Professional Documents
Culture Documents
www.atmospolres.com
Theeffectofambientozoneandhumidityontheperformanceof
nylonandTeflonfiltersusedinambientairmonitoringfilterǦpack
systems
PamelaE.Padgett
USDAForestService,RiversideFireLab.4955CanyonCrestDriveRiverside,CA92507USA
ABSTRACT
NylonandTeflonfiltermediaarefrequentlyusedformonitoringambientairpollutants.Thesemediaaresubjectto Keywords:
many environmental factors that may influence adsorption and retention of particulate and gaseous nitrogenous Nitricacid
pollutants.ThisstudyevaluatedtheeffectsofozoneandhumidityontheefficacyofnylonandTeflonfiltersusedin Drydeposition
theUSdrydepositionmonitoringnetwork.Ozonewasshownto reduceretentionofnitricacidonnylonfiltersand Ozone
highhumiditywasshowntodramaticallyincreaseretentiononnitrateonTeflonfilters. Filterpack
Ammonia
ArticleHistory:
Received:02October2009
Revised:25November2009
Accepted:18December2009
CorrespondingAuthor:
PamelaE.Padgett
Tel:9516801584
Fax:9516801501
EͲmail:ppadgett@fs.fed.us
©Author(s)2010.ThisworkisdistributedundertheCreativeCommonsAttribution3.0License. doi:10.5094/APR.2010.004
1.Introduction atflowratesof1.5LminͲ1intheeast,and3.0LminͲ1inthewest.
Filterpacksareexchangedweekly,exposedfiltersareextractedin
The Clean Air Status and Trends Network (CASTNET, 2009) is aqueous solutions, and the resulting solutions analyzed for
theUSEnvironmentalProtectionAgency’sprogramformonitoring constituents of interest. This data is then used to calculate dry
drydepositionofnitrogenandsulfurcontainingairpollutants.The depositionratesbyinferentialmethods(Clarkeetal.,1997,Meyers
networkhasestablishedabout90monitoringlocationsacrossthe etal.,1998).Thedataismadeavailabletothepublicthroughthe
continental US with the objective of collecting data on regional website,http://www.epa.gov/castnet(CASTNET,2009).
trends in air quality, which impacts regional trends in dry
deposition. When paired with the wet deposition network–the TheefficacyandrepresentativenessoftheFPin atmospheric
independent National Atmospheric Deposition Program (NADP, monitoring is a longͲstanding debate (Harrison and Kitto, 1990;
2009)–the data generated is designed to give researchers and Sicklesetal.,1999).Inpart,thedebatecentersaroundtheability
regulators a picture of deposition loads to managed and of the filter materials to behave uniformly across environmental
unmanagedecosystems. conditions that range from the Pacific Northwest to the Gulf of
Mexico, and the deserts of the southwest to the north Atlantic
TheheartoftheCASTNETmonitoringmethodisthefilterpack coast.
(FP).TheFPisaseriesofthreecommerciallyavailablefilters:The
inletconfigurationandsamplingheadexcludeparticleslargerthan The physicoͲchemistry of surfaces such as filter media is
2.5 μm. The FP itself is a series of three commercially available influencedbytemperature,humidity,andthespecificcombination
filters.Particlessmallerthan2.5μmarecapturedonaTeflonfilter. ofatmosphericcontaminants(HarrisonandKitto,1990;Tsaietal.,
Behind that is a phosphoric acid coated glass filter that traps 2004). Dry deposition–the ecological attribute the FPs are
ammonia(NH3),followedbya“Nylasorb”filter(aproprietarynylon designedtoestimate–ishighlyinfluencedbywindcharacteristics
product)thattrapsnitricacid(HNO3)andsulfurdioxide.Thereare and vegetation (Clarke et al., 1997; Brook et al., 1997).
no denuders or devices for trapping pollutant gases prior to Measurements or estimates of dry deposition continue to be an
exposure to the Teflon filters. Thus NH3/NH4+ and HNO3/NO3Ͳ elusiveandlimitingfactorinunderstandingairpollutioneffectson
captured by the glass and nylon filters may be from decomposed natural ecosystems (Fenn et al., 2003). Understanding the biases
particulates trapped by the Teflon filter or ambient gaseous associated with the FP systems is critical to the usefulness of the
pollutants that pass through the Teflon filter. When deployed in CASTNET network in assessing ecological responses to dry
the field, the FP is mounted on towers 10m above the ground. deposition.
