Professional Documents
Culture Documents
IP-AK2
Access Control Unit
/
Installation and Configuration Guide
/
Fire Safety and Liability Notice: Never connect card readers to any critical entry, exit door,
barrier, elevator or gate without providing an alternative exit in accordance with all fire and
life safety codes pertinent to the installation. These fire and safety codes vary from city to
city and you must get approval from local fire officials whenever using an electronic product
to control a door or other barrier. Use of egress buttons, for example, may be illegal in
some cities. In most applications, single action exit without prior knowledge of what to do is
a life safety requirement. Always make certain that any required approvals are obtained in
writing. Verbal approvals are not valid.
Honeywell never recommends using WIN-PAK or related products for use as a primary
warning or monitoring system. Primary warning or monitoring systems should always meet
local fire and safety code requirements. The installer must also test the system on a regular
basis by instructing the end user in appropriate daily testing procedures. Failure to test a
system regularly could make installer liable for damages to the end user if a problem
Warnings occurs.
Earth ground all enclosures for proper installation.
Use suppressors on all door locks. Use S-4 suppressors for installation. Honeywell Access
Systems (HAS) recommends only DC locks.
Personal injury or death could occur, and the equipment could be damaged beyond repair,
if this precaution is not observed!
Before installation, turn off the external circuit breaker which supplies power to the
system, including door locks.
Before connecting the device to the power supply, verify that the output voltage is
within specifications of the power supply.
Do not apply power to the system until after the installation has been completed.
If any damage to the shipment is noticed, a claim must be filed with the commercial carrier
responsible.
Electro-static discharge (ESD) can damage CMOS integrated circuits and modules. To
prevent damage always follow these procedures:
Cautions Use static shield packaging and containers to transport all electronic components,
including completed reader assemblies.
Handle all ESD sensitive components at an approved static controlled workstation.
These workstations consist of a desk mat, floor mat and an ESD wrist strap.
Workstations are available from various vendors.
i
Honeywell
Limited Warranty
All product and brand names are the service marks, trademarks, registered trademarks,
or registered service marks of their respective owners. Printed in the United States of
America. Honeywell reserves the right to change any information in this document at any
time without prior notice.
All Products sold or licensed by Honeywell Access Systems (HAS) include a warranty
registration card which must be completed and returned to HAS by or on behalf of the
end user in order for Honeywell to provide warranty service, repair, credit or exchange.
All warranty work shall be handled through the Customer which shall notify Honeywell
and apply for a Return Merchandise Authorization (RMA) number prior to returning any
Product for service, repair, credit or exchange.
Honeywell warrants that its Products shall be free from defects in materials and
workmanship for a period of one year from date of shipment of the Product to the
Customer. The warranty on Terminals, Printers, Communications, Products and Upgrade
kits is 90 days from date of shipment. Satisfaction of this warranty shall be limited to
repair or replacement of Products which are defective or defective under normal use.
Honeywells warranty shall not extend to any Product which, upon examination, is
determined to be defective as a result of misuse, improper storage, incorrect installation,
operation or maintenance, alteration, modification, accident or unusual deterioration of
the Product due to physical environments in excess of the limits set forth in Product
manuals.
THERE ARE NO WARRANTIES THAT EXTEND BEYOND THIS PROVISION. THIS
WARRANTY IS IN LIEU OF ALL OTHER WARRANTIES WHETHER EXPRESS,
IMPLIED OR STATUTORY, INCLUDING IMPLIED WARRANTIES OF
MERCHANTABILITY OR FITNESS FOR ANY PARTICULAR PURPOSE. NO
REPRESENTATION OR WARRANTY OF THE DISTRIBUTOR SHALL EXTEND THE
LIABILITY OR RESPONSIBILITY OF THE MANUFACTURER BEYOND THE TERMS
OF THIS PROVISION. IN NO EVENT SHALL HONEYWELL BE LIABLE FOR ANY RE-
PROCUREMENT COSTS, LOSS OF PROFITS, LOSS OF USE, INCIDENTAL,
CONSEQUENTIAL OR SPECIAL DAMAGES TO ANY PERSON RESULTING FROM
THE USE OF HONEYWELL PRODUCTS.
ii
Honeywell
Contents
1 About This Document ..................................................................................................................................1
Overview of Contents.........................................................................................................................1
Special Font and Symbols .................................................................................................................2
How to Use This Document ...............................................................................................................2
2 Introduction..................................................................................................................................................3
IP-AK2 Access Control Panel ............................................................................................................4
Power Supply .....................................................................................................................................4
Battery................................................................................................................................................4
3 Installation ...................................................................................................................................................5
Mounting ............................................................................................................................................6
Wirings ...............................................................................................................................................8
Cabinet Wiring.............................................................................................................................8
Reader Wiring .............................................................................................................................9
Supervised Input Wiring ............................................................................................................10
Output Wiring ............................................................................................................................11
DIP Switch Settings..........................................................................................................................11
LED Status .......................................................................................................................................13
4 Connecting to IP-AK2 Access Control System..........................................................................................14
5 Configuring via IP-AK2 Web Server ..........................................................................................................15
Connecting to IP-AK2 Web Server...................................................................................................15
Connecting Panel to Computer .................................................................................................15
Configuring Network Connection...............................................................................................16
Login to IP-AK2 Web Server ............................................................................................................17
Security Alert .............................................................................................................................17
Login..........................................................................................................................................18
Configuring via Web Server .............................................................................................................19
Time Configuration ....................................................................................................................21
Panel Configuration...................................................................................................................23
Door Configuration ....................................................................................................................29
Access Configuration ................................................................................................................34
System Configuration ................................................................................................................40
Monitor .............................................................................................................................................43
Alarms .......................................................................................................................................43
Events .......................................................................................................................................44
Door View..................................................................................................................................45
Input View..................................................................................................................................45
Output View...............................................................................................................................46
System Status ...........................................................................................................................47
Report ..............................................................................................................................................47
6 Specifications and Panel Wiring ................................................................................................................48
Specifications ...................................................................................................................................48
IP-AK2 Panel Wiring Diagram..........................................................................................................49
7 Maintenance ..............................................................................................................................................50
8 Troubleshooting.........................................................................................................................................51
Appendix A Miscellaneous ...........................................................................................................................52
Basic Standalone Operations...........................................................................................................52
Card Read / Door Lock Operation.............................................................................................52
Door Egress / Door Lock / Door Status Operation ....................................................................52
IP-AK2 Panel Defaults .....................................................................................................................52
Reader Ports .............................................................................................................................52
Reader Tamper Inputs ..............................................................................................................53
Door Egress Inputs....................................................................................................................53
Door Status Inputs.....................................................................................................................53
AC FAIL and Panel Tamper Inputs ...........................................................................................54
Additional Generic Outputs .......................................................................................................54
i
Honeywell
Figures
Figure 2-1 IP-AK2 Access Control Unit ...................................................................................................................... 3
Figure 3-1 IP-AK2 Panel Cabinet - Top View ............................................................................................................. 6
Figure 3-2 IP-AK2 Panel Cabinet - Bottom View ........................................................................................................ 6
Figure 3-3 IP-AK2 Panel Cabinet - Left View ............................................................................................................. 7
Figure 3-4 IP-AK2 Panel Cabinet - Right View ........................................................................................................... 7
Figure 3-5 IP-AK2 Panel Cabinet - Back View ........................................................................................................... 8
Figure 3-6 Cabinet Wiring........................................................................................................................................... 9
Figure 3-7 Typical Supervised Input Wiring Diagram ............................................................................................... 10
Figure 3-8 LED Indicators......................................................................................................................................... 13
Figure 4-1 IP-AK2 Panel Connections in IP-AK2 Access Control System ............................................................... 14
Figure 5-1 IP-AK2 Web Server Hub Connection ...................................................................................................... 15
Figure 5-2 IP-AK2 Web Server Direct Connection ................................................................................................... 16
Figure 5-3 Local Area Connection Properties........................................................................................................... 16
Figure 5-4 Network Configuration............................................................................................................................. 17
Figure 5-5 Security Alert 1 ........................................................................................................................................ 17
Figure 5-6 Security Alert 2 ........................................................................................................................................ 18
Figure 5-7 Security Alert 3 ........................................................................................................................................ 18
Figure 5-8 Security Alert 4 ........................................................................................................................................ 18
Figure 5-9 IP-AK2 Web Server Login Page.............................................................................................................. 18
Figure 5-10 IP-AK2 Web Server Main Page............................................................................................................. 19
Figure 5-11 IP-AK2 System Configuration Flow Chart ............................................................................................. 20
Figure 5-12 Configuration Menu in IP-AK2 Web Server........................................................................................... 20
Figure 5-13 Time Zones Page .................................................................................................................................. 21
Figure 5-14 Current Loop Time ................................................................................................................................ 21
Figure 5-15 Update Loop Time................................................................................................................................. 21
Figure 5-16 Add Time Zone...................................................................................................................................... 21
Figure 5-17 Modify Time Zone.................................................................................................................................. 22
