Professional Documents
Culture Documents
PALESTINIAN RELEIF
Electronic copy of the BOQ shall be submitted along with the signed hard copy thereof. In case
of any discrepancy between the soft and the hard copies, the hard copy shall prevail.
BILL OF QUANTITIES
Excavation.
General.
1. Excavation for foundation, trenches. Etc. shall be the actual dimensions shown on Drawings including
blinding area, and to be measured from Natural Ground Level or Reduced Level (which is lower), i.e.
1. From Reduced Level when R. L. is lower than N. G. L.
2. From N. G. L. when N. G. L. is lower than the Reduced Level.
3. Top agricultural soil to be excavated and relocated at contractor’s expense up to depth of 75 cm as stated in
item 11 below. Quantities to be calculated and reimbursed do not include this 75 cm layer.
2.Allowance for working space is not applicable, unless it is clearly specified in the Special Conditions.
3. The price of excavation for foundation of retaining walls and B/W are including in the concrete foundation
price.
4. Price to include removal of site obstacles, rocks, trees and all debris from site, including any necessary
rerouting of infrastructure works, such as piping, conduits, etc... Price also to include maintaining all trees that
are not obstructing the buildings, boundary walls, courts and roads.
5. Each layer of backfilling shall be tested separately, on the contractor's expense, prior to applying the next
layer.
6. Co-ordination with all local authorities to facilitate the works, removal of obstacles or for diversion of roads,
services, etc. is the contractor's responsibility and are deemed to be included in his rates.
7. Excavated soil shall be classified and retained, to back fill with suitable fill material and to place agricultural
soil as where needed as shown in the drawings and as instructed by the Engineer. The extra and unsuitable soil
shall be removed, on the contractor’s expense with no extra cost.
8. Prior to commencement of site leveling or any excavation, the Contractor shall obtain Engineer’s written
approval on the contour grid of 5m exam map, checked jointly by the contractor and the Engineer, the
excavation profiles and sections showing all levels and dimensions, and the calculations of excavation
quantities.
9. Excavation shall be in Cubic Volume, the net measurements of the excavated elements as shown in the
drawings, no allowance shall be made for increase in bulk after excavation.
10. Hard Core beds shall be of not less than 15 cm. thick. And measured in Meter Square, (the net measurement
of the finished surface). No extra rate shall be paid for Leveling, ramming and filling of voids under the hard
core.
11. Rate of Excavation shall include :-
Removal of top agricultural soil, containing roots and organic materials. Up to 75 cm. Deep.
Excavation to any depth, in any shape, in any type of soil, below water table level and keeping excavation
free of water.
Leveling, ramming, trimming and grading excavation bottoms.
Planking and strutting.
Cost of lab. Tests of works and materials.
Package #8: Construction of Tal El Sultan Secondary School #2 in Rafah ITB 2013‐032
Bill No (1)
1. Mobilization & Demobilization
Unit Rate Unit Rate Total
Item
Description Unit Quantity US $ US $ Amount
No.
(letters) (Numbers) US $
All works according to particular specifications, and
supervisor engineer instructions.
Preparation the existing site include:
1- Supply Site offices, shed, ground slab, equipments,
and furniture for both supervision and contractor.
2- Access road to and through the site.
3- Transportation & Communication for the contractor
team and for the supervision engineers as well
1.1 L.S. 1
Contractor's Signature and Seal
Package #8: Construction of Tal El Sultan Secondary School #2 in Rafah ITB 2013‐032
Bill No (A)
1.EXCAVATION & EARTHWORKS
Unit Rate Unit Rate Total
Item
Description Unit Quantity US $ US $ Amount
No.
(letters) (Numbers) US $
Contractor shall take into consideration that all – direct
and indirect works and expenses required for the
completion of the coming items are included in the uint
price.
All works must be according to drawings, specification
and engineer instructions. Rates shall include :
1. Shore up the sides of excavation and take all
precautions to keep the adjacent buildings and existing
infrastructure utilities (sewage, water, electricity and
telecommunication works )safe. And repaire any
damage occure in the site.
2. Cleaning the site and removing all debris and rubbles
to approved dump site.
3.Approval of Bench mark and leveling network before
excavation works.
4. Backfilling in layers not more than 25cm thick for
each layer and compaction to 98% of MDD.
5. Safety precautions to protect neighbor utilizes and
persons.
6. All required Tests should be accommedated by an
approved lab.
7. Laying out the buildings coordinates to be carrid out
by profesional surveyor using total station device.
8.price include leveling and backfilling from imported
sand to make up level around buildings up to the top of
external ground beams levels.
9.All the above mentioned and following specifications
is part of the contractor obligations.
1.1 Excavation in sandy soil or any other soils including
backfilling with selected or imported sand material
around foundations & any other element up to ground
slab level in layers not more than 25cm thick for each
layer with compaction to 98% of MDD. The works L.S. 1
including compacting the design soil surfaces to get
(98% MDD), The price also includes transportation of
the disapproved excavated material to approved dump
area according to supervision engineer’s instructions.
Total
Contractor's Signature and Seal
Package #8: Construction of Tal El Sultan Secondary School #2 in Rafah ITB 2013‐032
Bill No (A)
2. Concrete Works.
Unit Rate Unit Rate Total
Item
Description Unit Quantity US $ US $ Amount
No.
(letters) (Numbers) US $
Rates of Concrete Works shall include:‐
1. All form works and shuttering (new lumber for shuttering
painted by special oil ) in any form, shape and size . Making
chamfered and curved edges, allowing for and making
grooves and sleeves and using Tie Rods (Batant) for concrete
walls ; removal of forms and cleaning of all exposed tie wires
and rods. Steel forms must be used in shuttering the external
decorations.
2. Fuel or burned oil is not accepted to be used for painting
the lumber before use the form.
3. Supplying, Casting, vibrating and curing as per
specifications.
4. Approved additives and admixtures.
5. Incurred costs on New Concrete Job Mix Designs, Sampling
, testing and providing test results certificates, storing and
saving of samples.
Contractor's Signature and Seal
Package #8: Construction of Tal El Sultan Secondary School #2 in Rafah ITB 2013‐032
Bill No (A)
2. Concrete Works.
Unit Rate Unit Rate Total
Item
Description Unit Quantity US $ US $ Amount
No.
(letters) (Numbers) US $
2.9 Ditto , but for wall parapet in corridors under steel balustrade
in the gnd. floor, ramp side walls, roof expansion joints walls
& for stair case walls parapet M3 8
2.10. Ditto but for sills, lintels, concrete wall (hunches for doors),
gas room elements .etc. M3 60
2.11 Supply and cast ready mix concrete (B150) for stub columns
at the roof. M3 9
2.12
Ditto but plain concrete B200 under water tank. 10 cm thick. M3 3
2.13 Supply and cast ready mix reinforced concrete B (300)
kg/cm2 for columns and columns necks as per specifications
and drawings. M3 115
Supply and cast ready mix concrete B (250) kg/cm2 for
2.14
suspended hollow block slab 20 cm thick, including the
reinforced steel, decorative arches in last slab, corridor
concrete parapet, under steel balustrade for the typical slab,
hollow cement block 40 x 25 x 14cm, all drop and inverted
beams everywhere in the slab and all other materials as per
specifications and drawings. M2 2650
2.15 Ditto, but for stair case slab M2 100
2.16 ditto, but B250 reinforced concrete for Apron (surface treated
with mechanical steel toweled finish) the price include
polythene sheets. Reinforcement Ø 8mm / 15 cm in both way
and reinforced edge beam. The price including 15cm thick
compacted base coarse to 100% of MDD according to
drawing and specification. M2 230
Total
Contractor's Signature and Seal
Package #8: Construction of Tal El Sultan Secondary School #2 in Rafah ITB 2013‐032
Bill No (A)
3. Building Works
Unit Rate Unit Rate Total
Item
Description Unit Quantity US $ US $ Amount
No.
(letters) (Numbers) US $
The price include:
1- supplying hollow or solid cement block from good
and approved factory in perfect dimension and build it
in good manner with a compressive strength 35 kg/cm2
for hollow block and 60 kg/cm2 for solid block. This
item will include cement mortars, reinforced concrete
infill (B250) between columns & block walls (10-20 cm
wide) with 1Ø8mm/40cm horizontally and 2Ø8mm
vertically according to drawings, pipes encasement,
false columns 20x20 cm/4.0m among the parapet wall
with 4Ø12mm and bituminous paper between block
work and drop beams & all requirements needed to
finish the works according to the drawings, specification
and to the supervision engineer instructions.
2- Providing samples for approval and all the required
tests.
3.1 Supply and build hollow cement blocks 40x20x20cm. M2 1600
3.4 Supply and build solid cement block 40x20x20 cm, M2 170
under ground beams, and external boundary for building
including painting the buried parts with one coat of
primer and two coats of hot bitumen (75/25) after
primer layer.
Total
Contractor's Signature and Seal
Package #8: Construction of Tal El Sultan Secondary School #2 in Rafah ITB 2013‐032
Bill No (A)
4. Carpentry works
Unit Rate Unit Rate Total
Item
Description Unit Quantity US $ US $ Amount
No.
