Professional Documents
Culture Documents
Date-03/10/17
Mounting
Wall ( Ref ).
Top & bottom housing fixing with M3 hexgeonal posts (04 no“s) as show,
2
Place the Clamp for wall mounting on bottom housing fixing with M3x8 screws(2 No's) as shown.
Wall
3
Place the Base Clamp for wall mounting (W/O Printer ) of GL-11 POS on the wall and install with 8*25.4 Type A
screws(2 No's) as shown.
4
Place the assembled GL-11 POS unit into the base clamp as shown direction.
5
Unit and base clamp assembly with the help of M3x8 screws (2 No's) as shown .
Place the Housing for wall mounting with base clamp as shown.
Disclaimer: VISIONTEK ® is a registered trademark owned by Linkwell Telesystems Pvt. Ltd.. Other brands and names mentioned herein may be the trademarks of their respective
owners. Neither the whole nor any part of the information contained in, or the product described in, this document may be adapted or reproduced in any form without the prior written
permission of the copyright holder. The product described in this document is subject to continuous developments and improvements. All particulars of the product and its use contained in
this document are given by Linkwell Telesystems Pvt. Ltd. in good faith. However, all warranties implied or expressed, including but not limited to implied warranties of merchantability, or
fitness for purpose, are excluded. This document is intended only to assist the reader in the use of the product. Linkwell Telesystems Pvt. Ltd. shall not be liable for any loss or damage
arising from the use of any information in this document, or any error or omission in such information, or the use or inability to use the product.