Figure 5-18 Holidays Page ....................................................................................................................................... 22
Figure 5-19 Add Holiday ........................................................................................................................................... 23
Figure 5-20 Modify Holiday....................................................................................................................................... 23
Figure 5-21 Select a Different Panel 1...................................................................................................................... 23
Figure 5-22 Select a Different Panel 2...................................................................................................................... 24
Figure 5-23 Panel Attributes Page............................................................................................................................ 24
Figure 5-24 Interlocks Page...................................................................................................................................... 26
Figure 5-25 Add Interlock ......................................................................................................................................... 26
Figure 5-26 Modify Interlock ..................................................................................................................................... 27
Figure 5-27 Data Management Page ....................................................................................................................... 28
Figure 5-28 Select a Different Door 1 ....................................................................................................................... 29
Figure 5-29 Select a Different Door 2 ....................................................................................................................... 29
Figure 5-30 Input Settings Page ............................................................................................................................... 30
Figure 5-31 Door Status 1 ........................................................................................................................................ 30
Figure 5-32 Door Status 2 ........................................................................................................................................ 30
Figure 5-33 Door Status 3 ........................................................................................................................................ 30
Figure 5-34 Output Settings Page ............................................................................................................................ 32
Figure 5-35 Reader Settings Page ........................................................................................................................... 32
Figure 5-36 Site Codes Page ................................................................................................................................... 34
Figure 5-37 Add Site Code ....................................................................................................................................... 34
Figure 5-38 Modify Site Code ................................................................................................................................... 34
Figure 5-39 Access Levels Page .............................................................................................................................. 35
Figure 5-40 Add Access Level.................................................................................................................................. 35
Figure 5-41 Modify Access Level.............................................................................................................................. 36
Figure 5-42 Card Formats Page ............................................................................................................................... 36
Figure 5-43 Card Format Data Layout...................................................................................................................... 37
Figure 5-44 Card Management Page ....................................................................................................................... 38
Figure 5-45 Add Card ............................................................................................................................................... 38
Figure 5-46 Modify Card ........................................................................................................................................... 39
ii
Honeywell
Figure 5-47 Search Card .......................................................................................................................................... 40
Figure 5-48 User Configuration Page ....................................................................................................................... 40
Figure 5-49 Add User ............................................................................................................................................... 40
Figure 5-50 Modify User ........................................................................................................................................... 41
Figure 5-51 Change Password 1 .............................................................................................................................. 41
Figure 5-52 Change Password 2 .............................................................................................................................. 41
Figure 5-53 Networking Settings Page ..................................................................................................................... 42
Figure 5-54 Web Configuration................................................................................................................................. 42
Figure 5-55 Unacknowledged/ Acknowledged Alarm Number ................................................................................. 43
Figure 5-56 Monitoring->Alarm ................................................................................................................................. 43
Figure 5-57 Monitoring->Alarms->Acknowledged .................................................................................................. 43
Figure 5-58 Monitoring->Events ............................................................................................................................... 44
Figure 5-59 Monitoring->Doors................................................................................................................................. 45
Figure 5-60 Door Action............................................................................................................................................ 45
Figure 5-61 Monitoring->Inputs ................................................................................................................................ 45
Figure 5-62 Input Action ........................................................................................................................................... 46
Figure 5-63 Monitoring->Outputs.............................................................................................................................. 46
Figure 5-64 Output Action......................................................................................................................................... 47
Figure 5-65 Monitoring->System Status ................................................................................................................... 47
Figure 5-66 Reports Page ........................................................................................................................................ 47
Figure 6-1 IP-AK2 Panel Wiring Diagram ................................................................................................................. 49
iii
Honeywell
Tables
Table 3-1 Cabinet Electrical Entries ........................................................................................................................... 6
Table 3-2 Reader Wiring............................................................................................................................................. 9
Table 3-3 Default Supervised Input Assignments..................................................................................................... 10
Table 3-4 DIP Switch Definition ................................................................................................................................ 11
Table 3-5 DIP Switch Settings .................................................................................................................................. 12
Table 5-1 Panel Attributes Description ..................................................................................................................... 25
Table 5-2 Interlock Settings Description ................................................................................................................... 26
Table 5-3 Database Categories................................................................................................................................ 27
Table 5-4 Auto Backup Description .......................................................................................................................... 28
Table 5-5 Input Settings Description......................................................................................................................... 31
Table 5-6 Output Settings Description...................................................................................................................... 32
Table 5-7 Reader Settings Description..................................................................................................................... 33
Table 5-8 Card Format Description .......................................................................................................................... 37
Table 5-9 Card Fields Description ............................................................................................................................ 38
Table 5-10 Networking Settings Description............................................................................................................. 42
Table 5-11 Alarms Field Descriptions....................................................................................................................... 44
Table 5-12 Alarms Field Descriptions....................................................................................................................... 44
Table 5-13 Door Icon Description ............................................................................................................................. 45
Table 8-1 Troubleshooting Problems and Solutions................................................................................................. 51
Table A-1 Default Reader Ports................................................................................................................................ 53
Table A-2 Default Reader Tamper Inputs................................................................................................................. 53
Table A-3 Default Door Egress Inputs ...................................................................................................................... 53
Table A-4 Default Door Status Inputs ....................................................................................................................... 53
Table A-5 Default AC FAIL and Panel Tamper Inputs.............................................................................................. 54
Table A-6 Additional Generic Outputs ...................................................................................................................... 54
iv
Honeywell
Overview of Contents
1
About This Document
Italic references
a button, tab or menu item
Note the important notice should pay attention to
Caution important operating alerted
Pictures in the manual are for reference only, so please see the actual items.
The products will be updated and the information shall not be distributed.
Please read the book before operation and keep it properly for future use.
The manual has been reviewed and the accuracy is guaranteed. If there is any
uncertainty or controversy, please refer to the final explanation of Honeywell.
Honeywell does not take any responsibility for any consequences caused by
misunderstanding of the manual or improper operations.
2
Honeywell
2 Introduction
The IP-AK2 Access Control Unit is one part of Access Control System (see Figure 4-1
IP-AK2 Panel Connections in IP-AK2 Access Control System on page 14), which
protects and preserves enterprises resources by providing authentication, authorization,
and administration services.
The IP-AK2 Access Control Unit consists of:
An IP-AK2 Access Control Panel
A Power Supply
A Sealed Lead-acid Battery
The following figure shows the IP-AK2 Access Control Unit components in the cabinet.
Figure 2-1 IP-AK2 Access Control Unit
Chassis Ground
Connected Cable
RS232
POWER SUPPLY
BATTERY
3
Introduction
The IP-AK2 Access Control Panel (shorted for IP-AK2 panel hereafter) is a two-reader
access controller that controls up to 2 doors by providing up to 8 inputs and 4 outputs. It
can be used as a stand-alone system (Up to 10 panels). User can configure and monitor
it through standard web browser. The IP-AK2 panel has the following features:
Real-Time Clock Protection
The panel RTC is backed up using a super capacitor, which will power the real-time
clock for one week in the absence of primary power or backup battery.
Memory Protection
The IP-AK2 panel continuously saves database and event information in non-volatile
FLASH memory. This activity prevents the panel from losing data when power is lost.
Reader Power
Reader power is supplied at 12VDC nominal with a maximum current distribution of
150mA. The maximum draw of two readers is less than 300mA.
Caution IP-AK2 panel and Reader Power must not be used to power locks.
Power Supply
The IP-AK2 panel uses an internal 220VAC (110VAC) to 12VDC regulated power supply
(Hengfu Model HF20W-SB-12). The supply uses 220VAC (110VAC), 60Hz, 0.2(0.4)Amp
input, and provides 12VDC at 1.5Amps for the system power. It also charges and
monitors the condition of the batteries.
Input power indicator is supplied for illuminating when board input voltage is present. If
the indicator is off, it means the input voltage is off or it is too low to operate the system.
Battery
For the IP-AK2 panel, one Long-way 6FM3.2AJ, 12VDC, 3.2AHr sealed lead-acid battery
(Honeywell order number 300-03271) must be used to have backup battery capability.
The battery will provide standby backup power, depending upon system configuration
and activity. The battery is wired and connected to the BAT and COM terminals on the
12VDC power supply in the IP-AK2 enclosure. When AC is lost, the power supply
automatically switches to the backup batteries for continuous 12VDC power.
The power supply has deep discharge protection, and it can shutdown battery backup
output when discharge voltage is below 9.4V. Refer to the system wiring diagram for
details. Replace the batteries every 2 to 2.5 years, or more often if the system has a high
rate of backup use.
4
Honeywell
3 Installation
Use a static strap whenever touching the panel to ensure protection from
Caution
Electrostatic Discharge (ESD).
Improper wiring can cause damage to the IP-AK2 panel when power up and
Caution
result in a loss of warranty.
7. Apply power to the panel, and then POWER LED will turn green meanwhile. The
POWER LED is close to 12VDC power connector (TB1). After several minutes,
RUN LED will flash per second. The RUN LED is close to 80-pin Connector (J2).
8. Place one 3.2A-Hr battery in the enclosure. Attach the positive (red) Power Supply-
to-Battery cable to the remaining positive (red) battery terminal; and the negative
(black) Power Supply-to-Battery cable to the remaining negative (black) battery
terminal.
For panels using the Ethernet connection, the cable clamp must be used for the
Note panel to pass the FCC Part 15 Class B requirements. Snap the clamp around
any portion of the Ethernet cable that is inside of the enclosure.
5
Installation
Mounting
The following five figures show the back, top, bottom, right, and left views of the IP-AK2
panel cabinet. Each view includes the dimensions and knockout placement to mount the
cabinet. See the table below for dimensions of the conduit entries into the cabinet.