Pollutantsarecollectedbythefiltersbycontinuousflowpumpsset
24 Padgett–AtmosphericPollutionResearch1(2010)23Ͳ29
Several research groups have conducted valuable theoretical linked together and attached to a single continuous flow pump
(Kolb et al., 1997; Stelson and Seinfeld, 2007) and experimental (SierraInstrumentsInc,Monterey,CA)(Figure1).Airflowateach
Ͳ1
studies (Harrison and Kitto, 1990; Tsai et al., 2004; Keck and FP was adjusted independently to 1.5Lmin , the CASTNET
Wittmaack, 2005) directed at quantifying the environmental standard for the east coast. Although the experiments were
influences and biases of these filters. In particular, Sickles and conducted in the west where the standard practice is 3LminͲ1,
colleagues(1999,2002,and2008)havepublishedseveraldetailed ambient air pollution in Riverside, CA is very high (Padgett et al.,
evaluationshighlightingpotentialchemicalinteractionsandlosses. 1999)and3LminͲ1wasnotrepresentativeoftypicalfilterloading
InacomparisonofannulardenudersystemstoFPnylonfilters,the forthenetwork.Preliminarystudieshaveshownthatexposuresat
FP system appeared to be biased high relative to the denuder these conditions were well below the saturation levels for the
systems, particularly in the presence of elevated photochemical filters and denuders. During the experiments air flow at each FP
reactivity(Sicklesetal.,1999).WhencomparedtotheInteragency was monitored daily and adjusted as needed to maintain a
Monitoring of Protected Visual Environments (IMPROVE, 2009) constant flow (although adjustments were rarely needed). All
sampling method, the FP NO3Ͳ concentrations from the Teflon experimentsincludedapaneloffivereplicatesforeachtreatment,
filters were biased low. Because the protocol for IMPROVE apanelsetͲupbutnotdeployedtoserveasafieldblank,andaset
specifies a single 24Ͳhour collection period per FP rather than a offiltersextracteddirectlyfromthebox.
week long exposure used by CASTNET, the interpretation of the
difference was that the weekͲlong continual exposure at high
temperatures and low ambient concentrations resulted in
increased losses due to volatilization from the CASTNET Teflon
filter(SicklesandShadwick,2008).Bothofthesestudiesmadeuse
of ambient air pollution conditions rather than controlled
fumigationexposuresforpollutanttreatments.
The objectives of the work presented here were to evaluate
two environmental factors that have not, yet, been addressed
experimentally: (1) The interaction of ozone (O3) with adsorption
andretentionofNO3ͲandHNO3.(2)Theeffectofrelativehumidity,
specifically the rapid change in humidity associated with dewfall,
onparticulatesorptionandretentionbyTeflonandnylonfilters.
Ozone is usually a coͲcontaminant when atmospheric HNO3
levels are high as both are produced by the same photochemical
processes (Seinfeld and Pandis, 1998). One key difference is,
however,O3continuestoparticipateintheatmosphericreactions,
while HNO3 does not. Once formed, HNO3 is, however, very
reactive with aqueous and solid surfaces resulting in very high
depositionvelocitiesandashortatmosphericlifespanofaweekor
less (Sanhueza, 1982). Becauseof ozone’s reactivity, the question
arises whether the presence of O3 causes secondary reactions by
NO3Ͳcontainingpollutantstrappedbyfilters.
ThepreferentialpartitioningofHNO3intowaterdropletshas
beenwellestablishedandcontinuestobeoneoftheconfounding
factors in calculating dry deposition from atmospheric concenͲ
trations (Kolb et al., 1997; Stelson, and Seinfeld, 2007). In many
regions of the US, particularly in the west, sunset is accompanied
by a rapid drop in temperature, which triggers a rapid rise in RH
and dewfall. This phenomenon may have significant consequence
forthebehaviorofbothNO3ͲcontainingparticlesandHNO3vapor.
Controlled experiments using open top chambers (OTC) and
continuously stirred tank reactors (CSTR) were established to Figure1.Filterpackpanelsusedfortestingenvironmentaleffectsonfilter
evaluate these two environmental factors on sorption and adsorption and retention. Each panel consisted of five Teflon filter packs
retentionsofNO3ͲbyTeflonfiltersandHNO3bynylonfilters. provided by US EPA each individually connected to a flow meter for
independentadjustment.
