Professional Documents
Culture Documents
54LS257A/DM54LS257B/DM74LS257B, 54LS258A/DM54LS258B/DM74LS258B
June 1989
54LS257A/DM54LS257B/DM74LS257B,
54LS258A/DM54LS258B/DM74LS258B
TRI-STATEÉ Quad 2-Data Selectors/Multiplexers
General Description Features
These Schottky-clamped high-performance multiplexers Y TRI-STATE versions LS157 and LS158 with same pin-
feature TRI-STATE outputs that can interface directly with outs
data lines of bus-organized systems. With all but one of the Y Schottky-clamped for significant improvement in A-C
common outputs disabled (at a high impedance state), the performance
low impedance of the single enabled output will drive the Y Provides bus interface from multiple sources in high-
bus line to a high or low logic level. To minimize the possibil- performance systems
ity that two outputs will attempt to take a common bus to Y Average propagation delay from data input 12 ns
opposite logic levels, the output enable circuitry is designed Y Typical power dissipation
such that the output disable times are shorter than the out- LS257B 50 mW
put enable times. LS258B 35 mW
This TRI-STATE output feature means that n-bit (paralleled) Y Alternate military/aerospace devices (54LS257A/
data selectors with up to 258 sources can be implemented 54LS258A) are available. Contact a National Semicon-
for data buses. It also permits the use of standard TTL reg- ductor Sales Office/Distributor for specifications.
isters for data retention throughout the system.
Connection Diagrams
Dual-In-Line Package Dual-In-Line Package
TL/F/6417 – 1 TL/F/6417 – 2
Order Number 54LS257ADMQB, 54LS257AFMQB, Order Number 54LS258ADMQB, 54LS258AFMQB,
54LS257ALMQB, DM54LS257BJ, DM54LS257BW, 54LS258ALMQB, DM54LS258BJ, DM54LS258BW,
DM74LS257BM or DM74LS257BN DM74LS258BM or DM74LS258BN
See NS Package Number E20A, J16A, See NS Package Number E20A, J16A,
M16A, N16E or W16A M16A, N16E or W16A
Function Table
Inputs Output Y
Output
Select A B LS257 LS258
Control
H X X X Z Z
L L L X L H
L L H X H L
L H X L L H
L H X H H L
H e High Level, L e Low Level, X e Don’t Care,
Z e High Impedance (off)
2
’LS257B Switching Characteristics
at VCC e 5V and TA e 25§ C (See Section 1 for Test Waveforms and Output Load)
RL e 667X
From (Input)
Symbol Parameter To (Output) CL e 45 pF CL e 150 pF Units
Min Max Min Max
tPLH Propagation Delay Time Data to
18 27 ns
Low to High Level Output Output
tPHL Propagation Delay Time Data to
18 27 ns
High to Low Level Output Output
tPLH Propagation Delay Time Select to
28 35 ns
Low to High Level Output Output
tPHL Propagation Delay Time Select to
35 42 ns
High to Low Level Output Output
tPZH Output Enable Time Output
15 27 ns
to High Level Output Control to Y
tPZL Output Enable Time Output
28 38 ns
to Low Level Output Control to Y
tPHZ Output Disable Time from Output
26 ns
High Level Output (Note 1) Control to Y
tPLZ Output Disable Time from Output
25 ns
Low Level Output (Note 1) Control to Y
Note 1: CL e 5 pF.
Typ
Symbol Parameter Conditions Min Max Units
(Note 1)
VI Input Clamp Voltage VCC e Min, II e b18 mA b 1.5 V
VOH High Level Output VCC e Min, IOH e Max DM54 2.4 3.4
V
Voltage VIL e Max, VIH e Min
DM74 2.4 3.1
VOL Low Level Output VCC e Min, IOL e Max DM54 0.25 0.4
Voltage VIL e Max, VIH e Min
DM74 0.35 0.5 V
IOL e 12 mA, VCC e Min DM74 0.25 0.4
II Input Current @ Max VCC e Max, Select 0.2
mA
Input Voltage VI e 7V Other 0.1
IIH High Level Input VCC e Max, Select 40
mA
Current VI e 2.7V Other 20
3
’LS258B Electrical Characteristics
over recommended operating free air temperature range (unless otherwise noted) (Continued)
Typ
Symbol Parameter Conditions Min Max Units
(Note 1)
IIL Low Level Input VCC e Max, Select b 0.8
mA
Current VI e 0.4V Other b 0.4
RL e 667X
From (Input)
Symbol Parameter To (Output) CL e 45 pF CL e 150 pF Units
Min Max Min Max
tPLH Propagation Delay Time Data to
18 27 ns
Low to High Level Output Output
tPHL Propagation Delay Time Data to
18 27 ns
High to Low Level Output Output
tPLH Propagation Delay Time Select to
28 35 ns
Low to High Level Output Output
tPHL Propagation Delay Time Select to
35 42 ns
High to Low Level Output Output
tPZH Output Enable Time Output
15 27 ns
to High Level Output Control to Y
tPZL Output Enable Time Output
28 38 ns
to Low Level Output Control to Y
tPHZ Output Disable Time from Output
26 ns
High Level Output (Note 4) Control to Y
tPLZ Output Disable Time from Output
25 ns
Low Level Output (Note 4) Control to Y
Note 4: CL e 5 pF.
4
Logic Diagrams
LS257B
TL/F/6417 – 3
LS258B
TL/F/6417 – 4
5
Physical Dimensions inches (millimeters)
6
Physical Dimensions inches (millimeters) (Continued)
7
54LS257A/DM54LS257B/DM74LS257B, 54LS258A/DM54LS258B/DM74LS258B
TRI-STATE Quad 2-Data Selectors/Multiplexers
Physical Dimensions inches (millimeters) (Continued)
NATIONAL’S PRODUCTS ARE NOT AUTHORIZED FOR USE AS CRITICAL COMPONENTS IN LIFE SUPPORT
DEVICES OR SYSTEMS WITHOUT THE EXPRESS WRITTEN APPROVAL OF THE PRESIDENT OF NATIONAL
SEMICONDUCTOR CORPORATION. As used herein:
1. Life support devices or systems are devices or 2. A critical component is any component of a life
systems which, (a) are intended for surgical implant support device or system whose failure to perform can
into the body, or (b) support or sustain life, and whose be reasonably expected to cause the failure of the life
failure to perform, when properly used in accordance support device or system, or to affect its safety or
with instructions for use provided in the labeling, can effectiveness.
be reasonably expected to result in a significant injury
to the user.
National does not assume any responsibility for use of any circuitry described, no circuit patent licenses are implied and National reserves the right at any time without notice to change said circuitry and specifications.
This datasheet has been downloaded from:
www.DatasheetCatalog.com