Table 3-1 Cabinet Electrical Entries
Top 2 N/A
Bottom N/A 1
Right 2 N/A
Left 2 N/A
Back 1 N/A
78mm [3.071]
32.44mm [1.277]
0mm [0.000]
290mm [11.417]
125mm [4.921]
0mm [0.000]
0mm [0.000]
78mm [3.071]
6
Honeywell
Figure 3-3 IP-AK2 Panel Cabinet - Left View
78mm [3.071]
30mm [1.181]
0mm [0.000]
0mm [0.000]
55mm [2.165]
195mm [7.677]
340mm [13.386]
78mm [3.071]
0mm [0.000]
0mm [0.000]
55mm [2.165]
195mm [7.677]
340mm [13.386]
7
Installation
251.75mm [9.911]
144.92mm [5.706]
290mm [11.417]
38.25mm [1.506]
275mm [10.827]
15mm [0.591]
0mm [0.000]
18mm [0.709] 20mm [0.787]
10mm [0.394] Diameter (2 holes)
119mm [4.685]
221mm [8.701]
240mm [9.449] 240mm [9.449]
248mm [9.764]
260mm [10.236]
284mm [11.181]
262mm [10.315]
324.5mm [12.776]
2-N3
325mm [12.795]
235.06mm [9.254]
140mm [5.512]
160mm [6.299]
200mm [7.874]
97.1mm [3.823]
15mm [0.591]
76mm [2.992]
28mm [1.102]
48mm [1.890]
Wirings
This section describes how to wire the IP-AK2 panel cabinet, the reader, the supervised
input and output.
Cabinet Wiring
The picture below shows how to connect the IP-AK2 panel and the inputs, outputs,
power supply in cabinet.
8
Honeywell
Figure 3-6 Cabinet Wiring
Reader Wiring
Each reader port supports a single 12-volt reader with Wiegand output format. The
maximum power draw is 300 mA for readers.
To fully utilize each reader port, a shielded 7-conductor cable (18-22 AWG) is required. If
the optional reader buzzer feature is not needed, you can use the standard 6-conductor
cable. The cable shield should be grounded at the panel only. Grounding at both ends
can cause ground loops which can be disruptive. The maximum recommended length of
wiring is 500 feet per reader.
Table 3-2 Reader Wiring
9
Installation
The figure above shows the typical wiring for a supervised input using standard 2,200
ohm resistors. The IP-AK2 panel accepts 1,000, 2,200, 4,700, or 10,000 ohm values.
Note that both resistors must have the same value.
In addition, the Panel Tamper and External Power Fail can be supervised and capable of
being used as additional inputs if the default functionality is not needed. They also share
a single common.
Supervised input wiring must be used if Input 6 is used for External Power
Caution
Supply AC Failed.
10
Honeywell
The wire used for the inputs should be shielded and cannot exceed 20 ohms over the
entire length of the cable. Remember that the distance from the panel to the door must
be doubled to determine the total resistance.
The cable shield should be grounded only at the panel. Grounding at both ends
Caution
can cause ground loops disruptive.
Output Wiring
Relay 1 is defaulted for controlling Door 1 lock, Relay 2 is defaulted for controlling Door 2
lock, Relay 3 and Relay 4 are used as auxiliary outputs.
IP-AK2 panel is connected to the nominal 12VDC power supply and cannot be used to
power the access control door strikes/locks or other auxiliary loads. The voltage range of
the relay outputs is 12VDC to 28VDC.
Each relay also has a green indicator LED, which indicates the relay state. If the relay is
triggered, the LED will be on.
The cable used must be sized for the current load and should be shielded. Do
Caution
not bundle these wires with communication, reader, or supervised input wiring.
IP-AK2 panel includes 10 DIP switches. The table below shows DIP Switch Definition.
Table 3-4 DIP Switch Definition
6 ON/OFF Master/Slave
Position 1 to position 5, whose panel address from 1 to 31; they are must not been set 0,
which is invalid.
Position 6 will be set with the Host RS485 Master & Slave mode. For Multidrop RS-485
line, Position 6 MUST be set ON for RS-485 gateway in Master mode.
Position 7 and position 8 have four combinations. When both of them are OFF, it
means normal operation; When position 7 is ON and position 8 is OFF, it means the
11
Installation
default IP (192.168.1.150) and default user (admin) are retrieved to enter the system
when user account is forgotten; When position 7 is OFF and position 8 is ON, it
means the IP-AK2 panel is set to factory default; When both of them are ON, it is a
state reserved for manufacturer but useless for user.
Position 9 and position 10, which set end-of-line termination and biasing for the Multidrop
RS-485 Line. You must set both position 9 and position 10 to ON (terminated and
biased) at the two end-point panels for Multidrop RS-485 Line. At all other panels leave
position 9 and position 10 OFF. Note that both jumpers on a given panel must either be
ON or OFF.
Table 3-5 DIP Switch Settings
SW1.1 SW1.2 SW1.3 SW1.4 SW1.5 SW1.6 SW1.7 SW1.8 SW1.9 SW1.10 Selection
12
Honeywell
LED Status
When all of the wirings and DIP switch settings are finished, turn on the power. It will
take a few minutes for the panel to complete the power-up sequence. When the panel is
initializing, verify that the appropriate LED indicators identified in the figure are in accord
with the descriptions in the table below.
Figure 3-8 LED Indicators
OFF
FLASH
RED
GREEN Power On
LED
Power Off
N/A
N/A
PWR
Heart Beat
N/A
Running
RUN
No Com
Data
TX & RX
Data
Receive
Data
Transmit
485TR
LED Status
No Com
Data
TX & RX
Data
Receive
Data
Transmit
RS232
No link
Data
TX & RX
Link OK
N/A
Ethernet
De-energized
N/A
N/A
Energized
RELAY
Reader Off
Read
Flash at
N/A
Read
Flash at
Reader
13
Connecting to IP-AK2 Access Control System
Ethernet
100 BaseT (CAT 5) 328Ft (100 Meter).
Max
RS-485 Multidrop
DIP Switch Setting
DIP Switch Setting SW1-SW5: Panel
SW1-SW5: Panel Address
Address SW6: OFF: Slave
SW6: OFF: Slave SW9-SW10: OFF
SW9-SW10: ON
EG EG EG EG
14
Honeywell
IP-AK2 panel is a two-reader access controller with built-in web server. Through
standard web browser, up to 20 doors can be controlled and monitored.
IP-AK2 panel supports two kinds of web browsers:
Internet Explore 6.0
Firefox 3.0
If not noticed, all operations in this manual are performed in Internet Explore 6.0.
Note All function tests have been passed using web browser in Windows XP
Professional. Do not guarantee web browser compatibility in other operation
system.
Before connecting to the IP-AK2 Web Server, The IP-AK2 panel must be connected to
the Computer first, and then the network connection should be configured.
IP-AK2
Ethernet
Cable
Ethernet Hub
15
Configuring via IP-AK2 Web Server
IP-AK2
The IP-AK2 panel connected is the Master panel. DIP switch 6 on a Master panel
Note
must be set to ON.
Note Keep a record of your computers current network configuration for future use.
16
Honeywell
Figure 5-4 Network Configuration
IP address: 192.168.1.10
Subnet mask: 255.255.255.0
Default gateway: 192.168.1.1
Security Alert
Before logging into the IP-AK2 Web Server, there may be security alert messages
popping up to ensure security safe, and according to different web browsers, the security
alert windows will be different.
17
Configuring via IP-AK2 Web Server
Firefox 3.0
1. Launch the Firefox browser and enter https://192.168.1.150 in the address bar.
Press Enter, the Security Connection Failed window below will pop up, see below:
Figure 5-6 Security Alert 2
Login
After resolving the security problem, the IP-AK2 Web Server Login page will show up.
Figure 5-9 IP-AK2 Web Server Login Page
18
Honeywell
1. Enter user name and password.
This section explains the IP-AK2 configuration functions as accessed via the IP-AK2
Web Server. The menus on Configuration tab in IP-AK2 Web Server are arranged
according to the recommended configuration sequence, you can configure them from top
to bottom one by one These functions should be performed only by administrator.
19
Configuring via IP-AK2 Web Server
20
Honeywell
Time Configuration
Time Zones
The IP-AK2 panel controls access by time zones, or time schedules. Inputs, outputs,
readers, and cards with access levels are all configured with time zones by which they
will be energized or de-energized, enabled or disabled. For example, you might assign
an output to be energized from 12:00 a.m. to 6:00 p.m. every day. The time period, 12:00
a.m. to 6:00 p.m., Sunday through Saturday, is called a time zone.
ClickTime Zoneson Configuration tab to view existing time zones, change the
current loop, create a new time zone, modify an existing time zone, or delete time zones.
Figure 5-13 Time Zones Page
Synchronize with PCprovides an easy way to update loop time the same as the PC
time. Click the hyperlink in the Current Loop Time field to popup a time editing window,
on which the loop time can be updated.
Figure 5-15 Update Loop Time
21
Configuring via IP-AK2 Web Server
Link to Time Zone: select desired time zone from the drop-down list.
Start Time: enter the start time of the new time zone.
End Time: enter the end time of the new time zone.
Days: select weekdays during which the time zone will take effect.
Holiday Set: select holiday sets during which the time zone will take effect.
3. ClickOKto create a new time zone.
Holidays
Click Holidays on the Configuration tab, and then view existing holidays, create a new
holiday, modify an existing holiday, or delete holidays.
Figure 5-18 Holidays Page
Creating Holiday
1. ClickAdd Holidayabove the list, the page below will pop up:
22
Honeywell
Figure 5-19 Add Holiday
Modifying Holiday
1. Click the name of the holiday to be modified, the page below will pop up:
Figure 5-20 Modify Holiday
Deleting Holidays
1. Check all the boxes in front of the holidays to be deleted in the list.
2. ClickDeleteabove the list.
3. ClickOKon the prompt window.
Panel Configuration
Current Panel
Make sure you are configuring the correct panel. The horizontal bar shown on the top of
Panel Attributes page, Interlocks page, and Data Management page shows the panel
number that you are configuring currently.
Figure 5-21 Select a Different Panel 1
You can change the current panel by clickingSelect a different panel, then select a
panel from the page pops up.
