You are on page 1of 6

-

Technical Specifications

Parameter Symbol Value Unit

Supply Voltage V

Supply Pressure
Output force

No-load speed

Flow rate required

Stroke s

Supply air temperature

Ambient air temperature

Description

PG-27 actuator is an integrated system, combining the pneumatic linear motion driver, the electromagnetic
servo valve and the feedback device (Figure 2, Figure 3). When the actuator is activated, hot air is supplied to
the inlet port, then goes through the servo valve before coming to the cylinder chambers to drive the piston.

the feedback signal coming from the potentiometer, the controller will make decision of how much control
signal should be produced to achieve the desired motion. The output analog signal is then amplified and used
to drive the torque motor. This motor has a magnet rotating in the magnetic field generated by two solenoids.
The jet pipe is attached to the rotor and swings in the field. The current moving through the coils changes in
accordance with the voltage being applied. So does the magnetic field. Hence, by varying the voltage applied
on two solenoids, one can vary the j

which direct high pressure air to two separated chambers inside the cylinder. The force equilibrium on the
once the jet pipe moves to either direction, which causes the piston to move in the same
direction.

1
Figure 1

2
Figure 2 Figure 3

Part Number Name Part Number Name

1 Pneumatic servo valve 7 -


Cylinder Piston
2 8 Nut
Assembly
3 Inlet port 9 Washer

4 Discharge port 10 Screw M3 x 16

5 Bracket clamp 11 Screw M4 x 10

6 - 12 Screw M4 x 12

3
Servo Valve Assembly

Figure 4

Part Number Name Part Number Name

1 Torque motor 17 Screw

2 Jet pipe 18 Screw


Flow distribution
3 19 Nut
manifold
4,5,6 Seals 25 Bearing

7 Body 28 Screw M2 x 8

9 Rotating shaft 29 Screw M2.5 x 6

10 Adjusting screw 30 Screw M3 x 8

11 Lock nut 31 Washer

14 Cover 32 Screw M2 x 4

16 -

4
Torque motor

Figure 5

Part Number Name Part Number Name

1 Solenoids 4 Magnetic Frame

2 Solenoid core 5 Insulator

3 Magnet

5
Jet pipe assembly

Figure 6

Part Number Name Part Number Name

1 Solenoids 5 Flange

2 Jet pipe 6 Washer


Pipe connector with
3 7 Flat washer
ball joint
4 Nut 8 Screw M2 x 6

You might also like