(letters) (Numbers) US $
The items include supplying carpentry works from good wood
grade “A” including frame cover mould, architrave and at
least two coats of oil paint, 15cm Aluminum kick plate 1mm
thick from both sides , hard ware locked type Wally switch or
equivalent and brass hinges 10cm height, door stopper and all
other fitting according to specification and drawing .
Supply, fix & paint flushed wooden external double leaves
4.1 door type D1, overall size 125 x 220 x 4.5cm thick, complete No 20
with the above preamble.
4.2 Ditto but type D2 overall size 90x 220cm x45mm thick. No 4
Supply and fix soft wood poster hanging rails size 50mm x
20mm with round edges, smooth surface , apply two coats of
4.8 sanding sealer, sand lightly and apply two coats of varnish,one Mr 145
coat of Lucker paint. drill and fix to concrete or block walls
using expansion steel bolts as per specification and drawings..
Supply and fix soft wood rubbing rails size 150mm x 20mm
with round edges, smooth surface , apply two coats of sanding
4.9 sealer,one coat of Lucker paint. sand lightly and apply two Mr 530
coats of varnish, drill and fix to concrete or block walls using
expansion steel bolts as per specification and drawings..
Total
Contractor's Signature and Seal
Package #8: Construction of Tal El Sultan Secondary School #2 in Rafah ITB 2013‐032
Bill No (A)
5. Metal works
Unit Rate Unit Rate Total
Item
Description Unit Quantity US $ US $ Amount
No.
(letters) (Numbers) US $
The item include supplying white aluminum windows section
7000 with two rails, with min. wall thick 1.5mm (to be
approved by representative engineer )as frame, glass 4 mm
thick, ironmongery , accessories and hard ware as per
specification and drawings
Supply and fix white aluminum window section 7000 type
W1. , overall size 250 x 120cm, complete with frame, white
5.1 No 56
color, four sliding leaves ,clear glass 4mm thick, ironmongery
and hardware. and as per specification and drawing.
5.2 Ditto but, Type W2 overall size 125 x 120cm No 25
5.3 Ditto but two leaves type w3 over all size 250 x 80cm No 53
5.4 Ditto but type W3* overall size 1.25 x80cm (two leaves). No 3
Ditto but section 4500 W5 overall size 60x60cm with two
5.5 No 3
hinges at the mid as per specification and drawings
Supply and fix steel protection for windows over all size W1
(ground floor) 250x110 cm .the prices including mild steel
frame size 40 x 8mm thick, vertical steel plate size 20mm
wide x 8mm thick fixed every 12cm (clear distance),
5.6 .No 16
decorative circles 20x2mm, all by welding to the frame. Fixed
on walls by steel angle ties, painting with one coat of primer
undercoat and at least two coats of oil paint, all according to
drawing, specification and engineer instructions.
5.12 Ditto but window size 125x80cm for first and second floor No 20
Supply and fix mild steel balustrade 40cm high for the
corridors comprising of M.S. hollow section tubes 40 x 20 x 2
mm verticals spacing 10 cm clear distance, and welded
60x40x2 mm top and bottom rails fixed to columns and
5.13 Mr 260
bottom parapet using expansion bolts, rates includes M.S.
end angles, painting with one primer, one under coats and
minimum two coats of oil paint, (the color to be approved By
the Supervisor Engineer and as drawings and specifications).
5.14 Ditto but high 60cm for staircase handrail. Mr 85
Supply and fix galvanized steel balustrade for stair case pipe
Ø 1.5” 2mm thick fixed to walls by steel plate and 3 bolts
5.15 every 2m and 10cm space between wall and the pipe, the Mr 90
works include oil painting and all Accessories needed to finish
the work according to Eng. Instructions and specification.
Contractor's Signature and Seal
Package #8: Construction of Tal El Sultan Secondary School #2 in Rafah ITB 2013‐032
Bill No (A)
5. Metal works
Unit Rate Unit Rate Total
Item
Description Unit Quantity US $ US $ Amount
No.
(letters) (Numbers) US $
Supply and fix flush galvanized steel double external door
DS1 (125 x220x4.4cm), new double sheets (2‐mm thick),
complete with frame 3mm thick, ironmongery, hardware and
5.16 .No 6
oil painting, with hard ware locked type Wally switch or
equivalent and all requirement as latches, locks…etc as
specified in the drawings and specifications for ground floor.
5.17 Ditto but single door DS2 90x220cm No 8
Supply and fix double leaves Gas store door 250x105cm with
steel wire mesh 50x50x3mm fixed be steel angle size
50x50x5mm and 40x40x4mm mild steel stiffener, complete
with frame ironmongery, hard ware and oil painting. The
5.18 No 1
price includes approved lock EU made and all requirement as
latches, locks.. etc as specified in the drawings and
specification and to be approved by the representative
engineer.
Supply and fix steel cover for the access opening to the roof
(opening 80cmx80cm). The item includes angle frame,
5.19 No 2
pyramid shape steel sheet, counter weight, locks, oil
painting,…etc. as shown in the drawings and specifications.
Supply and fix a flag pole made of painted galvanized pipe
-5.20 No 2
1.5" ,3m length with welded pulley.
Total
Contractor's Signature and Seal
Package #8: Construction of Tal El Sultan Secondary School #2 in Rafah ITB 2013‐032
Bill No (A)
6. FINISHING works
Unit Rate Unit Rate Total
Item
Description Unit Quantity US $ US $ Amount
No.
(letters) (Numbers) US $
A- Plaster works
All works must be according to drawings, specification
and engineer instructions. Rates shall include :
Supply of all needed materials, including galvanized
angles for the corners, windows and external decoration
as well as the use of galvanized wire mesh between
concrete and block work.
Preparation works by covering all conduits of
electricity, water supplies , etc, with a galvanized wire
mesh at least 20cm width coated by mortar (1:1)
cement : sand and the work includes removal of wires
and nails and cleaning of surfaces to be ready for
Contractor shall take into consideration that all – direct
and indirect works and expenses required for the
completion of the coming items are included in the uint
price.
Trimming of concrete chippings, removing the wires
and etc. and cleaning of existing surfaces to be ready
for plastering.
The work shall include checking out all of the
preliminary installation in ceilings and walls such as
electrical, water supply and waste water pipes and
repairing the damages if any.
This should be done prior to commencement of
plastering and after obtaining a written approval from
the supervision engineer.
Curing with water for at least three days for each coat.
B- Tiles works
All works must be according to drawings, specification
and engineer instructions. Rates shall include :
1. Samples for approval and all the required tests.
2. Cleaning, mechanical polishing and pointing using
3.Insulation works under ceramic floor tiles for upstairs
bath rooms and kitchens using primer coat, two hot
bitumen coats (75/25)
4. Plastic angle beads for ceramic wall tiles and
Aluminum angle for ceramic of walls at the corners and
top and sides of ceramic edges.
5. Local marble must be Grade (A) free cracks and clay
flaws.
6. Measuring the stockpiled quantities of tiles and
obtaining the engineer approval prior to shipment to the
site.
7.Transporting and carefully handling the stored
quantities to the site.
Supply and make internal plastering 13 mm thick for ceiling
,walls and soffits. The work includes rough primer nail
rendering to form a key with (mix 1:1) cement sand, second
layer 13mm: Base‐Coat "Rendering" with (1:3:0.25) cement:
6.1 M2 7000
sand mortar: lime and third layer: Finishing Coat with (1:1:1)
cement: sand mortar: lime . Works include all materials
needed to finish the works according to specifications ,
drawings and supervisor engineer's instructions
Contractor's Signature and Seal
Package #8: Construction of Tal El Sultan Secondary School #2 in Rafah ITB 2013‐032
Bill No (A)
6. FINISHING works
Unit Rate Unit Rate Total
Item
Description Unit Quantity US $ US $ Amount
No.
(letters) (Numbers) US $
Supply and make internal plastering for black board size
400X125cm, three coats using lime free mortar , apply at
least 2 coats of glue putty, sand surface until smooth, apply
6.2 .No 26
one coat of undercoat ,allow to dry ,sand lightly then apply
liberally and brush two coats of chalkboard green oil paint
as per specifications and drawings.
Supply and make external plastering 20mm thick to walls
with four faces : the first is the rough nail rendering (mix
1:1) cement sand; the second is 5mm thick mortar (mix 1: 2)
cement:sand, the third is the undercoat 13mm (mix 1: 3
6.3 M2 1500
:0.25) cement:sand:lime, the forth is two coats of Tyrolean
finish ( mix 1: 3) white cement to fine aggregate (Quartiz)
and all is according to specifications , drawings and
supervisor engineer's instructions
Supply and make external plastering 20mm thick for
decorates at four faces : the first is the rough nail rendering
(mix 1:1) cement:sand, the second is 5mm thick mortar (mix
1: 2) cement:sand, the third is the undercoat 13mm (mix 1:
6.4 M2 1300
3 :0.25) cement:sand:lime; the forth is make Finishing Coat,
smooth surface with (1:1:1) cement:sand mortar:lime. and
all this is according to specifications , drawings and
supervisor engineer's instructions
Supply and install terrazzo floor tiles (grade A) size
25cmx25cmx2.5cm with Basalt stone laid on 2cm mortar
6.5 bed and 5 cm thick sand bed and terrazzo skirting 25cmx M2 2400
7cmx1cm including all materials and testing as per
specifications and drawings.