23
Configuring via IP-AK2 Web Server
All active panels in current loop will be shown as hyperlinks. The content of the hyperlink
is the name of the panel with the loop address in bracket.
Panel Attributes
Click Panel Attributes on the Configuration tab, the page below will show up. You can
configure panel settings, input and output settings.
Figure 5-23 Panel Attributes Page
Refer to the table below for description of each filed and make changes.
24
Honeywell
Table 5-1 Panel Attributes Description
Setting Description
Interlocks
An interlock is a programmed connection between two points. An action on one point will
cause a reaction from the other point on the same panel. For example, when press
egress input, it causes a relay (output) to energize.
Click Interlocks on Configuration tab and the page below will pop up. You can create
and delete interlocks, enable or disable existing interlocks.
25
Configuring via IP-AK2 Web Server
Creating Interlock
1. ClickAdd Interlockabove the list, the page below will pop up:
Figure 5-25 Add Interlock
Setting Description
Modifying Interlock
1. Click the name of the interlock to be modified, the page below will pop up:
26
Honeywell
Figure 5-26 Modify Interlock
Disable/Enable Interlocks
Click Disable/Enable hyperlink at the end of the row to disable/enable an interlock.
Deleting Interlocks
1. Check all the boxes in front of the interlocks to be deleted in the list.
2. ClickDeleteabove the list.
3. ClickOKon the prompt window.
Data Management
All configurations will be saved in panels database. On this page, you can download
database from a panel or upload database to a panel overwriting existing data. The page
is especially useful when changing a panel already been configured successfully.
All configuration data can be saved into three databases:
Table 5-3 Database Categories
Category Description
27
Configuring via IP-AK2 Web Server
Download
Click theDownloadhyperlink of a category to download the database file from panel
to computer..
Upload
Click theBrowsebutton to select the database file from computer to upload it.
Click theUploadbutton to send the database to the panel.
Auto-Backup
Alarms and events record what had happened in the system. It is important for accident
analysis. Due to memory limit, old alarms or events will be overwritten. IP-AK2 provides
event auto-backup mechanism to avoid event lost. When auto-backup function is
enabled, event and alarm will be transferred to remote ftp server automatically when
threshold value user defined is reached. For enabling auto-backup function successfully,
user should provide ftp server address and authority information.
Refer to the table below for the auto-backup configuration description:
Table 5-4 Auto Backup Description
Setting Description
28
Honeywell
Setting Description
Specifies the auto backup action trigger. If the number of event in the
database reaches the threshold, the database will be updated.
Percent
For example, if its set to 80%, then uploading happens when the number of
events reaches 20000 (thats 80% * 25000(system default)).
Clear Database Specifies if event database of panel is cleared after its auto backup is done.
Export
Alarm and event can be exported manually, and the database will be cleared.
To export data:
1. ClickExportbutton.
2. ClickOKon the pop-up window.
Door Configuration
Each IP-AK2 panel supports two doors. For each door, you must configure the readers,
inputs and outputs.
Current Door
Make sure you are configuring the correct door. The horizontal bar shown on the top of
Input Settings page, Output Settings page, and Reader Settings page shows the door
number that you are configuring currently.
Figure 5-28 Select a Different Door 1
You can change the current door by clickingSelect a different door, then select a
door from the page pops up.
Figure 5-29 Select a Different Door 2
Input Settings
Three inputs are associated with door:
Status - Provides the following door status information:
o Normal: indicates that the door state is currently in its normal state, either
Normally Opened or Normally Closed.
o Alarm: indicates that the doors state is currently in its abnormal state: if the
door is configured as Normally Open, its abnormal state is close; if the door is
configured as Normally Close, its abnormal state is open.
o Shorted (supervised input only): indicates that electrical circuit on the door has
been short-circuited.
29
Configuring via IP-AK2 Web Server
o Cut (supervised input only): indicates that the electrical circuit on the door has
been cut or disconnected.
Egress
Tamper - Indicates abnormal handling of the reader device.
Figure 5-30 Input Settings Page
There are four possible mode configurations. The figure above shows the normally
Closed/Unsupervised mode. The following figures show the remaining modes.
Figure 5-31 Door Status 1
30
Honeywell
Specify the Status, Egress and Tamper Debounce time, or the period of time when
the input must remain in new state before it is recognized.
Specify the time zones for the Status, Egress and Tamper inputs.
Enable or disable Auto-Relock for the Status input.
Refer to the table below to configure Status, Egress and Tamper inputs.
Table 5-5 Input Settings Description
Setting Description
Output Settings
An output, or output relay, is a switch on the panel that either energizes or de-energizes
or pulses an output device, such as a door lock or a horn. For example, a successful
card read at a reader (input device) causes the output relay switch on the panel board to
change the normal state of a door lock (output device), so that the normally-locked door
strike releases and permits entry.
31
Configuring via IP-AK2 Web Server
Setting Description
Output Number Specifies the number of out point to be occupied by the door.
Output Name The unique name identifies the device.
Specifies the duration for which the device will assume abnormal status.
For example, it specifies how long a horn will blow or a door strike will
remain released. Enter the desired number of hours (1 maximum), minutes
Pulse Time
(60 maximum), and seconds (60 maximum). The sum of all three units
comprises the pulse time. Note that you can express seconds in tenths of
a second.
Energized Sets the period during which the output switches are
automatically energized.
Time Zone
Disable Interlock - Specifies the time period during which the
programmed action on this input from another point will be disabled.
ClickUpdateto submit changes.
Reader Settings
A reader is a device that reads cards and either grants or denies access at the door.
Figure 5-35 Reader Settings Page
32
Honeywell
Define the time zone during which the reader will be disabled. When the reader is
disabled, neither exit nor entry by Card and PIN mode or Card or PIN mode is
allowed.
Define the time zone during which the reader will be in lockdown mode. When the
reader is in lockdown mode, entry is prevented but egress is still allowed.
Define the readers access mode (the combination of card and/or PIN entry required
by the reader). Note that the access mode defined here for the door can be
overridden by a card assigned with a VIP card type (see Creating Card on page 38
for assigning a VIP card type).
Configure the anti-passback feature. When enabled, the anti-passback feature
prevents an entrant to an area from passing his card back to another potential
entrant. Note that anti-passback must first be enabled on the Panel Attributes page.
Refer to the descriptions in the table below to configure reader:
Table 5-7 Reader Settings Description
Setting Description
33
Configuring via IP-AK2 Web Server
Access Configuration
Site Codes
Site Codes identify enterprise sites. Up to 8 site codes can be served as secondary card
IDs (in addition to the card number) for additional validation.
Click Site Codes on Configuration tab and the page below displays. You can view
existing site codes, create a new site code, modify an existing site code, and delete them.
Figure 5-36 Site Codes Page
34
Honeywell
2. Change site code settings.
3. ClickOKto accept changes.
Access Levels
The access level specifies the time zone, or time schedule, during which the card holder
can be granted access at specific doors. For example, an access level embedded in an
employees card might allow the employee to enter the facility only through door 2 from
6:00 a.m. to 6:00 p.m., Monday through Friday.
Note Door and Time Zone must be configured before configuring an access level.
Click Access Levels to display the page below and view existing access levels, create a
new access level, modify an existing access level, or delete access levels.
Figure 5-39 Access Levels Page
35
Configuring via IP-AK2 Web Server
Time Zone: select the time zone from the drop-down list
Associated Doors: select the door(s). Card holders with this access level can only
access selected door(s) during selected time zone.
3. ClickOK.
Card Formats
Click Card Formats to display the page below, then you can create and delete card
formats, enable or disable existing card formats.
Figure 5-42 Card Formats Page
36
Honeywell
Figure 5-43 Card Format Data Layout
2. Refer to the descriptions in the following table to configure card format settings.
Table 5-8 Card Format Description
Setting Description
37
Configuring via IP-AK2 Web Server
Card Management
Card is encoded with a unique number. When swiping a card with valid card number, the
card holder would be granted access to certain doors during a certain time.
Click Card Management and the page below will display, and then you can view existing
cards, create new card, modify an existing card, delete cards, and search cards.
Figure 5-44 Card Management Page
Creating Card
1. ClickAdd Cardbelow the list to open the page below:
Figure 5-45 Add Card
2. Refer to the field descriptions in the following table to complete the card fields.
Table 5-9 Card Fields Description
Setting Description
38
Honeywell
Setting Description
Identifies the card holder. A card holders name includes first name
Card Holder Name
and last name. Each name supports up to 25 characters.
Specifies whether the card holder is an employee, VIP, or a
Card Type
temporary employee (Temp). A card type is required.
Specifies the date that a temp card is activated. Note that this field is
Activation
active only when the Card Type is set to Temp.
Specifies the date that a temp card is de-activated. Note that this field
Expiration
is active only when the Card Type is set to Temp.
Specifies the Personal Identification Number (PIN) for the card
holder. A PIN is optional; however, if the door reader is configured to
PIN require PIN identification, then you must create a PIN for the card
holder here.
The PIN number has a maximum of six digits.
Specifies the number of times the card can be successfully treated as
NO. of uses
valid on a panel.
If its checked, the card will be granted access without input PIN code
Pin Not Required
even if PIN is required in reader mode.
Specifies the time zone, or time schedule, during which the card
Access Level holder can be granted access at specific doors. Up to 32 access
levels can be supported by one card.
Sends an alarm message to the alarm monitor whenever a card with
Trace trace enabled is presented at a reader. This feature provides a trace
of the cardholders path through the facility.
