Professional Documents
Culture Documents
4531/3(PP)
Fizik
Kertas 3
September
2008
PEPERIKSAAN PERCUBAAN
SIJIL PELAJARAN MALAYSIA 2008
FIZIK
Kertas 3
PERATURAN PEMARKAHAN
1
1. The responding variable, at y axis, 1
v
1
the manipulated variable, at x axis
u
2. States the unit of the variable correctly
3. Both axis with the even and uniform scale 2
4. All of 5 points correctly plotted. 3
4-1 points correctly plotted 4, 5
4. A smooth best fit straight line 4
5. Minimum size of the graph is 10 cm x 8 cm 6
7
No of ticks √ Marks
7 5
5,6 4
3,4 3
2 2
1 1
4531/3 SULIT
SULIT 3 4531/3
1
/ cm 1
v
0.07
0.06
0.05
0.04
0.03
0.02
0.01
1
0.01 0.02 0.03 0.04 0.05 0.06 / cm 1
u
(d) 1 1 1
is decreases linearly to
v u
* If the graph that has been plotted does not cross axis-y. Cancel
any answer in (d).
(e) Put on the curtain to avoid excess light from outside. 1
4531/3 SULIT
SULIT 4 4531/3
(b)(i) Calculate the gradient of the graph and state the value
within the acceptable range
(b)(ii) Gradient
State λ =
D 1
Substitute the gradient from b (i) correctly
2.5
= 1
5
State the correct answer with unit
λ = 0.5 m 1
(d) State ONE correct precaution so as to produce an accurate
result of the experiment
SECTION B
NO ANSWER Marks
3(a) Inference : 1
The volume of the gas depends on the pressure which acts on it.
(b) Hypothesis:
4531/3 SULIT
SULIT 5 4531/3
The smaller the pressure on a fixed mass of gas, the larger is the volume 1
of gas.
(c) Aim : To investigate the relationship between pressure and volume for a
(i) fixed mass of gas at a constant temperature. 1
(ii) Variables : Manipulated : Gas pressure, P 1
Responding : Gas volume, V
Fixed : Temperature of gas, T // mass of gas, m 1
3
(iii) Apparatus : 100cm glass syringe, load, and a short rubber tube, and 1
Bourdon gauge.
(iv) Arrangement of apparatus:
1
100 g
Load 200 g syringe Rubber tu
300 g
400 g
500 g
(v) Procedure:
1. The apparatus is set up as shown in the diagram
above.
2. The piston of the syringe is adjusted until the volume of air in the 1
syringe is 50 cm3.
3. Put 100 g of load on the top of piston and the reading of the Bourdon 1
gauge is taken.
4. The volume of the air trapped is measured from the syringe after
slotted mass is put on the top of the piston. 1
5. The experiment is repeated by using different mass = 200g, 300g,
400g, and 500g.
(vi)
Mass of load/g Pressure, P / kPa Volume, V/ cm3
100
1
200
300
4531/3 SULIT
SULIT 6 4531/3
400
500
(vii) / cm3
3
V/ cm
P/ kPa P/ kPa
Pressure of a fixed mass of gas is inversely proportional to its volume.
TOTAL 12
4531/3 SULIT
SULIT 7 4531/3
4531/3 SULIT