Professional Documents
Culture Documents
908
October 25, 2002
Dear Sirs,
We are pleased to announce the upgrade of the ProSound SSD-5000. As for the
detailed descriptions on the enhancements, please refer to the attached papers.
3. Brochure
Please use the current brochure.
4. Specifications
Please refer to the attached file.
Revised specifications pamphlet will be available around the end of October.
Document number of the revised pamphlet is SP-5000-V4.1-1.0
Y. Eihara
Director & General Manager
International Sales and Marketing Dept.
YE/Ss
Encl. Specifications of SSD-5000 Ver. 4.1
Enhancements on SSD-5000 Ver. 4.1
2.1 UST-987-7.5 (SHD convex sector probe for neurosurgery/neonatal head probes)
and UST-995-7.5 (finger-grip intraoperative probe)
Less banding* is produced at 4-point dynamic focusing in the default setting of
small part application.
* Banding: a phenomenon in which boundaries of focal areas are evidently seen
when the probe is touching nothing. However, the banding is almost not seen
when the probe is applied to the body.
1
3. Functional improvements
3.1 Steering method of Color Flow area and PW Doppler cursor with steered linear
probes
When the Flow area and the PW Doppler cursor are displayed at the same time,
the movement of the cursor can be switched between the following two methods.
(Preset function is used for the selection.)
Version Movement
Ver. 4.1 Selectable between independent and linked
Ver. 4.0.1 Linked
Ver. 4.0 (Ver. 4.0.0) Independent
Lower than Ver. 4.0 Linked
PW Doppler cursor
= =
2
3.2 Rearranging the TV synchronization method
Conventionally the status of TV synchronization was linked with the setting of
“Store Media” preset as follows:
The above has been changed so that the TV sync setting can be selected from
among Frame, Field, and off independent of Store Media setting. The setting is
exactly the same as the status.
Frame: an area on the screen that forms one complete picture and consists of a
set of scanning lines
Field: half of scanning lines
3
a. Displaying the grid on the convex sector image.
b. Switching the image to linear scanning image.
c. Switching the image to convex sector scanning image again. Then the grid
disappears.
4. Volume Mode
It is possible to switch between the following two methods with the preset.
a. Intermittent refresh display (Set the menu to “Fix”.)
Inside the 3D probe, an array of transducers is moved mechanically to scan the
body.
In this display, the Volume Mode image is renewed each time the transducer array
comes at an end. During the scanning, the Volume Mode image is still and remains
unchanged.
Intermittent refresh
Sweep refresh
b. Real-time refresh display (Set the menu to “Moving”.)
4
In this display, the Volume Mode image is gradually renewed with the movement of
the transducer array.