2.MaterialsandMethods
Attheendoftheexposures,filterswereremovedfromtheFP,
All experiments were conducted using the same batch of transferred into vials for extraction, and sent to the Canadian Air
Nylasorb filters (Nylon [1 micron] Pall Nylasorb #66509 Lot and Precipitation Monitoring Network (CAPMoN) Laboratory in
#427601) and Teflon filters (Millipore LSWP04700 Lot Toronto,Ontarioforanalysis.Preliminarystudieswereconducted
#H9BM51884). Each batch was tested (and passed) for residual tocomparetheresultsofduplicateandsplitsamplesbetweenthe
contaminationandpressuredroppriortouse. CAPMoN Lab and the contract Lab (MACTEC Engineering and
Consulting, Newberry Fl) used by the CASTNET operation. Results
Filters were loaded in Teflon US EPA CASTNETͲsupplied FP. for NO3Ͳ and NH4+ were within 5% of each other. All data shown
The FPs were used without the stainless steel outer casing. All herewereproducedbytheCAPMoNlaboratory.
components were washed in soapͲwater, rinsed in distilled
deionizedwaterandairdriedbetweenuses.Handlingoffiltersand 2.1.Honeycombdenudersassecondarymethods
FPwasconductedusingcleanforcepsandnitrilegloves.
Honeycomb denuders (Slanina et al., 1992; Koutrakis et al.,
Plexiglas panels were constructed to hold 5 FP, each FP was 1993)wereusedassecondarymonitoringsystemsforboththeO3
connected to a high accuracy flowmeter, FMͲ1050 series and humidity experiments. Denuders were placed in each of the
(Matheson TriͲGas, Montgomeryville, PA). The flowmeters were chambers(opentopandcontinuouslystirred)withoutduplication.
Padgett–AtmosphericPollutionResearch1(2010)23Ͳ29 25
Airflowforeachdenuderwassetat10LminͲ1usingconstantflow campus.Thefumigationsystemconsistsof10clearTefloncovered
pumps (Sierra Instruments Inc., Monterey CA). Denuders were chambers1mindiameterand1.5mtall.AHNO3generatorinan
exchangedevery24hoursandtheexactnumbersofminuteswere attached headhouse synthesizes HNO3 vapor that is delivered to
recorded.Denudersandfilterswereextractedbystandardmethod each chamber in controlled concentrations. Each chamber is
(Koutrakis et al., 1993) and analyzed by ion chromatography inͲ monitored independently using a standard NO monitor. To avoid
houseattheRiversideFirelaboratory. losses of HNO3 between the chambers and the monitor, a
molybdenumconverterisinstalledateachchamberwhichreduces
2.2. Experiment 1: Ozone effects on nitrate/nitric acid sorption HNO3toNOfortransporttothemonitoringsystem.Thedetailsof
andretention thesystemcanbefoundinPadgettetal.(2004).Ammoniagasand
ammonium particulates are a contaminating byͲproduct of the
TheexperimentalsystemfortheO3experimentswasopentop greenhouseactivities.
chambers(MusselmanandHale,1997).TheOTCfacility isonsite
attheRiversideFireLaboratoryinSouthernCaliforniaandconsists Humidity in the CSTR chambers was amended by installation
of 8 plastic covered coneͲtop chambers. Monitoring instrumenͲ of a mist valve in the bulk air supply. Water to the mister was
tation includes a Campbell meteorology station, a Daisibi ozone supplied from a deionized water source. The water supply was
monitor, a Monitor Labs nitrogen oxide monitor, and portable control by a timerͲrelay setͲup that opened the valve at about
particulate monitors (DataRam 4, MEI, Thermo instruments). PorͲ sunsettomimicdewfallasairtemperaturesrapidlydropatsunset.