3. ClickOK.
Modifying Card
1. Click the name of a card to be modified to select it, and clickEdit Cardbelow
the list to open the page below:
Figure 5-46 Modify Card
Deleting Card
1. Click the name of a card to select it.
2. ClickDelete Cardbelow the list.
39
Configuring via IP-AK2 Web Server
Searching Card
1. Check theSearch Modeabove the card list to active search mode.
2. Enter desired criteria and clickSearch, then the result will be shown.
Figure 5-47 Search Card
You can use wild char (*) in first name and last name field to do fuzzy search. For
Note
example, use Chun* will return card 17900.
System Configuration
User Configuration
Only User with the following roles can use the IP-AK2 Web Server:
Administrator - Configures and monitors the IP-AK2 System.
Operator - Monitors and operate the system.
Click User Configuration to display the User Configuration page, then you can view
existing users, create a new user, modify an existing user, and delete users.
Figure 5-48 User Configuration Page
Creating User
1. ClickAdd Userabove the list, the page below will pop up:
Figure 5-49 Add User
40
Honeywell
Role: select the user role, either administrator or operator.
Account State: select account state. Only a user in Enable state can log into the
system.
3. ClickOKto create this user.
Modifying User
1. Click the name of the user to be modified in the list to open the page below:
Figure 5-50 Modify User
Deleting Users
1. Check all the boxes in front of the users to be deleted in the list.
2. ClickDeleteabove the list.
3. ClickOKon the prompt window.
Changing Password
1. ClickChange Passwordon the top right corner of the page.
Figure 5-51 Change Password 1
3. Input current password, and then input new password and confirm it.
4. ClickOK.
Network Settings
Click Networking Settings to display the page below, then you can view and edit the
panel IP address, subnet mask, default gateway, and configure the loop baud rate for
communication among downstream panels.
41
Configuring via IP-AK2 Web Server
1. Refer to the table below for field descriptions and make corresponding changes.
Table 5-10 Networking Settings Description
Setting Description
IP Address IP address
Networking Subnet Mask subnet mask
Default Gateway default gateway
Specifies the transmission rate (bits per second) among
Baud Rate
Loop the downstream panels in the loop.
Panel ID The address of the master panel in the loop.
Web Configuration
Click Web Configuration to display web configuration page and edit Session Timeout
setting.
Figure 5-54 Web Configuration
42
Honeywell
Monitor
The following IP-AK2 panel status can be monitored:
Alarms one type of event, which has been assigned with alarm status. These
often include events such as an invalid card read or a forced door.
Events the recorded transactions of the IP-AK2 system. For example, an event
card found, number of users logged in.
Doors an overview of all doors status in the system in graphical manner.
Inputs terminals located on the IP-AK2 panel; the inputs are wired to input points,
such as a card reader, elsewhere in the IP-AK2 system.
Outputs switches located on the IP-AK2 panel that are connected to output
devices, such as a door lock, elsewhere in the IP-AK2 system.
System Status IP-AK2 system status.
Alarms
Alarms are system-generated messages that indicate the need for user attention. Select
Monitoring Alarms and all unacknowledged alarms will display.
Figure 5-55 Unacknowledged/ Acknowledged Alarm Number
Check the box before the alarms and acknowledge the selected alarms.
Figure 5-56 Monitoring->Alarm
43
Configuring via IP-AK2 Web Server
Provides the date and exact time the alarm was generated according
Time
to the panels time.
Panel ID The loop address of the panel that generates the alarm.
Event Point The unique number assigned to the device on the IP-AK2 panel.
Event Point Name The name assigned to the device on the IP-AK2 panel.
Description Description of the alarm.
Card Number Identifies the card number.
Identifies the last name of the card holder who energized the input
Card Holder
device when the alarm was generated.
Events
Both panel-generated and web-generated events (for example, reading a card is a panel
event and user login is a web event.) can be monitored on Events page.
Figure 5-58 Monitoring->Events
Time Provides the date and exact time the alarm was generated.
Panel ID The loop address of the panel that generates the event.
Event Point The unique number assigned to the device on the IP-AK2 panel.
Event Point Name The name assigned to the device on the IP-AK2 panel.
Description Description of the event.
Card Number Identifies the card number.
Identifies the last name of the card holder who energized the input
Card Holder
device when the event was generated.
44
Honeywell
Door View
All door status on the panel will be shown on Door View. In addition, some basic control
functions are provided on this page, such as Open/Close, Temporarily Open,
Restore to Time Zone.
Figure 5-59 Monitoring->Doors
Icon Description
Input View
The inputs status of all live panels will be shown on Input View. In addition, some basic
input control functions are provided on this page, such as Shunt Input Status and
Restore to Time Zone.
Figure 5-61 Monitoring->Inputs
45
Configuring via IP-AK2 Web Server
Output View
The outputs status of all live panels will be shown on Output View. In addition, some
basic output control functions are provided on this page, such as Change Output Status
and Pulse as well as Restore to Time zone.
Figure 5-63 Monitoring->Outputs
46
Honeywell
4. To reset the output behavior according to its configured time zone, click the
Restore to Time Zone. ClickOKto restore the time zone.
Figure 5-64 Output Action
System Status
IP-AK2 system basic information can be monitored on this page, including:
Existing: Number of currently configured items.
Capacity: Maximum number of items that can be configured.
Figure 5-65 Monitoring->System Status
Report
The IP-AK2 system can generate the following reports (they can be downloaded to the
computer by clicking the report icon):
Alarms & Events Report
Event Definition
Cards Report
Figure 5-66 Reports Page
47
Specifications and Panel Wiring
Specifications
Specification Parameters
Relay Contacts Four Form-C SPDT relays, 3A @ 28VDC (external PTC preferred)
Voltage: 12VDC nominal
Power
Current: 300mA combined with two readers
LED Output Open collector driver capable of sinking up to 8mA
Tamper Supervised or non-supervised input
Data Input TTL compatible inputs
Reader Interface Buzzer Output Open collector driver capable of sinking 8mA at 12VDC
Honeywell JT-MCR MIFARE Smart READERS
Honeywell HON-MSR MIFARE SECTOR READERS
Reader Type HONEYWELL OmniProx PROXIMITY READERS
Honeywell OmniClass SMART READERS
Honeywell HON-FIN3000 Fingerprint
Reader 150mA (any of the two reader outputs)
150mA (battery charge current for the battery wired in
Maximum Output Loading Battery
series)
Total 300mA (combined current of the two reader outputs)
The common connections of supervised input are all connected internally. They are
not connected to the panel chassis.
Common Connections
The common connections of relay output are NOT all connected internally, which are
NOT connected to the panel chassis.
Height: 340mm (13.4inches)
Enclosure Dimension Width: 290mm (11.4inches)
Mechanical
Depth: 78mm (3.1inches)
Enclosure Weight 5Kg (11lbs), with one battery
Operating: 0C ~ 50C
Temperature
Environment Storage: -55C ~ +85C
Humidity 5% ~ 85% RHNC
Shield, cat5 to RJ-45 330inches (100m)
Ethernet
(Maximum 10 panels) (Maximum Distance)
500 inches (153 m)
Readers 7-Conductor, Shielded
(Maximum Distance)
Cable
2,000 inches (610 m)
Supervisor Input Twisted Pair, Shielded
(Maximum Distance)
2,000 inches (610 m)
Relay Outputs Twisted Pair, Shielded
(Maximum Distance)
48
Honeywell
49
Maintenance
7 Maintenance
Caution Make sure AC power is disconnected before removing the Power Supply cover.
50
Honeywell
8 Troubleshooting
Problem Solution
51
Miscellaneous
Appendix A Miscellaneous
Reader Ports
The panel accepts a Wiegand serial data packet from the card reader. If the card is in
the database, the associated relay is activated. If the card is not in the database, the
relay state is unchanged.
