Professional Documents
Culture Documents
He conducted written test on August 19, 2008 which contains fully technical questions
mainly covers full basics of all subjects except fluid mechanics and environ mental
engineering …..u must refer ur code 456:2000 with updated values………….
There are 64, 1 mark questions and 6, 2 marks questions and one question carries 15
marks….
Questions:
1. CPM network mainly comprises?
2. As per IS code, cement content is restricted to ________
3. Strength of field weld compared to shop weld?
4. CPM deals with____
5. PERT deals with____
6. Pile foundation fails mainly due to ______--
7. 20kn 40kn 20kn
B D F
A C E G H
Find the force in the member DE
8.show the bending moment diagram…..
45. Cripling
46. Failure in pile foundation occurs due to __________
Ans: ) punching shear
47. Lime is prepared from lime stone by the process of ____
48. What is the area of parabola____?
49. Pile foundations are preferred over ______
Ans:) raft foundation
50. Seggregation of concrete referred to ________
51. When artesian pressure area is required in under ground layer , which type of pile
foundation are used.
52. What is the most economical section under compression?
53. w/c is not effected by _____
54. Purlins are used for __
55. Well foundations are used in _______
56. Strength of reverts in pneumatic hammer
57. Efflorance
58. Bolts are preferred in which type of structures?
59. in a beam max. b.m. occurs at _______
60. Problem on amount of sand to be excavated from trench.
61. If b is deflected by δ . Then change in bending moment in b.m. diagram
62. Problem on ultimate bearing capacity, given factor of safety, find safe bearing
capacity.
62. Problem on critical gradient (quick sand condition)
63. in what direction water in quick sand flows?
64. Problem on trusses?
65. Problem on frames?
66. Use of the formula 3A1/ (3A1+4A2)
67. Questions on pre stressed concrete, limit state of design and working stress method
(mainly difference between the stresses used in each method)
H.R. questions:
1. Tell me about ur self?
2. How compressive strength of cement is tested?
3. Use of theodolite?
4. Find the r.l. of given point?
5. R u ready to work at any where in India?
6. Tell me about ur work, u did in training period.