tabletemperature/relativehumiditysensors(Onset,PoccasetMA)
were deployed in each of the chambers to evaluate differences ThediurnalpatternofHNO3inthechamberswasdesignedto
between chamber and outside conditions. Ozone and nitrogen reproduce the ambient conditions in the lower elevations of
oxides were measured and recorded electronically in each Southern California: no HNO3 after dark, an increase in concenͲ
chamber,inadditiontodeploymentofhoneycombdenuders. trations with sunrise and automobile traffic reaching a peak
concentration midͲafternoon and subsequently declining until the
Each chamber is equipped with 6inch (15cm) activated HNO3 delivery system was shut off prior to sunset. In these
charcoalfiltersandaseriesofparticulatefilters.Activatedcharcoal experiments “dewfall” was timed to occur when atmospheric
is effective in removing O3 chemically and most ambient concentrations of HNO3 were at a minimum (see Figure 5 in
particulates and aerosols physically, but not generally effective in Section3).
removingnitrogenoxides.Thegroundsurfaceinsidethechambers
is covered with coarse gravel, which reduces, but does not The experiment ran for 4 days. Nitric acid was monitored
eliminate,localdust. continuously using a Thermo Nitrogen Oxide monitor. Ammonia,
HNO3 and particulate NH4+ and NOͲ was monitored using
Ozone is generated by a Griffen O3 synthesizer (Griffin honeycomb denuders. The protocol for the denuders was 24h
Technics Corp. Lodi, NJ, USA). Synthesized O3 was added back to sampling period at 10LminͲ1 flow rate. Calculations reflect the
the filtered air stream at controlled concentrations that reflected average ambient air concentrations over the 4 day exposure
typicaldiurnalpatterns.Thelevelsweresetfor0,75and150ppb period. Because the experiments were conducted using the
peak afternoon concentrations, which is at the higher end of the standard operating procedures specific to each monitoring
pollutionspectrum,butnotunrealisticinSouthernCalifornia.The method,directcomparisonsbetweentheFPandthedenudersare
experimentwasconductedfor7days. not possible. Consistency analysis suggested that particulate
capture was similar between the two systems, but that gases
2.3. Experiment 2: The effects of humidity on uptake and captured by the glass denuders were far greater than gasses
retentionofnitricacidonTeflonandnylonfilters capturedbythenylonofglassfiltersoftheFPandthattherewas
nostatisticalrelationshipbetweenthetwosystemsforthegasses.
There were two components to these experiments. The first
wastoevaluateretentionofatmosphericmoisturebynylonfilters 2.4.Dataanalysis
andthesecondwastoquantifytheeffectofatmosphericmoisture
onretentionofnitrate/nitricacidbyTeflonandnylonfilters. Each panel of 5 FP was analyzed as a single treatment of 5
replicates. Treatment effects were evaluated using oneͲway
For the water retention experiment forty nylon filters were ANOVA using SigmaͲStat V2.0 (Jandel Scientific Software San
weighed using a microbalance. Fifteen were placed in desiccators Rafael, CA). Chamber effects and the appropriate (or misapͲ
with desiccant for a 0% RH. Fifteen were placed in desiccators propriate) use of “replicate” chambers has been described by
containing distilled water for a 100% RH. Ten were set aside as several authors (Potvin, 1993; Peterson and Mickler, 1994). The
controls. The thirty treated filters were allowed to equilibrate for conclusion of these studies is that each chamber must be
five days in the 0% and 100% pretreatments. Filters were evaluatedasauniquetreatment.Truereplicationamongdifferent
reweighed following the pretreatment before being divided into chambersisnotreallypossible.
five groups of three. Each group of three (three from the dry
treatmentandthreefromthewettreatment)wereplacedintoone Dataispresentedasaccumulationandextractionofanalytes
of five desiccators containing solutions with equilibrium water onaperfilterbasiswithoutfurthermodelingaswouldbeusedfor
contentof31%(saturatedCaCl.6H2O,280gin100mL),51%(satuͲ presentationbyCASTNET.