The followings are the default reader ports to relay associations:
52
Honeywell
Table A-1 Default Reader Ports
1 Relay 1 (Output 1)
2 Relay 2 (Output 2)
Tamper 1 Input 7
Tamper 2 Input 8
1 1 SUP1 Input 1
2 2 SUP3 Input 3
1 SUP2 Input 2
2 SUP4 Input 4
53
Miscellaneous
3 Output 3
4 Output 4
54
Honeywell
WIN-PAK
S-4 HAS
DC
ESD CMOS
ESD
ESD
i
Honeywell
1 ...................................................................................................................................................1
.............................................................................................................................................1
..................................................................................................................................2
....................................................................................................................................................2
2 .............................................................................................................................................................3
IP-AK2 .............................................................................................................................4
....................................................................................................................................................4
....................................................................................................................................................4
3 .............................................................................................................................................................5
.............................................................................................................................................6
....................................................................................................................................................8
......................................................................................................................................8
..................................................................................................................................9
.............................................................................................................................10
....................................................................................................................................11
DIP ....................................................................................................................................11
LED ..........................................................................................................................................13
4 IP-AK2 .....................................................................................................................14
5 IP-AK2 Web Server ...................................................................................................................15
IP-AK2 Web Server ..............................................................................................................15
IP-AK2 .....................................................................................................15
..................................................................................................................16
IP-AK2 Web Server ..............................................................................................................17
....................................................................................................................................17
...........................................................................................................................................18
IP-AK2 Web Server ..........................................................................................................19
....................................................................................................................................21
................................................................................................................................23
........................................................................................................................................28
....................................................................................................................................32
....................................................................................................................................39
IP-AK2 ..............................................................................................................................42
...........................................................................................................................................42
...........................................................................................................................................43
........................................................................................................................................43
....................................................................................................................................44
....................................................................................................................................45
....................................................................................................................................46
..................................................................................................................................................46
6 ...........................................................................................................................47
...........................................................................................................................................47
IP-AK2 .......................................................................................................................48
7 ...........................................................................................................................................................49
8 .........................................................................................................................................50
A ....................................................................................................................................51
....................................................................................................................................51
/ ........................................................................................................................51
/ / ..................................................................................................51
IP-AK2 ....................................................................................................................51
i
Honeywell
................................................................................................................................51
.........................................................................................................................52
.............................................................................................................................52
................................................................................................................................52
................................................................................................53
.............................................................................................................................53
ii
Honeywell
iii
Honeywell
5-40 .............................................................................................................................................. 34
5-41 .............................................................................................................................................. 34
5-42 ................................................................................................................................................. 35
5-43 .......................................................................................................................................... 35
5-44 ................................................................................................................................................. 36
5-45 ................................................................................................................................................. 37
5-46 ......................................................................................................................................................... 37
5-47 ......................................................................................................................................................... 38
5-48 ......................................................................................................................................................... 38
5-49 .............................................................................................................................................. 39
5-50 ..................................................................................................................................................... 39
5-51 ..................................................................................................................................................... 40
5-52 1 .................................................................................................................................................. 40
5-53 2 .................................................................................................................................................. 40
5-54 .............................................................................................................................................. 41
5-55 ..................................................................................................................................................... 41
5-56 / .................................................................................................................................. 42
5-57 ->.................................................................................................................................................. 42
5-58 ->-> ................................................................................................................................. 42
5-59 ->.................................................................................................................................................. 43
5-60 -> ..................................................................................................................................................... 44
5-61 ......................................................................................................................................................... 44
5-62 ->.................................................................................................................................................. 44
5-63 ..................................................................................................................................................... 45
5-64 ->.................................................................................................................................................. 45
5-65 ..................................................................................................................................................... 45
5-66 ->........................................................................................................................................... 46
5-67 ..................................................................................................................................................... 46
6-1 IP-AK2 .................................................................................................................................... 48
iv
Honeywell
3-1 .................................................................................................................................................. 6
3-2 ..................................................................................................................................................... 9
3-3 ......................................................................................................................................... 10
3-4 DIP ................................................................................................................................................. 11
3-5 DIP ................................................................................................................................................. 12
5-1 ............................................................................................................................................ 25
5-2 ................................................................................................................................................ 26
5-3 ................................................................................................................................................... 27
5-4 ................................................................................................................................................ 28
5-5 ................................................................................................................................................ 30
5-6 ................................................................................................................................................ 31
5-7 ............................................................................................................................................ 32
5-8 ................................................................................................................................................... 35
5-9 ................................................................................................................................................... 37
5-10 .............................................................................................................................................. 41
5-11 .............................................................................................................................................. 43
5-12 .............................................................................................................................................. 43
5-13 ................................................................................................................................................. 44
8-1 ............................................................................................................................................ 50
A-1 ............................................................................................................................................ 52
A-2 ..................................................................................................................................... 52
A-3 ........................................................................................................................................ 52
A-4 ............................................................................................................................................ 52
A-5 ................................................................................................................... 53
A-6 ............................................................................................................................................... 53
v
Honeywell
IP-AK2
IP-AK2
1 IP-AK2
2 IP-AK2 IP-AK2
3 IP-AK2 DIP
4 IP-AK2 IP-AK2
5 IP-AK2 Web ServerIP-AK2 Web ServerIP-
AK2
6 IP-AK2
7
8
AIP-AK2
Honeywell
Honeywell
2
Honeywell
IP-AK2 IP-AK2
14 4-1 IP-AK2 IP-AK2
IP-AK2
IP-AK2
IP-AK2
2-1 P-AK2
IP-AK2
IP-AK2 IP-AK2
2 8 4 10 IP-AK2
IP-AK2
IP-AK2
IP-AK2
12VDC150mA 300mA
IP-AK2
6FM3.2AJ12VDC3.2AHr 300-
03271 IP-AK2
12VDC BAT COM AC
12VDC
9.4V
2 2.5
4
Honeywell
IP-AK2
ESD
1.
2.
3. I/O
48 6-1 IP-AK2
220VAC/60Hz12VDC/
6.35mm
4.
5. DIP12 3-5 DIP
6.
IP-AK2
FCC 15 Class B
IP-AK2
3-1
130mm 240mm
2 N/A
N/A 1
2 N/A
2 N/A
1 N/A
3-1 IP-AK2
30mm [1.181]
78mm [3.071]
32.44mm [1.277]
0mm [0.000]
290mm [11.417]
125mm [4.921]
0mm [0.000]
3-2 IP-AK2
290mm [11.417]
255mm [10.039]
35mm [1.378]
0mm [0.000]
0mm [0.000]
78mm [3.071]
30mm [1.181]
6
Honeywell
3-3 IP-AK2
78mm [3.071]
30mm [1.181]
0mm [0.000]
55mm [2.165]
30mm [1.181]
195mm [7.677]
340mm [13.386]
3-4 IP-AK2
30mm [1.181]
78mm [3.071]
0mm [0.000]
0mm [0.000]
55mm [2.165]
30mm [1.181]
195mm [7.677]
340mm [13.386]
3-5 IP-AK2
251.75mm [9.911]
290mm [11.417]
15mm [0.591]
0mm [0.000]
18mm [0.709] 20mm [0.787]
10mm [0.394] ()
119mm [4.685]
40mm [1.575]
221mm [8.701]
240mm [9.449] 240mm [9.449]
248mm [9.764]
260mm [10.236]
284mm [11.181]
262mm [10.315]
324.5mm [12.776]
2-N3
325mm [12.795]
235.06mm [9.254]
140mm [5.512]
160mm [6.299]
200mm [7.874]
97.1mm [3.823]
15mm [0.591]
76mm [2.992]
28mm [1.102]
48mm [1.890]
IP-AK2
IP-AK2
8
Honeywell
3-6
Wiegand 12V
300mA
7-18-22AWG
6-
152.4m500inch
3-2
Wiegand
Wiegand
TB5-6 6-6
TB5-7 6-7
TB5TB6TB7 TB8 1 4
TB7 5 6 TB8 7 8 TB5 TB6
3-3
TB7-1 1 1
TB7-3 2 1
TB7-4 3 2
TB7-6 4 2
TB8-1 5
TB8-3 6
3-7
20ohms
10
Honeywell
1 1 2 2 3-4
IP-AK2 12VDC
12VDC28VDC
LED LED
DIP
DIP
1-5 (1 ~ 31)
6 ON/OFF /
ON OFF IP
OFF ON
7-8
ON ON
OFF OFF
1 5 1~31 0
6 RS485 6 ON RS-
485
7 8 OFF 7
ON8 OFF IP(192.168.1.150)
(admin) 7 OFF8
ON IP-AK2 ON
11
9 10 RS-485
ONOFFON
OFF
3-5 DIP
SW1.1 SW1.2 SW1.3 SW1.4 SW1.5 SW1.6 SW1.7 SW1.8 SW1.9 SW1.10
12
Honeywell
13
LED
LED
LED PWR RUN 485TR RS232
3-8 LED
N/A
N/A N/A N/A N/A
N/A N/A
LED
IP-AK2
4 IP-AK2
IP-AK2
IP-AK2
IP-AK2
IP-AK2 IP-AK2
4-1 IP-AK2 IP-AK2
100 BaseT (CAT 5) 328Ft (100 Meter).
Max
RS-485 DIP
SW1-SW5: IP-AK2
RS485 IP-AK2 SW6: ON:
SW9-SW10: ON
/ TB9-6 (RS485+)
/ TB9-5 (RS485-)
RS-485 COM TB9-4 (RS485 COM)
RS-485
DIP
DIP SW1-SW5:
SW1-SW5: SW6: OFF:
SW6: OFF: SW9-SW10: OFF
SW9-SW10: ON
IP-AK2
(EG)
EG EG EG EG
RS-485 10
14
Honeywell
IP-AK2 IP-AK2
20
IP-AK2
Internet Explore 6.0
Firefox 3.0
IP-AK2
IP-AK2
5-1
IP-AK2
IP-AK2
15
IP-AK2 Web Server
5-2
IP-AK2
IP-AK2
IP-AK2 DIP 6
ON
1.
2.
5-3
3. Internet ProtocolTCP/IP
4. IP
16
Honeywell
5-4
IP 192.168.1.10
255.255.255.0
192.168.1.1
5.
17
IP-AK2 Web Server
Firefox 3.0
1. Firefox 3.0 https://192.168.1.150Enter
5-6
2.
5-7
3.
5-8
IP-AK2 Web Server
5-9 IP-AK2 Web Server
1.
18
Honeywell
adminadmin
IP-AK2
19
IP-AK2 Web Server
5-11 IP-AK2
20
Honeywell
IP-AK2
12
6 12 6
5-13
5-14
5-15
1.
5-16
2.
21
IP-AK2 Web Server
3.
1.
5-17
2.
3.
1.
2.
3.
5-18
1.
22
Honeywell
5-19
2.
3.
1.
5-20
2.
3.
1.
2.
3.
5-21 1
23
IP-AK2 Web Server
5-22 2
5-23
24
Honeywell
5-1
DIP
IP-AK2
IP-AK2
IP-AK2
+
+
1 1 2222
2221 2223
LED
/ 29
5-24
25
IP-AK2 Web Server
1.
5-25
2.
5-2
1.
5-26
2.
3.
26
Honeywell
1.
2.
3.
5-3
5-27
27
IP-AK2 Web Server
IP-AK2
FTP
FTP
5-4
FTP FTP IP
FTP
FTP
FTP
80% 2000080%*
25000
IP-AK2
5-28 1
5-29 2
28
Honeywell
IP-AK2
o
o
o
o
5-30
/
5-31 /
5-32 /
29
IP-AK2 Web Server
5-33 /
5-5
1024 60 60
5
5
5-34
30
Honeywell
5-6
1 60 60
5-35
+
/
36
31
IP-AK2 Web Server
5-7
+
+
8 ID ID
5-36
32
Honeywell
1.