Supply and cast terrazzo edge beam 24cm wide x 6cm thick
of the same kind and color of the floor tiles including
6.6 .Mr 200
smoothing the surfaces and edges (for corridors and
thresholds.) as per specifications and drawings.
6.7 Ditto but for stair case handrail coping size 15cmx4cm. Mr 50
Supply and install local marble (grade A) size 25 cm wide x
3cm thick for windows sills laid on 2 cm thick mortar bed
6.8 Mr 280
including polishing and grooving as approved by the
representative engineer and as specification and drawings..
Supply and lay precast terrazzo stair treads size 35 cm wide x
4cm thick chamfered once , rebated once and laid on 2cm
thick mortar bed same color and kind of the floor tiles and
6.9- Mr 280
the price including terrazzo stair risers size 12.4cm high
x2cm thick and skirting 20cm high x2cm thick on the both
sides as specification and drawing.
Supply and install best quality non slipping ceramic floor
6.10 tiles (grade A) size 20 cm x 20cm x 6mm thick as M2 35
specification and drawings.
Contractor's Signature and Seal
Package #8: Construction of Tal El Sultan Secondary School #2 in Rafah ITB 2013‐032
Bill No (A)
6. FINISHING works
Unit Rate Unit Rate Total
Item
Description Unit Quantity US $ US $ Amount
No.
(letters) (Numbers) US $
Supply and install white glazed wall tiles (grade A) size 20 cm
x 20cm x 6mm thick laid on mortar backing up to lintel level
6.11 M2 110
as specified in the drawing and approved by representative
engineer.
Supply and install high quality Granite 250x60x2cm thick
(Tiger) for top cover of kitchen. The price includes local
marble grade A for two direction supporting, for, back,
6.12 shelves, skirting, aluminum doors, and all accessories, fitting 1
No
and making holes for sinks and water and gas supply as per
specification and drawings and to be approved by the
representative engineer.
Supply and fix fire extinguisher, 6kg capacity filled with CO2,
6.13 fixed at 2m height. According to, specification, drawings and No 4
as per Palestinian fire defiance requirements.
6.14 Ditto but filled with powder. No 4
Supply and install Gas supply system for laboratory, the
system including all required brass pipe, fitting valves,
distribution box, Burners.etc, and pipe should be pressure
6.15 tested and guaranteed against chemical attack and .L.S 1
approved by representative engineer and the civil defense.
the contractor shall submit work shop drawing to be
approve by the representative Engineer
Supply and install high quality Granite 180x70x2cm thick
(Tiger) for top cover of students preparing bench. The price
includes local marble grade A for two direction supporting,
floor, mid separators, marble necessary to close around and
6.16 8
bottom of sink, and shelves, skirting and all accessories, Unit
fitting and making holes for sinks and water and gas supply
as per specification and drawings and to be approved by the
representative engineer.
Ditto but for teacher bench 200x80x2cm including marble
6.17 Unit 1
back
Ditto but for laboratory store bench size 255x60x2.0cm
6.18 including aluminum doors (kitchen doors) and including Unit 1
marble back
Total
Contractor's Signature and Seal
Package #8: Construction of Tal El Sultan Secondary School #2 in Rafah ITB 2013‐032
Bill No (A)
7. PLUMBING works
Unit Rate Unit Rate Total
Item
Description Unit Quantity US $ US $ Amount
No.
(letters) (Numbers) US $
Supply and fix white glazed fireclay hand wash basin size
56cm x43cm (HARSA Type) or equivalent, complete with all
7.1 water supply pipes ½", waste fitting, trap, plug and chain, No 3
swan neck water tap( Hamat or equivalent) and mirror
60x60cm, and the drainage line 2” to the nearest floor trap.
Supply and fix white glazed fireclay Oriental squatting W.C.
suite (HARSA Type), or equivalent complete with plastic
double action flushing cistern, and fixed chromium plated tap
7.2 1/2”, including all water supply pipes ½", flushing No 1
mechanism, angle valves, 4” diam PVC drainage pipe to
the nearest manhole as specification and drawings. as
specification and drawings.
7.3 Ditto but European W.C , including heavy duty cover. No 2
Supply and fix floor trap 4inch diameter, complete with heavy
duty brass grating and 4”& 2” PVC drainage pipe to the
7.4 No 14
nearest manhole or next F.T and including S trap if needed as
specification and drawings.
Supply and install Galvanized steel pipe and fittings (1”)
including insulation with asphalt paper, excavation &
backfilling with clean sand , jointing using all necessary
7.5 .Mr 250
fittings, valves and fixing with brackets screwed to concrete
or block work as specification ,drawings and engineer
instruction.
7.6 Ditto but (3/4”). .Mr 75
Supply and fix oil painted galvanized steel threaded pipe 3”
including jointing, fittings Tee ,elbows ,shows,& fixing to
7.7 walls with metallic brackets and 3 inch diameter wire balloon .Mr 180
grating, caps on the top ends and floor traps in all floors as
specification and drawings.
Supply and fix water storage plastic tank 1.5 m3 capacity with
locks for cover, with approved type not less than 32 kg
weight, complete with lockable cover, 1 inch diam.
7.8 automatic float valve, overflow pipe (1”diam) and drip tray, .No 6
with all connections for rising main and distribution pipe
work and stop valves 1” with all accessories as specification
and drawings, including painting tanks with white oil paint .
Supply and install UPVC pipes 160mm, SN8 for drainage, with
sockets ,work includes excavating of trenches (depth 0.75‐
7.9 1.5m),bedding, compacted backfilling with clean sand in .Mr 200
layers not more than 25 cm, connecting to the manholes and
hydraulic test according to the specifications and drawings
Contractor's Signature and Seal
Package #8: Construction of Tal El Sultan Secondary School #2 in Rafah ITB 2013‐032
Bill No (A)
7. PLUMBING works
Unit Rate Unit Rate Total
Item
Description Unit Quantity US $ US $ Amount
No.
(letters) (Numbers) US $
Supply and install concrete manhole of internal diameter 60
cm ,and (50‐100) cm depth according to the required level,
10cm thick plain concrete for walls and base, slab, with cast
7.11 iron cover with frame 50cm opening, 8 ton bearing capacity, No 10
including excavation, backfilling, hunching and making good
according to specification ,drawing, and the engineer
instructions.
7.12 Ditto, but 80 cm internal diameter (105‐150cm)depth .No 8
Supply and fix white glazed fireclay laboratory sink size
60cmx40cm (HARSA Type) or equivalent, complete with
7.13 water supply pipes ½” , waste, fitting, trap, chain, long swan .No 11
neck water tap ( Hamat or equivalent), and the drainage line
2” to the nearest floor trap as specification and drawings
Supply and Install a standby booster pump with capacity = 5
m3/hr and head equal 30 m. The item includes all the
required fittings & equipments (valves, T, elbows, non return
7.14 valves,. etc.), also the item includes steel box protection with L.S 1
lock, automatic operation device and connecting to electrical
source with needed cables and all as Representative
Engineer instructions as specification and drawings
Supply & install, water meter device, type (ARAD) or
equivalent 1”, with gate valve 1” inch diameter, jointing, and
7.15 connection to the existing water supply pipe 4” including all .No 1
required fittings and accessories and as specification and
drawings.
Total
Contractor's Signature and Seal
Package #8: Construction of Tal El Sultan Secondary School #2 in Rafah ITB 2013‐032
Bill No (A)
8. ROOFING works
Unit Rate Unit Rate Total
Item
Description Unit Quantity US $ US $ Amount
No.
(letters) (Numbers) US $
Supply and cast foam concrete with fine aggregates for
roof screeding of average thickness 7 cm as shown in
8.1 M2 850
drawing. The item will include making the angle fillet
5x5cm around the boundary of the parapet .
Supply and lay one layer of plasticized bitumen roofing
membrane with chipping 4 mm thick, including priming
concrete surface prior to laying, dressing into rain water
outlets to form water proofing seal and cover the angle
8.2 M2 850
fillets. The rate include verticals parts skirting as per
specification and drawings.
Note: Measurement will be for the horizontal projection
Supply and Execute expansion joint on the roof as
8.3 detailed in drawings including, polystyrene sheets 2cm .Mr 20
thick, mastic sealant as per specification and drawings.
Note: The concrete work not included
Total
Contractor's Signature and Seal
Package #8: Construction of Tal El Sultan Secondary School #2 in Rafah ITB 2013‐032
Bill No (A)
9. PAINTING works
Unit Rate Unit Rate Total
Item
Description Unit Quantity US $ US $ Amount
No.
(letters) (Numbers) US $
All the painting materials should be approved and tested
by approved local laboratory and have the final
Approved from the Eng.
Supply and Paint the internal walls up to a high of 2.2m
above finishing floor level with one coat pendrole, two
9.1 coats of putty, one undercoat primer and two coat of oil M2 2400
paint as specified in specification and approved by
representative engineer.
Supply and Paint one-primer and minimum two coats of
9.2 Poliside for internal walls, ceiling and drop beams as M2 4500
specification and drawings.
Supply and Paint, external walls with one coat of
Pendrole primer and at least two coats of External
9.3 M2 2600
quality of colored emulsion (Weather Shield) or equal
approved as specification and drawings
Total
Contractor's Signature and Seal
BILL of QUANTITIES
( B ) -CANTEEN
Package #8: Construction of Tal El Sultan Secondary School #2 in Rafah ITB 2013‐032
Bill No (B)
1.EXCAVATION & EARTHWORKS
Unit Rate Unit Rate Total
Item
Description Unit Quantity US $ US $ Amount
No.
