Professional Documents
Culture Documents
Industry Online Support Deutsch Contact Help Support Request Site Explorer Search in Online Support
Home Forum Product Conferences Communication / Networks Product Support Services Forum mySupport
Low-Voltage Controls I've already loaded the modbus drivers,set up the comunication
parameters for communicating with two devices, one PM710 and one
Building Technology Sepam 40, i need to read some data.
Solutions, Applications and Initiatives I used FB7 (P_RCV_RK ) and FB8 (P_SND_RK) and built a block that
General Conferences works when reading the PM710 but does not with Sepam; in last case
Platinum Member i'm receiving error 830. I've checked the wiring and seems to be all
Quicklinks
right.
Forum Terms Joined: 4/19/2008 The communication parameters for both devices are:
Last visit: 4/11/2018 • 19200
• 8 bit,
Posts: 1522
• 1 bit stop
Rating:
• Even
(154) The frames i'm sending include the following information:
• Slave number
• Function code (3)
• Starting registre number
• Data length
Do you have any suggestion or advice?
Hi Docfv9,
Ammy
I'm using a CP-341 and the drivers are already loaded and working properly
because i'm communicating with a PM710, the problem i have is i'm not able
communicate with a Sepam 40 using the same FB. Both devices are from
Schneider and suppose touse the same protocol but something is wronw
with it (sepam 40) and i need to know if any one could solve this problem.
Member
Thank for your tip, i will used the tester you suggested to me.
Joined: 2/23/2011
Last visit: 10/3/2016
Posts: 1
Rating:
(0)
Regular Member
Joined: 3/24/2009
Last visit: 4/5/2018
Posts: 5
Rating:
Last edited by: Min_Moderator at: 12/7/2015 3:16:23 PM
(0) Contact data deleted
4 Entries
© Siemens AG 2018 - Corporate Information | Privacy Policy | Cookie policy | Terms Of Use | Digital ID | Forum Terms