5-37
2.
5
3.
1.
5-38
2.
3.
1.
2.
3.
6 6 2
33
IP-AK2 Web Server
5-39
1.
5-40
2.
3.
1.
5-41
2.
3.
34
Honeywell
1.
2.
3.
5-42
5-43
5-8
ID
35
IP-AK2 Web Server
ID
ID
CID ABCD
ID
CID A
A
ABCD
A
1.
5-44
2.
3.
1.
2.
3.
36
Honeywell
5-45
1.
5-46
2.
5-9
25
37
IP-AK2 Web Server
3.
1.
5-47
2.
3.
1.
2.
3.
1.
5-48
2.
38
Honeywell
*17900
ChunfengChun*
17900
IP-AK2
IP-AK2
5-49
1.
5-50
2.
3.
39
IP-AK2 Web Server
1.
5-51
2.
3.
1.
2.
3.
1.
5-52 1
2.
5-53 2
3.
4.
IP
RS485
40
Honeywell
5-54
1.
5-10
IP IP-AK2
IP-AK2
IP-AK2
RS485
RS485
2.
5-55
1.
2.
41
IP-AK2 Web Server
IP-AK2
IP-AK2
IP-AK2
IP-AK2
IP-AK2
IP-AK2
5-56 /
5-57 ->
5-58 ->->
42
Honeywell
5-11
IP-AK2
IP-AK2
5-59 ->
5-12
IP-AK2
IP-AK2
43
IP-AK2 Web Server
5-60 ->
5-13
1.
2.
5-61
3.
/
5-62 ->
44
Honeywell
1. /
2.
5-63
/
5-64 ->
1.
5-65
2. /
3.
45
IP-AK2 Web Server
4.
IP-AK2
5-66 ->
IP-AK2
5-67
46
Honeywell
IP-AK2
8mA @ 12VDC
Honeywell JT-MCR MIFARE Smart READERS
Honeywell HON-MSR MIFARE SECTOR READERS
HONEYWELL OmniProx PROXIMITY READERS
Honeywell OmniClass SMART READERS
Honeywell HON-FIN3000 Fingerprint
150mA
150mA
300mA
340mm13.4inch
290mm11.4inch
78mm3.1inch
5kg11lb
0C ~ 50C
-55C ~ +85C
5% ~ 85% RHNC
Cat5 RJ-45
100m330inch
10
7 153m500inch
610m2, 000inch
610m2, 000inch
47
IP-AK2
6-1 IP-AK2
DIP
9~10
1~5
7-8
6
TB4
OFF OFF
ON ON
OFF ON
ON OFF
ON/OFF
LED
DATA 0
485 EOL
IP
/
(1 ~ 31)
DATA 1
COMMON TB5
+12VDC
7
LED
DATA 0
DATA 1
COMMON TB6
+12VDC
TB7
TB8
SW1
10
J1
ON
TB9
T1
220VAC/60Hz 12VDC
/ 6.35mm
48
Honeywell
IP-AK2
2 2.5 6FM3.2A
49
8-1
DIP
DIP 6=ON
RS-485
TB7DIP 6=ON
RS-485
IP-AK2 EOL
EOL RS-485
50
Honeywell
/
1.
2.
3.
/ /
1.
2. 10
3. 10
IP-AK2
Wiegand
51
A-1
...
1 11
2 22
IP-AK2
LED
A-2
LED ..
1 7
2 8
A-3
... ...
1 1 SUP1 1
2 2 SUP3 3
A-4
...
1 SUP2 2
2 SUP4 4
52
Honeywell
14 14
20 14 20
TB8
3-7
A-5
...
/ SUP5 5
/ SUP6 6
2 Form C
A-6
...
3 3
4 4
53
Honeywell
RoHS
IP-AK2
1. 10
2.
Pb Hg Cd Cr(VI) PBB PBDE
O O O O O O
X O O O O O
X O O O O O
X O O O O O
X O O O O O
O SJ/T11363-2006
X SJ/T11363-2006
Honeywell
WIN-PAK
S-4 HAS
DC
ESD CMOS
ESD
ESD
i
Honeywell
1 ...................................................................................................................................................1
.............................................................................................................................................1
..................................................................................................................................2
....................................................................................................................................................2
2 .............................................................................................................................................................3
IP-AK2 .............................................................................................................................4
....................................................................................................................................................4
....................................................................................................................................................4
3 .............................................................................................................................................................5
.............................................................................................................................................6
....................................................................................................................................................8
......................................................................................................................................8
..................................................................................................................................9
.............................................................................................................................10
....................................................................................................................................11
DIP ....................................................................................................................................11
LED ..........................................................................................................................................13
4 IP-AK2 .....................................................................................................................14
5 IP-AK2 Web Server ...................................................................................................................15
IP-AK2 Web Server ..............................................................................................................15
IP-AK2 ........................................................................................................15
......................................................................................................................16
IP-AK2 Web Server ..............................................................................................................17
....................................................................................................................................17
...........................................................................................................................................18
IP-AK2 Web Server ..........................................................................................................19
....................................................................................................................................21
................................................................................................................................23
........................................................................................................................................28
....................................................................................................................................32
....................................................................................................................................39
IP-AK2 ..............................................................................................................................42
...........................................................................................................................................42
...........................................................................................................................................43
........................................................................................................................................43
....................................................................................................................................44
....................................................................................................................................45
....................................................................................................................................46
..................................................................................................................................................46
6 ...........................................................................................................................47
...........................................................................................................................................47
IP-AK2 .......................................................................................................................48
7 ...........................................................................................................................................................49
8 .........................................................................................................................................50
A ....................................................................................................................................51
....................................................................................................................................51
/ ........................................................................................................................51
/ / ..................................................................................................51
IP-AK2 ....................................................................................................................51
i
Honeywell
....................................................................................................................................51
.........................................................................................................................52
.............................................................................................................................52
................................................................................................................................52
................................................................................................53
.............................................................................................................................53
ii
Honeywell
iii
Honeywell
5-40 .............................................................................................................................................. 34
5-41 .............................................................................................................................................. 35
5-42 ................................................................................................................................................. 35
5-43 .......................................................................................................................................... 36
5-44 ................................................................................................................................................. 36
5-45 ................................................................................................................................................. 37
5-46 ......................................................................................................................................................... 37
5-47 ......................................................................................................................................................... 38
5-48 ......................................................................................................................................................... 39
5-49 .............................................................................................................................................. 39
5-50 ..................................................................................................................................................... 39
5-51 ..................................................................................................................................................... 40
5-52 1 .................................................................................................................................................. 40
5-53 2 .................................................................................................................................................. 40
5-54 .............................................................................................................................................. 41
5-55 ..................................................................................................................................................... 41
5-56 / .................................................................................................................................. 42
5-57 ->.................................................................................................................................................. 42
5-58 ->-> ................................................................................................................................. 42
5-59 ->.................................................................................................................................................. 43
5-60 -> ..................................................................................................................................................... 44
5-61 ......................................................................................................................................................... 44
5-62 ->.................................................................................................................................................. 44
5-63 ..................................................................................................................................................... 45
5-64 ->.................................................................................................................................................. 45
5-65 ..................................................................................................................................................... 45
5-66 ->........................................................................................................................................... 46
5-67 ..................................................................................................................................................... 46
6-1 IP-AK2 .................................................................................................................................... 48
iv
Honeywell
3-1 .................................................................................................................................................. 6
3-2 ..................................................................................................................................................... 9
3-3 ......................................................................................................................................... 10
3-4 DIP ................................................................................................................................................. 11
3-5 DIP ................................................................................................................................................. 12
5-1 ............................................................................................................................................ 25
5-2 ................................................................................................................................................ 26
5-3 ................................................................................................................................................... 27
5-4 ................................................................................................................................................ 28
5-5 ................................................................................................................................................ 30
5-6 ................................................................................................................................................ 31
5-7 ............................................................................................................................................ 32
5-8 ................................................................................................................................................... 36
5-9 ................................................................................................................................................... 38
5-10 .............................................................................................................................................. 41
5-11 .............................................................................................................................................. 43
5-12 .............................................................................................................................................. 43
5-13 ................................................................................................................................................. 44
8-1 ............................................................................................................................................ 50
A-1 ............................................................................................................................................... 52
A-2 ..................................................................................................................................... 52
A-3 ........................................................................................................................................ 52
A-4 ............................................................................................................................................ 52
A-5 ................................................................................................................... 53
A-6 ............................................................................................................................................... 53
v
Honeywell
IP-AK2
IP-AK2
1 IP-AK2
2 IP-AK2 IP-AK2
3 IP-AK2 DIP
4 IP-AK2 IP-AK2
5 IP-AK2 Web ServerIP-AK2 Web ServerIP-
AK2
6 IP-AK2
7
8
AIP-AK2
Honeywell
Honeywell
2
Honeywell
IP-AK2 IP-AK2
14 4-1 IP-AK2 IP-AK2
IP-AK2
IP-AK2
IP-AK2
2-1 IP-AK2
IP-AK2
IP-AK2 IP-AK2
2 8 4 10 IP-AK2
IP-AK2
IP-AK2
IP-AK2
12VDC150mA 300mA
IP-AK2
6FM3.2AJ12VDC3.2AHr 300-
03271 IP-AK2
12VDC BAT COM AC
12VDC
9.4V
2 2.5
4
Honeywell
IP-AK2
ESD
1.
2.
3. I/O
48 6-1 IP-AK2
220VAC/60Hz12VDC/
6.35mm
4.