(letters) (Numbers) US $
Rates of Concrete Works shall include:-
1. All form works and shuttering (new lumber for
shuttering painted by special oil ) in any form, shape
and size . Making chamfered and curved edges,
allowing for and making grooves and sleeves and using
Tie Rods (Batant) for concrete walls ; removal of forms
and cleaning of all exposed tie wires and rods. Steel
forms must be used in shuttering the external
decorations.
2. Fuel or burned oil is not accepted to be used for
painting the lumber before use the form.
3. Supplying, Casting, vibrating and curing as per
specifications.
4. Approved additives and admixtures.
5. Incurred costs on New Concrete Job Mix Designs,
Sampling , testing and providing test results certificates,
storing and saving of samples.
6. Painting of exposed surfaces of underground
reinforced concrete elements with two coats of hot
bituminous paint (75/25) after primer layer , the strokes
of each layer to be opposite to each other.
7. Preliminary installations for Electrical, plumbing and
floor drainage in floor slabs including final floor slab.
8. Compaction and testing under the foundation, ground
beams, and ground slabs, the compaction should not be
less than 98% of MDD.
9. All works according to specifications , drawings and
supervisor engineer instructions
Note : All prices of concrete item should include the
steel reinforcement works as the follwoing:
10.Supply, fabricate and fix reinforcement steel (fy=
410 N/mm2) for all the structural elements according to
drawings and engineer's instructions for any grade, size
and length as detailed in the drawings, storing on site
including cutting, bending and fixing in position and
providing all tying wires, spacers, shop drawings,
testing and bar bending schedules .All works according
to specifications , drawings and supervisor engineer
instructions
Contractor shall take into consideration that all – direct
and indirect works and expenses required for the
completion of the coming items are included in the uint
price.
All works must be according to drawings, specification
and engineer instructions. Rates shall include :
1. Shore up the sides of excavation and take all
precautions to keep the adjacent buildings and existing
infrastructure utilities (sewage, water, electricity and
telecommunication works )safe. And repaire any
damage occure in the site.
2. Cleaning the site and removing all debris and rubbles
to approved dump site.
3.Approval of Bench mark and leveling network before
excavation works.
4. Backfilling in layers not more than 25cm thick for
each layer and compaction to 98% of MDD.
Contractor's Signature and Seal
Package #8: Construction of Tal El Sultan Secondary School #2 in Rafah ITB 2013‐032
Bill No (B)
1.EXCAVATION & EARTHWORKS
Unit Rate Unit Rate Total
Item
Description Unit Quantity US $ US $ Amount
No.
(letters) (Numbers) US $
5. Safety precautions to protect neighbor utilizes and
persons.
6. All required Tests should be accommedated by an
approved lab.
7. Laying out the buildings coordinates to be carrid out
by profesional surveyor using total station device.
8.price include leveling and backfilling from imported
sand to make up level around buildings up to the top of
external ground beams levels.
9.All the above mentioned and following specifications
is part of the contractor obligations.
Excavation in sandy soil or any other soils including
backfilling with selected or imported sand material
around foundations & any other element up to ground
slab level in layers not more than 25cm thick for each
1.1 layer with compaction to 98% of MDD. The works L.S. 1
including compacting the design soil surfaces to get
(98% MDD), The price also includes transportation of
the disapproved excavated material to approved dump
area according to supervision engineer’s instructions.
Total
Contractor's Signature and Seal
Package #8: Construction of Tal El Sultan Secondary School #2 in Rafah ITB 2013‐032
Bill No (B)
2. CONCRETE works
Unit Rate Unit Rate Total
Item
Description Unit Quantity US $ US $ Amount
No.
(letters) (Numbers) US $
Rates of Concrete Works shall include:-
1. All form works and shuttering (new lumber for
shuttering painted by special oil ) in any form, shape
and size . Making chamfered and curved edges,
allowing for and making grooves and sleeves and using
Tie Rods (Batant) for concrete walls ; removal of forms
and cleaning of all exposed tie wires and rods. Steel
forms must be used in shuttering the external
decorations.
2. Fuel or burned oil is not accepted to be used for
painting the lumber before use the form.
3. Supplying, Casting, vibrating and curing as per
specifications.
4. Approved additives and admixtures.
5. Incurred costs on New Concrete Job Mix Designs,
Sampling , testing and providing test results certificates,
storing and saving of samples.
6. Painting of exposed surfaces of underground
reinforced concrete elements with two coats of hot
bituminous paint (75/25) after primer layer , the strokes
of each layer to be opposite to each other.
7. Preliminary installations for Electrical, plumbing and
floor drainage in floor slabs including final floor slab.
8. Compaction and testing under the foundation, ground
beams, and ground slabs, the compaction should not be
less than 98% of MDD.
9. All works according to specifications , drawings and
supervisor engineer instructions
Note : All prices of concrete item should include the
steel reinforcement works as the follwoing:
10.Supply, fabricate and fix reinforcement steel (fy=
410 N/mm2) for all the structural elements according to
drawings and engineer's instructions for any grade, size
and length as detailed in the drawings, storing on site
including cutting, bending and fixing in position and
providing all tying wires, spacers, shop drawings,
testing and bar bending schedules .All works according
to specifications , drawings and supervisor engineer
instructions
Supply and cast ready mix plain concrete B (200)
2.1 kg/cm2 for Blinding beds 5 cm thick including M3 1
polythene sheets as per specifications and drawings.
2.2 Ditto, under cold water tank 10cm thick M3 1
Contractor's Signature and Seal
Package #8: Construction of Tal El Sultan Secondary School #2 in Rafah ITB 2013‐032
Bill No (B)
2. CONCRETE works
Unit Rate Unit Rate Total
Item
Description Unit Quantity US $ US $ Amount
No.
(letters) (Numbers) US $
ditto, but B250 reinforced concrete for Apron (surface
treated with mechanical steel toweled finish) the price
include polythene sheets. Reinforcement Ø 8mm / 15
2.8 M2 40
cm in both way and reinforced edge beam. The price
including 15cm thick compacted base coarse to 100% of
MDD according to drawing and specification.
Supply and cast ready mix reinforced concrete B250 kg/
cm2 for suspended hollow block slab 20 cm thick ,
including the reinforced steel, drop and inverted beams,
2.9 M2 40
hollow cement block 40*25*14, and all other materials
needed to finish the work as per specifications and
drawings.
Total
Contractor's Signature and Seal
Package #8: Construction of Tal El Sultan Secondary School #2 in Rafah ITB 2013‐032
Bill No (B)
3. BLOCK works
Unit Rate Unit Rate Total
Item
Description Unit Quantity US $ US $ Amount
No.
(letters) (Numbers) US $
The price include:
1- supplying hollow or solid cement block from good
and approved factory in perfect dimension and build it
in good manner with a compressive strength 35 kg/cm2
for hollow block and 60 kg/cm2 for solid block. This
item will include cement mortars, reinforced concrete
infill (B250) between columns & block walls (10-20 cm
wide) with 1Ø8mm/40cm horizontally and 2Ø8mm
vertically according to drawings, pipes encasement,
false columns 20x20 cm/4.0m among the parapet wall
with 4Ø12mm and bituminous paper between block
work and drop beams & all requirements needed to
finish the works according to the drawings, specification
and to the supervision engineer instructions.
3.1 Supply and build hollow cement blocks 40x20x20cm. M2 55
3.2 Ditto but 40x20x 15 cm thick for the parapet wall M2 10
Total
Contractor's Signature and Seal
Package #8: Construction of Tal El Sultan Secondary School #2 in Rafah ITB 2013‐032
Bill No (B)
4. METAL works
Unit Rate Unit Rate Total
Item
Description Unit Quantity US $ US $ Amount
No.
(letters) (Numbers) US $
The item include supplying white aluminum windows
section 7000 with two rails, with min. wall thick
1.5mm(be approved by representative engineer )as
frame, glass 4 mm thick, fironmongery , accessories and
hard ware as per specification and drawings.
-Steel work should be Paint with two coats of oil paint
& one primer (polyzinc).
Supply fix and paint flush galvanized steel single leaf
door D4 all fittings overall size 110x220cm, double
4.1 sheet (2-mm), complete with frame ,ironmongery, No. 1
hardware with locked type wally switch or equivalents.
.as per specification and drawings.
Supply and fix aluminum window W6, overall size
4.2 No. 3
120x120cm.
Supply and fix galvanized steel protection for windows
over all size 120x110 cm .the prices including mild steel
frame size 8mm thick x 40mm wide, vertical steel plate
size 20mm wide x 8mm thick fixed every 12cm C.C by
4.3 welding to the frame and circular steel plate size No. 3
20x2mm as stiffeners and two horizontal steel stiffeners
size 20x8mm. Fixed on walls by steel angle ties,
painting with oil paint, all according to drawing,
specification and engineer instructions.
Total
Contractor's Signature and Seal
Package #8: Construction of Tal El Sultan Secondary School #2 in Rafah ITB 2013‐032
Bill No (B)
5. FINISHING works
Unit Rate Unit Rate Total
Item
Description Unit Quantity US $ US $ Amount
No.