rated Ca(NO)3.4H2O, 266g in 100mL), 81% (saturated (NH4)2SO4
71g in 100mL), and back into the 0% and 100% RH treatments. 3.ResultsandDiscussion
The filters were allowed to equilibrate a second time at the new
RH treatments for three days before being weighed for a third 3.1.Experiment1:Ozoneeffectsonnitrate/nitricacidadsorption
time. The water content lost or gained was calculated from the andretention
difference between the weights following treatment in 100% and
0%RHandtheweightsfollowingthe0%,31%51%,81%and100% Chamber concentrations of O3, NO, and NOX are shown in
RHtreatments. Figure 2. There were no significant differences in NO and NOX
concentrations among the three chambers. Ozone concentrations
The HNO3 exposure experiments were conducted in CSTRs were significantly different, however, as planned. The no ozoneͲ
modifiedforHNO3fumigationsfromtheoriginaldesignbyHeagle added treatments (designated “low” rather than “0”, chamber 1)
and Pillbeck (1979). The CSTRs are housed in a temperature hadlow,roughlyglobalbackgroundconcentrationsof30ppbpeak
controlled greenhouse on the University of California, Riverside
26 Padgett–AtmosphericPollutionResearch1(2010)23Ͳ29
Ͳ
daytime levels.The O3 added chambers were targeted for 75ppb (p<0.05) lower quantities of NO3 measured in the extraction
Ͳ
(medium,chamber2)and150ppb(high,chamber3). solutions and presumably trapped by the filters. The NO3
extracted from the Teflon filters, on the otherhand, indicated no
difference among chambers, although total NO3Ͳ containing
particulate loads on the Teflon filters were much smaller than on
thenylonfilters.
90
Honeycomb
80 Low Ozone/1
Teflon filter
Med Ozone/2
70
High Ozone/3
60
40
30
20
10
0
NH4+ Na+ Ca++ NO3-
(a)
120
Honeycomb NO3- Honeycomb nylon filter
glass denuders 25
100 20
15
10
80
Dose (ppm x hr)
5
0
NO3-
60
40
20
0
HNO3 NH3 SO2
(b)
Figure 3. Total particulate and vapor dose during open top chamber
experimentsasdeterminedbyhoneycombdenuder.Upperpanelshowsthe
dominantionsextractedfromtheTeflonfilter.Lowerpanelshowsthegases
extracted from the anion honeycomb denuder (HNO3 and SO2) and the
cationdenuder(NH3).
Figure2.Ozone,NO,andNOXconcentrationsduringfilterpackexposurein
OpenTopChambers.Datawascollectedfromcontinuousmonitorsusinga
DasibiOzonemonitorandaMonitorLabsNitrogenOxidemonitor.Ambient 140
airwasscrubbedbyactivatedcharcoaltoremoveO3beforebeingpumped
intothechambers.Ozonewassynthesizedby aGriffenO3synthesizerand 120 low Ozone/1
addedbackattheconcentrationsshown.Nitrogenoxidesarenotremoved
bycharcoalsowereprovidedbyambientatmosphericconcentrations. 100 med Ozone/2
Pg NO3- per filter
Thehoneycombdenuders/filterpackswereusedassecondary High Ozone/3
+ Ͳ + +2
80
monitorstoevaluateparticulateNH4 ,NO3 ,Na andCa ,andNH3
and HNO3 vapor concentrations in each of the OTCs (Figure 3). 60
+ + +2
ParticulateNH4 andNa werehigherinthelowchamber,butCa
Ͳ
and NO3 Ͳcontaining particles were similar among the three 40
treatmentchambers.GaseousHNO3,NH3,andSO2asdetermined
by the glass honeycomb denuders, were also similar across 20
chambers. Nitrate extracted from the nylon filters (designed to
capture HNO3Ͳ evolving from degradation of particles) was also 0
similaramongthethreechambers(insetFigure3b).
Nylon Teflon
The most significant result was the strong effect O3 had on
Ͳ
NO3 extracted from the nylon filters in the CASTNET FP system
(Figure 4). The higher O3 treatments resulted in significantly Figure 4. FilterͲpack nitrate concentrations from the ozone treatment
chambers.Errorbarsare1SE.
