You are on page 1of 2

1 AS/NZS 4456.

10:2003
(Incorporating Amendment Nos 1 and 2)

TM
Australian/New Zealand Standard
AS/NZS 4456.10:2003

Masonry units, segmental pavers and flags—


Methods of test
Method 10: Determining resistance to salt attack

This Standard incorporates Amendment No. 1 (August 2004) and Amendment No. 2
(September 2009). The changes required by the Amendment are indicated in the text by a
marginal bar and amendment number against the clause, note, table, figure or part thereof
affected.

1 SCOPE
This is a free 1 page sample. Access the full version online.

This Standard sets out methods for testing masonry units, segmental pavers and flags, to
determine their resistance to salt attack.
A1

2 PRINCIPLE
Specimens cut from masonry or segmental pavers are subjected to cycles of soaking in salt
solution, oven-drying and cooling. When particle losses occur, the total mass of the
particles lost from each specimen is determined by weighing. Alternative methods are
presented for stone, and for materials other than stone.
When the resistance of the sample against the action of sodium chloride is to be determined,
the sodium sulphate solution used in the test method may be substituted with a 14%
solution of sodium chloride.
NOTE: A sodium chloride test can be used when the users of this method find, after comparative
testing in solutions of both sodium chloride and sodium sulphate, that the product tested fails
more quickly in 14% sodium chloride solution. Satisfactory performance in a 14% sodium
chloride solution does not guarantee satisfactory performance in a 6.2% sodium sulphate solution.

3 REFERENCED DOCUMENTS
The following documents are referred to in this Standard:
AS
1289 Methods of testing soils for engineering purposes
1289.0 Part 0: General requirements and list of methods
3700 Masonry structures
AS/NZS
A2 4455 Masonry units, pavers, flags and segmental retaining wall units
4456 Masonry units, segmental pavers and flags—Methods of test
4456.0 Part 0: General introduction and list of methods
4456.1 Method 1: Sampling for testing
4456.14 Method 14: Determining water absorption properties

COPYRIGHT
This is a free preview. Purchase the entire publication at the link below:

AS/NZS 4456.10:2003 Masonry units and


segmental pavers and flags - Methods of test -
Determining resistance to salt attack
This is a free 1 page sample. Access the full version online.

Looking for additional Standards? Visit SAI Global Infostore


Subscribe to our Free Newsletters about Australian Standards® in Legislation; ISO, IEC, BSI and more
Do you need to Manage Standards Collections Online?
Learn about LexConnect, All Jurisdictions, Standards referenced in Australian legislation
Do you want to know when a Standard has changed?
Want to become an SAI Global Standards Sales Affiliate?

Learn about other SAI Global Services:

LOGICOM Military Parts and Supplier Database


Metals Infobase Database of Metal Grades, Standards and Manufacturers
Materials Infobase Database of Materials, Standards and Suppliers
Database of European Law, CELEX and Court Decisions

Need to speak with a Customer Service Representative - Contact Us

You might also like