(letters) (Numbers) US $
A- Plaster works
All works must be according to drawings, specification
and engineer instructions. Rates shall include :
Supply of all needed materials, including galvanized
angles for the corners, windows and external decoration
as well as the use of galvanized wire mesh between
concrete and block work.
Preparation works by covering all conduits of electricity,
water supplies , etc, with a galvanized wire mesh at
least 20cm width coated by mortar (1:1) cement : sand
and the work includes removal of wires and nails and
cleaning of surfaces to be ready for plastering.
Contractor's Signature and Seal
Package #8: Construction of Tal El Sultan Secondary School #2 in Rafah ITB 2013‐032
Bill No (B)
5. FINISHING works
Unit Rate Unit Rate Total
Item
Description Unit Quantity US $ US $ Amount
No.
(letters) (Numbers) US $
Supply and make external plastering 20mm thick to
walls with four faces : the first is the rough nail
rendering (mix 1:1) cement sand; the second is 5mm
thick mortar (mix 1: 2) cement:sand, the third is the
5.2 undercoat 13mm (mix 1: 3 :0.25) cement:sand:lime, the M2 65
forth is two coats of Tyrolean finish ( mix 1: 3) white
cement to fine aggregate (Quartiz) and all is according to
specifications , drawings and supervisor engineer's
instructions
Supply and make external plastering 20mm thick for
decorates at four faces : the first is the rough nail
rendering (mix 1:1) cement:sand, the second is 5mm
thick mortar (mix 1: 2) cement:sand, the third is the
5.3 undercoat 13mm (mix 1: 3 :0.25) cement:sand:lime; the M2 15
forth is make Finishing Coat, smooth surface with
(1:1:1) cement:sand mortar:lime. and all this is
according to specifications , drawings and supervisor
engineer's instructions
Supply and install terrazzo floor tiles size 25cmx25cmx2.5cm
with Basalt stone laid on 2cm mortar bed and 5 cm thick sand
5.4 bed and the price including terrazzo skirting of same kind and M2 25
color of the floor tiles 25cmx7cm x1cm thick laid on 1 cm
mortar
Supply and cast terrazzo edge beam 25cm wide x6cm thick of
the same kind and color of the floor tiles including smoothing
5.5 Mr 2
the surfaces and edges (for thresholds )as per specification and
drawing
Supply and install white glazed wall tiles (grade A) size 20cm
5.6 x20 cm x 6 mm thick laid non mortar backing up to lintel level M2 35
as specified in the drawing and approved by the engineer.
Total
Contractor's Signature and Seal
Package #8: Construction of Tal El Sultan Secondary School #2 in Rafah ITB 2013‐032
Bill No (B)
6. PLUMBING works
Unit Rate Unit Rate Total
Item
Description Unit Quantity US $ US $ Amount
No.
(letters) (Numbers) US $
Supply and fix stainless steel single bowel sink basin
size 80cm x40cm (type Foster), complete with water
supply pipes ½” , waste, fitting, trap, chain, long swan
6.1 No 1
neck water tap ( Hamat or equivalent), and the drainage
line 2” to the nearest floor trap as specification and
drawings
Supply and install Galvanized steel pipe and fittings (1”)
including insulation with asphalt paper, excavation &
backfilling with clean sand , jointing using all
6.2 Mr 35
necessary fittings, valves and fixing with brackets
screwed to concrete or block work as specification
,drawings and engineer instruction.
6.3 Ditto but (3/4”) internal diameter. Mr. 30
Supply and fix galvanized steel threaded pipe 3”
including jointing, fittings Tee ,elbows ,shows,& fixing
6.4 to walls with metallic brackets and 3 inch diameter wire Mr 4
balloon grating and floor traps as specification and
drawings.
Supply and fix water storage plastic tank 1.5 m3
capacity with locks for cover, with approved type not
less than 32 kg weight, complete with lockable cover,
1 inch diam. automatic float valve, overflow pipe
6.5 No. 2
(1”diam) and drip tray, with all connections for rising
main and distribution pipe work and stop valves 1”
with all accessories as specification and drawings,
including painting tanks with white oil paint .
Supply and install concrete manhole of internal diameter
60 cm ,and (50-90) cm depth according to the required
6.6 level, 10cm thick plain concrete for walls and base, slab, No 2
with cast iron cover with frame 40cm opening, 8 ton
bearing capacity ,according to specification and drawing
Ditto but with 80 cm internal diameter (100-
6.7 No 2
150cm)depth
Supply and fix floor trap 4-inch diameter, complete with
heavy-duty brass grating and 2-inch diam. UPVC
6.8 No 1
drainage pipe to the nearest manhole as specification
and drawings.
Supply and install steel stop valve (1”) internal diameter
6.9 including jointing using all necessary fittings as No. 1
specification and drawings
Supply and install UPVC pipes 160mm, SN8 for
drainage, with sockets ,work includes excavating of
trenches (depth 0.75-1.5m),bedding, compacted
6.1 Mr 60
backfilling with clean sand, connecting to the manholes
and hydraulic test according to the specifications and
drawings
6.11 Ditto but 100mm (4”) internal diameter. Mr 10
Total
Contractor's Signature and Seal
Package #8: Construction of Tal El Sultan Secondary School #2 in Rafah ITB 2013‐032
Bill No (B)
7. ROOFING works
Unit Rate Unit Rate Total
Item
Description Unit Quantity US $ US $ Amount
No.
(letters) (Numbers) US $
Supply and cast foam concrete with fine aggregates for
7.1 roof screeding of average thickness 10 cm as shown in M2 40
drawing.
Supply and lay one layer of plasticised bitumen roofing
membrane with chipping 4 mm thick, including priming
concrete surface prior to laying, dressing into rainwater
7.2 M2 40
outlets to form waterproofing seal and cover with angle
fillets. The rate includes verticals parts skirting as per
specification and drawings.
Total
Contractor's Signature and Seal
Package #8: Construction of Tal El Sultan Secondary School #2 in Rafah ITB 2013‐032
Bill No (B)
8. PAINTING works
Unit Rate Unit Rate Total
Item
Description Unit Quantity US $ US $ Amount
No.
(letters) (Numbers) US $
All the painting materials should be approved and tested
by approved local laboratory and have the final
Approved from the Eng.
Supply and Paint one-primer and minimum two coats of
8.1 Poliside for internal walls, ceiling and drop beams as M2 60
specification and drawings.
Supply and Paint, external walls with one coat of
Pendrole primer and at least two coats of External
8.2 M2 80
quality of colored emulsion (Weather Shield) or equal
approved as specification and drawings
Total
Contractor's Signature and Seal
BILL of QUANTITIES
(C)-Construction of
standard Basket and
Volleyball Playground
Package #8: Construction of Tal El Sultan Secondary School #2 in Rafah ITB 2013‐032
Bill No (C)
1.Playground works
Unit Rate Unit Rate Total
Item
Description Unit Quantity US $ US $ Amount
No.
(letters) (Numbers) US $
Supply ,spreading ,leveling , damping and compacting 20cm
(M.D.D 100%) of base coarse material with CBR≥80 including
the excavation and backfilling with approval clean sand or
kurkar leveling up to required levels, compaction of subgrade
1.1 M2 460
to 98% MDD & removing trees or any other obstruction
items available in the proposed area of the playground and
removing all arising debris from the site according to drawing
specifications and under supervision .
Supply and cast plain concrete B250 kg/cm2 for bases of
volleyball poles of size 70x70x70cm including excavation,
1.2 No. 2
bitumen paint , backfilling with clean sand and steel sleeve
2.5”.
Supply and cast ready mix reinforced concrete B250 kg/cm2
for the floor slab 12 cm thick including expansion joints, by
cutting the concrete slab 4mm thick & 5cm depth, mastic
1.3 sealant, polythene sheets below concrete slab and M2 460
mechanical steel trowelling for the surface, complete with
the boundary chamfered beams 20cm wide and 40 cm depth.
as per specifications and drawings.
Supply and fix two galvanized steel pipes with standard
volleyball net, each pipe consists 2‐inch diam./3.2 mm thick
1.4 L.S 1
and 300 cm long pipe to be put inside the sleeve, work
includes priming, undercoats of two white oil paint.
Supply and fix movable galvanized steel basket ball towers as
detailed in the drawing including fiberglass board size
180x120x1.6cm with steel frame of angle 50x20x5mm.. steel
plate size 60x40x0.6 cm, standard steel ring and net as shown
1.5 No. 2
on the drawings. The work also include painting of all the
steel elements with poly zinc primer and at least two coats
of while/black oil paint and the fibber glass board with black
and white colors.
Painting of basket and volleyball playground lines 5 cm
wide in two different colors (white and yellow) with
1.6 L.S 1
special paint for sports and according to the engineer
instruction.
Total
Contractor's Signature and Seal
Tal Al - Sultan School
Bill of Quantities
Bill No (D)
1.BOUNDARY WALL WORKS
Unit Rate Unit Rate Total
Item
Description Unit Quantity US $ US $ Amount
No.
(letters) (Numbers) US $
‐Compressive strength for solid block not less than 60kg/cm2.
‐Painting all the steel elements with one coat primer, under
coat, 2 coats of oil paint
* Rates of Concrete Works shall include:‐
1. All form works and shuttering (new lumber for shuttering
painted by special oil ) in any form, shape and size . Making
chamfered and curved edges, allowing for and making
grooves and sleeves and using Tie Rods (Batant) for concrete
walls ; removal of forms and cleaning of all exposed tie wires
and rods. Steel forms must be used in shuttering the external
decorations.