5. DIP12 3-5 DIP
6.
IP-AK2
FCC 15 Class B
IP-AK2
3-1
130mm 240mm
2 N/A
N/A 1
2 N/A
2 N/A
1 N/A
3-1 IP-AK2
30mm [1.181]
78mm [3.071]
32.44mm [1.277]
0mm [0.000]
290mm [11.417]
125mm [4.921]
0mm [0.000]
3-2 IP-AK2
290mm [11.417]
255mm [10.039]
35mm [1.378]
0mm [0.000]
0mm [0.000]
78mm [3.071]
30mm [1.181]
6
Honeywell
3-3 IP-AK2
78mm [3.071]
30mm [1.181]
0mm [0.000]
0mm [0.000]
55mm [2.165]
30mm [1.181]
195mm [7.677]
340mm [13.386]
3-4 IP-AK2
30mm [1.181]
78mm [3.071]
0mm [0.000]
0mm [0.000]
55mm [2.165]
30mm [1.181]
195mm [7.677]
340mm [13.386]
3-5 IP-AK2
251.75mm [9.911]
144.92mm [5.706]
290mm [11.417]
38.25mm [1.506]
275mm [10.827]
15mm [0.591]
0mm [0.000]
18mm [0.709] 20mm [0.787]
10mm [0.394] ()
119mm [4.685]
40mm [1.575]
221mm [8.701]
240mm [9.449] 240mm [9.449]
248mm [9.764]
260mm [10.236]
284mm [11.181]
262mm [10.315]
324.5mm [12.776]
2-N3
325mm [12.795]
235.06mm [9.254]
140mm [5.512]
160mm [6.299]
200mm [7.874]
97.1mm [3.823]
15mm [0.591]
76mm [2.992]
28mm [1.102]
48mm [1.890]
IP-AK2
IP-AK2
8
Honeywell
3-6
Wiegand 12V
300mA
7-18-22AWG
6-
152.4m500inch
3-2
Wiegand
Wiegand
TB5-6 6-6
TB5-7 6-7
TB5TB6TB7 TB8 1 4
TB7 5 6 TB8 7 8 TB5 TB6
3-3
TB7-1 1 1
TB7-3 2 1
TB7-4 3 2
TB7-6 4 2
TB8-1 5
TB8-3 6
3-7
20ohms
10
Honeywell
1 1 2 2 3-4
IP-AK2 12VDC
12VDC28VDC
LED LED
DIP
DIP
1-5 (1 ~ 31)
6 ON/OFF /
ON OFF IP
OFF ON
7-8
ON ON
OFF OFF
1 5 1~31 0
6 RS485 6 ON
RS-485
7 8 OFF 7
ON8 OFF IP(192.168.1.150)
(admin) 7 OFF8
ON IP-AK2 ON
11
9 10 RS-485
ONOFFON
OFF
3-5 DIP
SW1.1 SW1.2 SW1.3 SW1.4 SW1.5 SW1.6 SW1.7 SW1.8 SW1.9 SW1.10
12
Honeywell
13
J1
TB1
()
SW1
TB2
TB9
T1
TB3
TB4
TB5
TB7
TB6
TB8
7
7
LED
LED
LED PWR RUN 485TR RS232
3-8 LED
N/A
N/A N/A N/A N/A
N/A N/A
LED
IP-AK2
4 IP-AK2
IP-AK2
IP-AK2
IP-AK2
IP-AK2 IP-AK2
4-1 IP-AK2 IP-AK2
14
Honeywell
IP-AK2 IP-AK2
20
IP-AK2
Internet Explore 6.0
Firefox 3.0
IP-AK2
IP-AK2
5-1
IP-AK2
IP-AK2
15
IP-AK2 Web Server
5-2
IP-AK2
IP-AK2
IP-AK2 DIP 6
ON
1.
2.
5-3
3. Internet ProtocolTCP/IP
4. IP
16
Honeywell
5-4
IP 192.168.1.10
255.255.255.0
192.168.1.1
5.
Firefox 3.0
17
IP-AK2 Web Server
2.
5-7
3.
5-8
IP-AK2 Web Server
5-9 IP-AK2 Web Server
1.
18
Honeywell
adminadmin
IP-AK2
19
IP-AK2 Web Server
5-11 IP-AK2
20
Honeywell
IP-AK2
12
6 12 6
5-13
5-14
5-15
1.
5-16
2.
21
IP-AK2 Web Server
3.
1.
5-17
2.
3.
1.
2.
3.
5-18
1.
22
Honeywell
5-19
2.
3.
1.
5-20
2.
3.
1.
2.
3.
5-21 1
23
IP-AK2 Web Server
5-22 2
5-23
24
Honeywell
5-1
DIP
IP-AK2
IP-AK2
IP-AK2
+
+
1 1 2222
2221 2223
LED
/ 28
5-24
25
IP-AK2 Web Server
1.
5-25
2.
5-2
1.
5-26
2.
3.
26
Honeywell
1.
2.
3.
5-3
5-27
27
IP-AK2 Web Server
IP-AK2
FTP
FTP
5-4
FTP FTP IP
FTP
FTP
FTP
80% 2000080%*
25000
IP-AK2
5-28 1
28
Honeywell
5-29 2
IP-AK2
o
o
o
o
5-30
/
5-31 /
29
IP-AK2 Web Server
5-32 /
5-33 /
5-5
1024 60 60
5
5
30
Honeywell
5-34
5-6
1 60 60
5-35
31
IP-AK2 Web Server
/
36
5-7
+
+
8 ID ID
32
Honeywell
5-36
1.
5-37
2.
5
3.
1.
5-38
2.
3.
1.
2.
3.
33
IP-AK2 Web Server
6 6 2
5-39
1.
5-40
2.
3.
1.
34
Honeywell
5-41
2.
3.
1.
2.
3.
5-42
35
IP-AK2 Web Server
5-43
5-8
ID
ID
ID
CID ABCD
ID
CID A
A
ABCD
A
1.
5-44
2.
3.
36
Honeywell
1.
2.
3.
5-45
1.
5-46
37
IP-AK2 Web Server
2.
5-9
25
3.
1.
5-47
2.
3.
1.
38
Honeywell
2.
3.
1.
5-48
2.
*17900
ChunfengChun*
17900
IP-AK2
IP-AK2
5-49
1.
5-50
2.
39
IP-AK2 Web Server
3.
1.
5-51
2.
3.
1.
2.
3.
1.
5-52 1
2.
5-53 2
3.
4.
40
Honeywell
IP
RS485
5-54
1.
5-10
IP IP-AK2
IP-AK2
IP-AK2
RS485
RS485
2.
5-55
41
IP-AK2 Web Server
1.
2.
IP-AK2
IP-AK2
IP-AK2
IP-AK2
IP-AK2
IP-AK2
5-56 /
5-57 ->
5-58 ->->
42
Honeywell
5-11
IP-AK2
IP-AK2
5-59 ->
5-12
IP-AK2
IP-AK2
43
IP-AK2 Web Server
5-60 ->
5-13
1.
2.
5-61
3.
/
5-62 ->
44
Honeywell
1. /
2.
5-63
/
5-64 ->
1.
5-65
45
IP-AK2 Web Server
2. /
3.
4.
IP-AK2
5-66 ->
IP-AK2
5-67
46
Honeywell
IP-AK2
8mA @ 12VDC
Honeywell JT-MCR MIFARE Smart READERS
Honeywell HON-MSR MIFARE SECTOR READERS
HONEYWELL OmniProx PROXIMITY READERS
Honeywell OmniClass SMART READERS
Honeywell HON-FIN3000 Fingerprint
150mA
150mA
300mA
340mm13.4inch
290mm11.4inch
78mm3.1inch
5kg11lb
0C ~ 50C
-55C ~ +85C
5% ~ 85% RHNC
Cat5 RJ-45
100m330inch
10
7 153m500inch
610m2, 000inch
610m2, 000inch
47
IP-AK2
6-1 IP-AK2
DIP
9~10
1~5
7-8
6
TB4
OFF OFF
ON ON
OFF ON
ON OFF
ON/OFF
LED
DATA 0
485 EOL
IP
/
(1 ~ 31)
DATA 1
COMMON TB5
+12VDC
7
LED
DATA 0
DATA 1
COMMON TB6
+12VDC
TB7
TB8
SW1
10
J1
ON
TB9
T1
220VAC/60Hz 12VDC
/ 6.35mm
48
Honeywell
IP-AK2
2 2.5 6FM3.2A
49
8-1
DIP
DIP 6=ON
RS-485
TB7DIP 6=ON
RS-485
IP-AK2 EOL
EOL RS-485
50
Honeywell
/
1.
2.
3.
/ /
1.
2. 10
3. 10
IP-AK2
Wiegand
51
A-1
...
1 11
2 22
IP-AK2
LED
A-2
LED ..
1 7
2 8
A-3
... ...
1 1 SUP1 1
2 2 SUP3 3
A-4
...
1 SUP2 2
2 SUP4 4
52
Honeywell
14 14
20 14 20
TB8
3-7
A-5
...
/ SUP5 5
/ SUP6 6
2 Form C
A-6
...
3 3
4 4
53
Honeywell
RoHS
IP-AK2
1. 10
2.
Pb Hg Cd Cr(VI) PBB PBDE
O O O O O O
X O O O O O
X O O O O O
X O O O O O
X O O O O O
O SJ/T11363-2006
X SJ/T11363-2006
Honeywell Security
Honeywell Security Asia Pacific
35F Tower A, City Center, 100 Zun Yi Road, Shanghai 200051, China
Honeywell
2009 Honeywell International Inc.
www.security.honeywell.com