Padgett–AtmosphericPollutionResearch1(2010)23Ͳ29 27
Interference and secondary reactions of particles by “high”, one with added humidity, and one without; and two
continuousexposureof1weekhasbeenalongstandingconcern chambers were established as “medium” also with, and without,
for the CASTNET system. In a detailed study of FP and annular humidity. Ultimately, the integrated HNO3 levels were similar
denuder systems Sickles et al. (1999) proposed that oxidation of enoughthattheywerecombinedintotwochamberswithhumidity
ambientHNO2maycauseHNO3extractedfromnylonfilterstobe and two chambers without humidity. The data from control
biased high, in comparison to annular denuder systems. During chamber is not shown. The RH patterns in the nonͲhumidified
that 14 week study, the first 2 weeks featured very high O3, SO2, chambers were typical of semiͲarid environments, between 20%
Ͳ2 +
SO4 and H concentrations. The speculation was that the high and 30% during the day and increasing as temperatures cooled
oxidant levels caused increased HNO3 by oxidation of HNO2. The after sunset (Figure 5). The dewfall chambers were designed to
data indicated that the bias was not thought to be caused by exaggerate that pattern with a rapid and increase in relative
volatilizationofparticulateNO3Ͳ. moisturecontenttonearly100%followedbyquasiͲequilibriumof
70% to 80%. Sunrise and warming of the greenhouse caused a
The results of these controlled O3 exposures where all other rapiddeclineinRH.TherelationshipbetweenHNO3presenceand
factorswereconsistentacrosstreatmentsindicatethatelevatedO3 RHisalsoshowninFigure5.Nitricacidconcentrationswereatthe
depressed the accumulation of NO3Ͳ on the nylon filters. But, like detection limit (assumed to be 0) when dewfall was initiated and
Sickles et al. (1999) had little effect on particles trapped by the RHwasbacktobackgroundlevelsbeforeHNO3wasreͲintroduced
Teflon filter. The honeycomb denuders showed no differences in tothechambers.
HNO3/NO3Ͳ atmospheric concentrations among the chamber
suggesting that the events causing depression of NO3Ͳ extracted 250
unclearwhethertheeffectisduetoareductioninadsorptionfrom 150
the air stream or recovery during extraction. However, since it is 125
thought that nylon, a polyamine, binds NO3Ͳ/HNO3 on free amine
groups, and O3 is known to attack nonͲprotonated amines, it is 100
reasonable to hypothesize that the presence of O3 reduces the 75
ability of the Nylasorb filter to adsorb HNO3 vapor by eliminating 50
bindingsites.
25
3.2. Experiment 2: The effects of humidity on uptake and 0
retentionofnitricacidonTeflonandnylonfilters 10 AM - 4 PM 10 AM - 4 PM 10 AM - 4 PM 10 AM - 4 PM
RH (%) Humid Cham 2 RH (%) Humid Cham 3
Water gain/loss. The nylon filters absorbed and desorbed RH (%) Dry Cham 7 RH (%) Dry cham 8
HNO3 High Humid HNO3 Med Humid
water vapor in response to changes in relative humidity, HNO3 Med Dry HNO3 High Dry
particularly at higher relative humidity (Table 1). The filters that
were initially equilibrated at 0% RH and then transferred to the Figure 5. Relative humidity and nitric acid concentrations in the
100% RH treatment gained 5.6mg of water over the 3day continuouslystirredtankreactorsduringexposureofthefilterpacks.
exposure period. The moisture gained by the filters transferred
into the 31% and 51% RH treatments were not significantly Denuder measurement of NH3 and HNO3 vapor indicated no
different from one another, but were significantly lower than the significant differences in HNO3/NO3Ͳ between the humid and dry
81% RH treatment, which in turn was significantly lower that the +
chambers(Figure6).AmmoniaandparticulateNH4 concentrations
100% RH treatment. The relationship between treatment RH (%) were highly variable in both the humid and dry chambers as
and water gained was not linear suggesting that the nylon filters indicated by the large SE bars. There was a trend for higher
haveathresholdofhydrophilicity. ammoniavaporinthedrychamber,andagreateramountofNH3Ͳ
NrelativetoHNO3,butneithertrendwerestatisticallysignificant.
Table 1. Water gained and lost by nylon filters after equilibration in 5 Particulate NH4+ was, however, significantly higher in the dry
differentrelativehumiditylevels chamber (p<0.1) and both humid and dry chambers had
+
significantly greater NH4 containing particulates than NO3
Ͳ
Secondary particulates. The reasons for this behavior of reduced N are not
0%InitialTreatment 100%Initialtreatment
Treatment clear,butmayhavesomethingtodowithothercomponentsinthe
RH(%) Watergained SE Waterlost SE dryfractionsthatwerenotcapturedinthisanalysis.