2. Fuel or burned oil is not accepted to be used for painting
the lumber before use the form.
3. Supplying, Casting, vibrating and curing as per
specifications.
4. Approved additives and admixtures.
5. Incurred costs on New Concrete Job Mix Designs, Sampling
, testing and providing test results certificates, storing and
saving of samples.
6. Painting of exposed surfaces of underground reinforced
concrete elements with two coats of hot bituminous paint
(75/25) after primer layer , the strokes of each layer to be
opposite to each other.
7.The excavation &backfilling with imported clean sand.
8. Compaction and testing under the foundation, ground
beams, and ground slabs, the compaction should not be less
than 98% of MDD.
9. All works according to specifications , drawings and
supervisor engineer instructions
10.Supply, fabricate and fix reinforcement steel (fy= 410
N/mm2) for all the structural elements according to drawings
and engineer's instructions for any grade, size and length as
detailed in the drawings, storing on site including cutting,
bending and fixing in position and providing all tying wires,
spacers, shop drawings, testing and bar bending schedules
.All works according to specifications , drawings and
supervisor engineer instructions
* Compressive strength for solid block not less than
60kg/cm2.
* Painting all the steel elements with one coat primer, under
coat, 2 coats of oil paint
Supply and cast plain concrete B200 kg/cm2 for blinding beds
1.1 5cm thick including polythene sheet as per specifications and M3 12
drawings.
Supply and cast ready mix reinforced concrete B250 kg/cm2
1.2 for foundations (Strap footing, and gnd. beam) as per M3 75
specifications and drawings for boundary walls.
1.3 Ditto, but for top beams, columns and column necks. M3 35
Supply and built solid cement blocks type A 40x20x15cm for
1.4 M2 950
boundary walls as per specifications and drawings.
Contractor's Signature and Seal
Package #8: Construction of Tal El Sultan Secondary School #2 in Rafah ITB 2013‐032
Bill No (D)
1.BOUNDARY WALL WORKS
Unit Rate Unit Rate Total
Item
Description Unit Quantity US $ US $ Amount
No.
(letters) (Numbers) US $
Supply and fix polystyrene sheets 18mm thick and applying
mastic sealant 2cm depth and aluminum strip at the both
1.5 Mr 100
sides for boundary wall expansion joint at foundation and the
super structure as per specifications and drawings.
Supply and make external plastering 15mm thick and colored
Tyrolean finish coats for walls and colored external painting
1.6 M2 2200
finish for soffits and columns according to drawings,
specifications and under supervision.
Supply, fix and paint two leaves steel gate size 450 cm wide x
310cm high comprising of steel angles 40x40x4mm for frame
and stiffeners, 2mm steel sheets, each leaf will be fixed to
1.7 .No 1
reinforced concrete columns, three hinge pad lock 2” three
tower bolts and all needed accessories and rubber wheels
15cm diam as per specification and drawings
Total
Contractor's Signature and Seal
Tal Al - Sultan School
Bill of quantities
E - External Works
Package #8: Construction of Tal El Sultan Secondary School #2 in Rafah ITB 2013‐032
Bill No (E)
1.External Works
Unit Rate Unit Rate Total
Item
Description Unit Quantity US $ US $ Amount
No.
(letters) (Numbers) US $
Supply, spread , level and compact of 40cm thick in two
layers of approved selected material ( Kurkar ) with CBR ≥30
to be spread as bedding layer prior to subsequent tiling
1.1 including soil grading, leveling ,excavating, backfilling with M2 1200
approved material and all needed tests and compaction test 98
% for sub-base and Kurkar. The excess material form the site
up to the required level as per specifications and drawings
2
Supply & Cast ready reinforced concrete mix B250 kg/cm
1.2 for chamfered edge beams 20x30 as per specifications .M3 15
and drawings.
Supply, spread, land, colored interlock tiles 8 cm thick with
1.3 shape approved by engineer, the price includes 5 cm clean M2 1200
sand, compacting, tiles testing as per specification and drawing
Total
Contractor's Signature and Seal
Tal Al - Sultan School
Bill of quantities
F - Toilet Block
Package #8: Construction of Tal El Sultan Secondary School #2 in Rafah ITB 2013‐032
Bill No (F)
1.EXCAVATION & EARTHWORKS
Unit Rate Unit Rate Total
Item
Description Unit Quantity US $ US $ Amount
No.
(letters) (Numbers) US $
Contractor shall take into consideration that all – direct
and indirect works and expenses required for the
completion of the coming items are included in the uint
price.
All works must be according to drawings, specification
and engineer instructions. Rates shall include :
1. Shore up the sides of excavation and take all
precautions to keep the adjacent buildings and existing
infrastructure utilities (sewage, water, electricity and
telecommunication works )safe. And repaire any
damage occure in the site.
2. Cleaning the site and removing all debris and rubbles
to approved dump site.
3.Approval of Bench mark and leveling network before
excavation works.
4. Backfilling in layers not more than 25cm thick for
each layer and compaction to 98% of MDD.
5. Safety precautions to protect neighbor utilizes and
persons.
6. All required Tests should be accommedated by an
approved lab.
7. Laying out the buildings coordinates to be carrid out
by profesional surveyor using total station device.
8.price include leveling and backfilling from imported
sand to make up level around buildings up to the top of
external ground beams levels.
9.All the above mentioned and following specifications
is part of the contractor obligations.
1.1 Excavation in sandy soil or any other soils including
backfilling with selected or imported sand material
around foundations & any other element up to ground
slab level in layers not more than 25cm thick for each
layer with compaction to 98% of MDD. The works
including compacting the design soil surfaces to get
(98% MDD), The price also includes transportation of
the disapproved excavated material to approved dump
area according to supervision engineer’s instructions. L.S. 1
Total
Contractor's Signature and Seal
Package #8: Construction of Tal El Sultan Secondary School #2 in Rafah ITB 2013‐032
Bill No (F)
2.CONCRETE WORKS
Unit Rate Unit Rate Total
Item
Description Unit Quantity US $ US $ Amount
No.
(letters) (Numbers) US $
Rates of Concrete Works shall include:‐
1. All form works and shuttering (new lumber for shuttering
painted by special oil ) in any form, shape and size . Making
chamfered and curved edges, allowing for and making
grooves and sleeves and using Tie Rods (Batant) for concrete
walls ; removal of forms and cleaning of all exposed tie wires
and rods. Steel forms must be used in shuttering the external
decorations.
2. Fuel or burned oil is not accepted to be used for painting
the lumber before use the form.
3. Supplying, Casting, vibrating and curing as per
specifications.
4. Approved additives and admixtures.
5. Incurred costs on New Concrete Job Mix Designs, Sampling
, testing and providing test results certificates, storing and
saving of samples.
6. Painting of exposed surfaces of underground reinforced
concrete elements with two coats of hot bituminous paint
(75/25) after primer layer , the strokes of each layer to be
opposite to each other.
7. Preliminary installations for Electrical, plumbing and floor
drainage in floor slabs including final floor slab.
8. Compaction and testing under the foundation, ground
beams, and ground slabs, the compaction should not be less
than 98% of MDD.
9. All works according to specifications , drawings and
supervisor engineer instructions
Note : All prices of concrete item should include the steel
reinforcement works as the follwoing:
10.Supply, fabricate and fix reinforcement steel (fy= 410
N/mm2) for all the structural elements according to drawings
and engineer's instructions for any grade, size and length as
detailed in the drawings, storing on site including cutting,
bending and fixing in position and providing all tying wires,
spacers, shop drawings, testing and bar bending schedules
.All works according to specifications , drawings and
supervisor engineer instructions
Supply and cast ready mix for plain conc. B 200 under cold
2.1 M3 2
water tank 10cm thick
Supply and cast ready mix reinforced concrete B250 kg/cm2
for the ground slab 10 cm thick with steel mesh 8 mm
2.2 M2 40
diameter every 20 cm including polythene sheets below
concrete slab.
Supply and cast ready mix reinforced concrete B250 for
2.3 M3 3
foundations
2.4 Ditto but for ground beams. M3 5
2.5 Ditto but for lintels and sills. M3 2
2.6 Ditto, but B300 for columns and column necks. M3 3
Contractor's Signature and Seal
Package #8: Construction of Tal El Sultan Secondary School #2 in Rafah ITB 2013‐032
Bill No (F)
2.CONCRETE WORKS
Unit Rate Unit Rate Total
Item
Description Unit Quantity US $ US $ Amount
No.
(letters) (Numbers) US $
2.7 Ditto, but plain conc. B 200 under cold water tank 10cm thick m3 2
Supply and cast ready mix concrete B250 kg/cm2 for
suspended hollow block slab 20 cm thick, including the
2.8 reinforced steel, drop and inverted beams, making grooves M2 70
around the cantilever and all other materials, hollow cement
block 40x20x14cm as per specification and drawing
ditto, but B250 reinforced concrete for Apron (surface
treated with mechanical steel toweled finish) the price
include polythene sheets. Reinforcement Ø 8mm / 15 cm in
2.9 M2 60
both way and reinforced edge beam. The price including
15cm thick compacted base coarse to 100% of MDD
according to drawing and specification.
