Professional Documents
Culture Documents
Nut
TANK THREADED
WALL TANK WALL
H1 I L L1
RUBBER
WASHER
Buna-N
LLG-3, LLG-5
HOLLOW BOLT
TRANSPARENT
MOUNTING POLYMIDE RESIN 10
BOLT
.39 MOUNTING
H2 BOLT
STEEL GUARD MAX
ASSEMBLING INSTRUCTIONS
Nut
Method A: Tank has to have two drilled and tapped holes in either M10,
NUTM12 or 1/2-13 UNC and
TANK THREADED H1 I into the threaded holes
WALL TANK WALL can be fastened from outside
L
RUBBER
WASHER Method B: Two holes must be drilled (10.2 mm on M10, 12.2 mm on M12, 12.6 mm on 1/2-13
LLG-10
UNC) and the level gauge fastened with two hex nuts from the inside of the tank Toler-
Buna-N
ance on center-to-center distance: 0.3 mm, tolerance on the drilled holes 0.2 mm
RUBBER
HOLLOW BOLT WASHER
Max tightening torque suggested 4 Ft-Lbs / 5 Nm
Dimensional Detail H2
MOUNTING
BOLT
MOUNTING MOUNTING WALL BOLT
MODEL I H1 H2 L L1 HOLE BOLT CENTER THICKNESS TORQUE
LLG-3, T-LLG-3 H1IN 3" 4.2" NUT
1.2" 1.5" 1.3" .50–.53 1/2-13x1.75" 2.98–3.01 0.4 4 FT-LBS
THREADED I
TANK WALL MM 76 L 107 30 39 34 10.2–10.5 M10-1.5x1.65" 75.7–76.3 10 5 NM
LLG-10 1/2-13x1.75"
M12-1.75x1.65"
LLG-5, T-LLG-5 IN 5" 6.1" 1.2" 3.1" 3.3" .50–.53 1/2-13x1.75" 4.98–5.01 0.4 4 FT-LBS
RUBBER
MM 127 155 30
WASHER 80 86 12.6–12.9 M12-1.75x1.65" 126.7–127.3 10 5 NM
Ordering Code
MOUNTING
2 BOLT
GYR-LLG-5
T — LLG — 5 — *
NUT
L
THERMOMETER SERIES SIZE OPTIONS
OMIT LEVEL LLG 3 OMIT NO OPTIONS
T RED THERM 5 M10 M10 BOLT
BT BLUE THERM
RUBBER
WASHER
M12 M12 BOLT
V VITON SEALS
PE ETHYLENE-PROPYLENE
LB 1/2-13 x 2" BOLT
RB REFLECTING BALL 3.5
AR ALCOHOL RESISTANT
M10SS SS BOLT, NUT
M12SS SS BOLT, NUT
See website technical bulletin TB.TA06.708, TB.TA09.708, NG NO GUARD
TB.TA12.708 and TB.TA15.708 and for further information at PLG 5" PLASTIC GUARD
(Technical Data - www.lenzinc.com). LLG-5-RB-NG