Total
Contractor's Signature and Seal
Package #8: Construction of Tal El Sultan Secondary School #2 in Rafah ITB 2013‐032
Bill No (F)
3.BLOCK WORK
Unit Rate Unit Rate Total
Item
Description Unit Quantity US $ US $ Amount
No.
(letters) (Numbers) US $
3 The price include:
1‐ supplying hollow or solid cement block from good and
approved factory in perfect dimension and build it in good
manner with a compressive strength 35 kg/cm2 for hollow
block and 60 kg/cm2 for solid block. This item will include
cement mortars, reinforced concrete infill (B250) between
columns & block walls (10‐20 cm wide) with 1Ø8mm/40cm
horizontally and 2Ø8mm vertically according to drawings,
pipes encasement, false columns 20x20 cm/4.0m among the
parapet wall with 4Ø12mm and bituminous paper between
block work and drop beams & all requirements needed to
finish the works according to the drawings, specification and
to the supervision engineer instructions.
3.1
M2 100
Supply and build hollow cement blocks type “A” 40x20x20cm.
3.2 Ditto but 10 cm thick. M2 20
Total
Contractor's Signature and Seal
Package #8: Construction of Tal El Sultan Secondary School #2 in Rafah ITB 2013‐032
Bill No (F)
4.CARPENTRY WORK
Unit Rate Unit Rate Total
Item
Description Unit Quantity US $ US $ Amount
No.
(letters) (Numbers) US $
Supply, fix and paint wooden single internal flush door type
D7 over all size 70x220x4.5cm complete with frame,
architrave, ironmongery, and hardware and 15cm aluminum
4.1 No 12
kick plate from both sides, 10cm brass hinges, steel latches
etc. & painting with oil paint according to the drawing,
specifications and under supervision.
Total
Contractor's Signature and Seal
Package #8: Construction of Tal El Sultan Secondary School #2 in Rafah ITB 2013‐032
Bill No (F)
5.METAL WORK
Unit Rate Unit Rate Total
Item
Description Unit Quantity US $ US $ Amount
No.
(letters) (Numbers) US $
‐The item include supplying aluminum windows type 4500
with min. wall thick 1.6mm and with all requirement as
frame, glass 4 mm thick, ironmongery , accessories and hard
ware as per specification and drawings.
‐Painting all the steel elements with one coat primer, under
coat, two coats of oil paint
Supply, fix and paint single external steel door type DS4 size
110x220cm complete with frame, ironmongery wally switch
5.1 No. 2
type, latch, lock…etc. According to drawings, specifications
and under supervision.
Supply and fix aluminum window type 7000 min wall thick
1.5mm , W7 , overall size 160 x 60cm, complete with frame,
5.2 white color, two sliding leaves and one for fly screen ,clear No 6
glass 4mm thick, ironmongery and hardware. And as per
specification and drawing.
Supply and fix Aluminum window 4500 W8 60x60 cm
5.3 No 12
with two hinged at the mid as per specification and drawings.
Supply and fix 1” galvanize steel pipe protection fixed
5.4 regularly to concrete edges 180 cm lengths including painting No. 18
with two coats of oil paint and one coats of poly zinc primer.
Total
Contractor's Signature and Seal
Package #8: Construction of Tal El Sultan Secondary School #2 in Rafah ITB 2013‐032
Bill No (F)
6.FINISHING WORKS
Unit Rate Unit Rate Total
Item
Description Unit Quantity US $ US $ Amount
No.
(letters) (Numbers) US $
A- Plaster works
All works must be according to drawings, specification
and engineer instructions. Rates shall include :
Supply of all needed materials, including galvanized
angles for the corners, windows and external decoration
as well as the use of galvanized wire mesh between
concrete and block work.
Preparation works by covering all conduits of electricity,
water supplies , etc, with a galvanized wire mesh at
least 20cm width coated by mortar (1:1) cement : sand
and the work includes removal of wires and nails and
cleaning of surfaces to be ready for plastering.
Contractor's Signature and Seal
Package #8: Construction of Tal El Sultan Secondary School #2 in Rafah ITB 2013‐032
Bill No (F)
6.FINISHING WORKS
Unit Rate Unit Rate Total
Item
Description Unit Quantity US $ US $ Amount
No.
(letters) (Numbers) US $
Supply and make external plastering 20mm thick to walls with
four faces : the first is the rough nail rendering (mix 1:1)
cement sand; the second is 5mm thick mortar (mix 1: 2)
cement:sand, the third is the undercoat 13mm (mix 1: 3
6.2 M2 80
:0.25) cement:sand:lime, the forth is two coats of Tyrolean
finish ( mix 1: 3) white cement to fine aggregate (Quartiz) and
all is according to specifications , drawings and supervisor
engineer's instructions
Supply and make external plastering 20mm thick for
decorates at four faces : the first is the rough nail rendering
(mix 1:1) cement:sand, the second is 5mm thick mortar (mix
1: 2) cement:sand, the third is the undercoat 13mm (mix 1: 3
6.3 M2 25
:0.25) cement:sand:lime; the forth is make Finishing Coat,
smooth surface with (1:1:1) cement:sand mortar:lime. and all
this is according to specifications , drawings and supervisor
engineer's instructions
Supply and install non‐slipping ceramic (grade A) size
6.4 M2 44
20cmX20cmX6mm thick for floor.
Supply & fix pre‐cast terrazzo drinking point units size
214x50x25cm including the followings;
‐ polishing and smoothing, forming slope.
‐ built on 3 concrete piers 15cm thick, at least 3 piers per unit.
required pipes ½”and fittings for cold water supply and 4
6.5 taps 1/2 " (Tebisea type or equivalent). No. 6
‐ 2" PVC drainage pipe to the nearest manhole
‐ 60cm high of white glaze tiles above it .
‐ painted galvanized steel cover box for protections, wire
mesh grill complete with frames and lock, brass grating &
complete with all fittings according to the drawing. and
specifications.
Supply and install white glazed wall tiles (grade A) size
6.6 M2 180
20cmx20cmx6 mm thick laid on2cm mortar (1:3).
Supply and install local marble (grade A) size 25cm wide x
3cm thick for windows sills and edge beam laid on 2cm thick
6.7 Mr 21
mortar bed with water drip greeve as approved by the
Engineer and as specification and drawings.
Total
Contractor's Signature and Seal
Package #8: Construction of Tal El Sultan Secondary School #2 in Rafah ITB 2013‐032
Bill No (F)
7.PLUMBING WORKS
Unit Rate Unit Rate Total
Item
Description Unit Quantity US $ US $ Amount
No.
(letters) (Numbers) US $
Supply and fix white glazed fireclay hand wash basin
size 56cm x43cm (HARSA Type) or equivalent,
complete with all water supply pipes ½", waste fitting,
7.1 No. 4
trap, plug and chain, swan neck water tap( Hamat or
equivalent) and mirror 60x60cm, and the drainage line
2” to the nearest floor trap.
Supply and fix white glazed fireclay Oriental squatting
W.C. suite (HARSA Type), or equivalent complete with
plastic flushing cistern, and fixed chromium plated tap
7.2 1/2”, including all water supply pipes ½", flushing No. 10
mechanism, angle valves, 4” diam PVC drainage pipe to
the nearest manhole as specification and drawings. as
specification and drawings.
7.3 Ditto but European W.C No. 2
Supply and fix floor trap 4inch diameter, complete with
heavy duty brass grating and 4”& 2” UPVC drainage
7.4 No. 9
pipe to the nearest manhole or next F.T and including S
trap if needed as specification and drawings.
Supply and install Galvanized steel pipe and fittings (1”)
including insulation with asphalt paper, excavation &
backfilling with clean sand , jointing using all
7.5 Mr. 50
necessary fittings, valves and fixing with brackets
screwed to concrete or block work as specification
,drawings and engineer instruction.
7.6 Ditto but (3/4”) diameter. Mr. 40
Supply and fix water storage plastic tank 1.5 m3
capacity with locks for cover, with approved type not
less than 32 kg weight, complete with lockable cover,
1 inch diam. automatic float valve, overflow pipe
7.7 No. 4
(1”diam) and drip tray, with all connections for rising
main and distribution pipe work and stop valves 1”
with all accessories as specification and drawings,
including painting tanks with white oil paint .
Supply and install UPVC pipes 160mm, SN8 for
drainage, with sockets ,work includes excavating of
trenches (depth 0.75-1.5m),bedding, compacted
7.8 Mr. 60
backfilling with clean sand, connecting to the manholes
and hydraulic test according to the specifications and
drawings
7.9 Ditto but 110mm internal diameter. Mr. 20
7.10 Ditto but 110mm for vent-pipe Mr. 8
Supply and install concrete manhole of internal diameter
60 cm ,and (50-100) cm depth according to the required
level, 10cm thick plain concrete for walls and base, slab,
7.11 with cast iron cover with frame 50cm opening, 8 ton No. 10
bearing capacity, including excavation, backfilling,
hunching and making good according to specification
,drawing, and the engineer instructions.
Ditto, but with 80 cm internal diameter (105-
7.12 No. 6
150cm)depth
Total
Contractor's Signature and Seal
Package #8: Construction of Tal El Sultan Secondary School #2 in Rafah ITB 2013‐032
Bill No (F)
8.ROOFING WORKS
Unit Rate Unit Rate Total
Item
Description Unit Quantity US $ US $ Amount
No.
(letters) (Numbers) US $
Supply and cast foam concrete with fine aggregates for
roof screeding of average thickness 7 cm including
8.1 M2 70
conc. Angle fillet 5cmx5cm around the boundary as
shown in drawing.
Supply and lay one layer of plasticized bitumen roofing
membrane with chipping 4 mm thick, including priming
concrete surface prior to laying, dressing into rainwater
outlets to form waterproofing seal and cover with angle
8.2 M2 70
fillets. The rate includes verticals parts skirting 25cm
height as per specification and drawings.
Note: Measurement will be for the horizontal projection
Total
Contractor's Signature and Seal
Package #8: Construction of Tal El Sultan Secondary School #2 in Rafah ITB 2013‐032
Bill No (F)
9.PAINTING WORKS
Unit Rate Unit Rate Total
Item
Description Unit Quantity US $ US $ Amount
No.
(letters) (Numbers) US $
All the painting materials should be approved and tested
by approved local laboratory and have the final
Approved from the Eng.
Supply and Paint one-primer and minimum two coats of
9.1 Poliside for internal walls, ceiling and drop beams as M2 85
specification and drawings.
Supply and Paint, external walls with one coat of
Pendrole primer and at least two coats of External
9.2 M2 100
quality of colored emulsion (Weather Shield) or equal
approved as specification and drawings
Total
Contractor's Signature and Seal
Tal Al - Sultan School
Bill of quantities
G - Electrical works
Package #8: Construction of Tal El Sultan Secondary School #2 in Rafah ITB 2013‐032
Bill No (G)
1- ELECTRICAL WORKS
Unit Rate Unit Rate Total
Item
Description Unit Quantity US $ US $ Amount
No.
(letters) (Numbers) US $
Al the following items shall include erecting the flush and/or
surface type electrical wirings according to drawings,
specifications and engineer instructions, the items should be
executed completely including all materials and accessories
needed such as wires, cables, conduits, boxes,..Retc.
Supply, install, connect and test ceiling mounted fluorescent
lighting fixture 2x36w complete with lighting tubes 36, chock,
1 condensers, starters, rigid PVC conduits, J.boxes, fixing NO 42
screws (Galv.) and wiring. (Type is GA'ASH No. 50540 or
equivalent)
2 Ditto but 1x36w NO 6
3 Ditto but 1x36 w with special reflector for black board NO 90
4 Ditto but round bulk head light, water proof, 60 w lamp No 72
Ditto but lighting luminaries 150w HPS lamp for external
5 lighting, work is complete with all accessories and wires of NO 5
4mm2
Supply and install single pole 10A ON/OFF switch from
"Bticino‐luna" BN white complete with the internal box 503
BP "114x79x46mm", support frame C4 703 and cover
6 NO 13
plat4803/1BN, the work includes all accessories needed such
as wires , pipes, fixing bolts, connection and commissioning
.As per drawings and specification.
7 Ditto but double pole switch 10A and with cover plate NO 3
8 Ditto but triple pole switches with cover plate NO 27
9 Ditto but two ways switch 1P 16N NO 19
10 Ditto but push button 10A1P NO 11
Ditto but socket outlet (2P+E) 10/16A, complete with all
11 NO 122
accessories for connection and commissions.
Ditto for external uses, type is Bticino complete with all
12 NO 18
accessories.
Ditto but telephone socket complete with all accessories and
13 No 4
wires.
Ditto, but computer sockets outlet complete with all conduits
14 and cables from the socket to the main computer junction No. 15
box, type STP, cat 5.
15 Ditto, but satellite sockets. No. 5
Supply, install , connect and test computer rack U6 with
patch panels 24 port and Cisco 24 Port Router for telephone
16 and data complete with all connection strips, termination, L.S 1
cables from socket outlet to rack and from rack to telephone
as per drawings and engineers instructions .
Supply and install school electrical two bell with two push
17 L.S 1
buttons connected together
18 Ditto but domestic bell No 1
Supply and install electrical ceiling fan 220V\125W, with its
19 No 34
switch and connection , type is CHMC or equivalent
Supply and install 2x60W amplifier with TWO horn loud
20 speakers , 50 W each, two microphones and connection, set 1
include steel protection box around the loud speakers.
Supply and install amplifier socket out let , the work including
21 No 2
wires, conduits, j. boxes and all necessary accessories.
Contractor's Signature and Seal
Package #8: Construction of Tal El Sultan Secondary School #2 in Rafah ITB 2013‐032
Bill No (G)
1- ELECTRICAL WORKS
Unit Rate Unit Rate Total
Item
Description Unit Quantity US $ US $ Amount
No.
(letters) (Numbers) US $
Earthing System : Supply, install, and commission complete
earthing system includes the following:
welding 3.5x30mm galvanized steel sheets and
connection to main distribution board .Cupper electrodes with
22 diameter 25 mm inside manhole . Four 60cm manholes with L.S 1
its standard covers. Wires of 35mm2 NYA , pipes , boxes ,
all accessories & civil works required. All works according to
drawings, specifications and engineer instructions. The
resistance of the system must not exceed 2 ohm.
Supplying and installing 80cm manhole with 8 ton cover,
23 No 1
15cm base coarse
24 Ditto but 60 cm No 6
Supply and install 3” PVC pipe in depth 90cm, the work
25 includes excavation, 20cm clean sand bedding backfilling and MR 170
warning tape.
26 Ditto but 2” PVC pipes MR 70
27 Ditto but 1.5” PVC pipes (rigid) MR 20
Supply and install a wooden pole of 8.5m height and 1.5m to
be driven in soil, the work includes painting the lower part of
28 NO 1
the pole by cold bitumen, all accessories should be used in
connection.
Supply and install lighting octagonal pole of 10m height,
including concrete base with the four poles for fixing and 10A
C.B for control, installed on fiberglass plate The pole is
29 NO 2
supplied with lighting luminaries from GA’ASH CAT no5764
compete with lamp 250W, including arm 40cm, cable
3x2.5mm2, according to specifications and drawings
Supply and install electrical switch board of size 120x80x25
cm , two doors, the frame work is made of galvanized steel
sheets 2mm thickness, painted by antistatic and insulation
paint . steel sheets with anti‐static paint,indication lamps ,
30 No 1
bus bars for phases , neutral and earthing terminal with all
necessary accessories and material to hand over clean and
tested ad in operating conditions . Type is MOLLER or
equivalent with high degree of protection
31 Ditto but 80x60x20cm one door. No 1
32 Ditto, but 80X60X20 cm two doors No. 1
33 Ditto but size 60x40x20cm No 5
Ditto but PVC dist‐board 24CB capacity, type is GEWISS or
34 No 1
equivalent
Contractor's Signature and Seal
Package #8: Construction of Tal El Sultan Secondary School #2 in Rafah ITB 2013‐032
Bill No (G)
1- ELECTRICAL WORKS
Unit Rate Unit Rate Total
Item
Description Unit Quantity US $ US $ Amount
No.
(letters) (Numbers) US $
35 Supply and install the followings
a) NZM6‐ 63A/ZM‐63A NO 1
b) NZM 6‐100A ZM6 100A NO 1
c) LTL fuses 3x60A/100A Set 1
d) KWHM 3X60A NO 1
e) Three phase C.B 3x40A . (Type is MOELLER FAZ‐3‐C40 or
NO 2
equivalent).
f) Three phase C.B 3x32A. (Type is MOELLER FAZ‐3‐C32 or
NO 13
equivalent).
g) Three phase C.B 3x25A . (Type is MOELLER FAZ‐3‐C25 or
No 6
equivalent).
h) Single phase C.B 1x32A (Type is MOELLER FAZ‐1‐C32 or
NO 2
equivalent).
i) Single phase C.B 1x25A (Type is MOELLER FAZ‐1‐C25 or
NO 2
equivalent).
j) Single phase C.B 1x16A (Type is MOELLER FAZ‐1‐C16 or
NO 56
equivalent).
k) Single phase C.B 1x10A (Type is MOELLER FAZ‐1‐C10 or
NO 24
equivalent).
l) Three phase 4 poles residual current C.B 4x40A, 0.03A NO 9
m) One phase 2 poles residual current C.B, 2x40A, 0.03A NO 1
n) PSK Staircase light switch timer , 16A ,220V NO 3
o)KVARM3 ph 60A No 1
p)capacitors unit 10KVAR complete with mcb and resistor No 1
Voltmeter with 7 position selector switch complete with all
36 No 1
accessories
37 Ammeter with 3‐CTs 100/5A , complete with all accessories No 1
38 Supply , install , connect and test the following cable
a) XLPE cable 5x16 mm2 MR 50
b) XLPE cable 5x10 mm2 MR 160
c) XLPE cable 5x6 mm2 MR 160
d) XLPE cable 5x4 mm2 MR 20
e) NYY CABLE 3x6mm2 MR 100
f) NYY CABLE 3x4 mm2 MR 50
2
Supply and install XLPE Cu cable 3*25+16 mm with all
39 MR 100
accessories needed for connection to pillar.
Total
Contractor's Signature and Seal
Package #8: Construction of Tal El Sultan Secondary School #2 in Rafah ITB 2013‐032
OVERALL SUMMARY