0 Ͳ0.304 0.090 2.936 0.933
31 0.249 0.363 3.337 1.721 The average 24 h HNO3 concentrations in the humid and dry
51 0.185 0.117 3.828 0.888 chambers,asmeasuredbythedenuders,weresimilarat20to24
81 1.499 0.282 3.720 1.066 μgͲNmͲ3overthe4dayexperiment.ParticlescontainingNO3Ͳwere
100 5.578 0.683 Ͳ2.693 1.089 much lower than the ammoniaͲcontaining particles at a 24h
Ͳ3
averageofabout0.5μgͲNm .
Thepatternofwaterlossfromnylonfilterswasquitedifferent
than the pattern shown for water gain. After 5days in the initial The CASTNET FP data indicates that the NH4+ patterns were
100% RH treatment, filters maintained at 100% RH continued to similar to those measured by the denuder systems, with
gain water (Ͳ2.7 is a “negative”, loss in this context). The filters significantly higher NH4+ containing particulates in the dry
transferredintothelowerRHtreatmentslostmoistureatthesame chambers.But,withoutthedenuderstostripgaseousHNO3,theFP
rate,regardlessofthetreatmentRH.Theadsorptionandretention resultswerequitedifferent(Figure7).Themostimportantfinding
ofwaterbythenylonfilterswouldbeexpectedtostronglyaffect wasthatNO3ͲcapturedbytheTeflonfilterwasmuchhigherinthe
Ͳ
theadsorptionandretentionofHNO3. humid chamber at over 300 μgͲN filterͲ1 compared to the NO3
extractedfromTeflonfiltersinthedrychambers(Figure7,inset).
CSTR humidity experiment. Nitric acid concentrations in the
treatment chambers (as measured by a realͲtime nitrogen oxide
monitor)areshowninFigure5.Twochamberswereestablishedas
28 Padgett–AtmosphericPollutionResearch1(2010)23Ͳ29
45
of apparent particulateͲN on the Teflon filters. Although this
40
cannot be totally ruled out, the experiment was repeated twice
35
and the timing of HNO3 synthesis and moisture addition was
30 carefullymonitoredtoavoidoverlap.
25
20 The data from the honeycomb denuders shows that once
15 gaseousHNO3wasremovedfromthesamplingstream,herewere
10 notsignificantdifferencesinatmosphericparticles.
5
0 4.SummaryandConclusions
Humid Dry Humid Dry
Theozonestudyseriouslydrawsintoquestiontheusefulness
NH3 HNO3 ofnylonfiltersunderhighHNO3andO3conditions.Itisimportant
to note that most of the CASTNET sites are in rural or remote
locations and this study was clearly at the upper end of typical
Average particulate nitrogen (Pg-N m )
4.5
-3
90 400
Teflon NO3-
80 300 HNO3 humid Acknowledgements
HNO3 dry
70 200
Control humid
60 100
Control dry ThisprojectwassupportedbyagrantfromtheUSEPA,Clean
50 0 AirMarketsDivision.Iamgratefulforoperationalassistancefrom
40 Elias Scott and Tongzou Wang, and for technical assistance from
30 Dr. David Parker, University of California and Dr. David McTavish,
20
EnvironmentCanada.
10
0
Disclaimer
Teflon NH4+ Glass filter (NH+) Nylon filter (NO3-)
Mention of trade names and products is for information only
and does not imply endorsement by either the US Department of
Figure7.Ammoniaandnitricacidconcentrationsextractedfromthefilter AgricultureortheUSEnvironmentalProtectionAgency.
packsafterfourdaysofexposuretoHNO3vaporincontinuouslystirredtank
reactors. References
The nylon filters are somewhat hygroscopic as demonstrated Brook, J.R., DiͲGiovanni, F., Cakmak, S., Meyers, T.P., 1997. Estimation of
by their accumulation and loss of water as a result of changes in dry deposition velocity using inferential models and siteͲspecific
relativehumidity.AsopposedtothehydrophobicnatureofTeflon. meteorology–uncertainty due to siting of meteorological towers.
However, the effect of RH (%) on FP performance was most AtmosphericEnvironment31,3911Ͳ3919.
notablebyNO3ͲextractedfromtheTeflonfilters.SinceTeflondoes
notadsorbwater,theresultsdonotsuggestsolubilizationofHNO3
Padgett–AtmosphericPollutionResearch1(2010)23Ͳ29 29
Bytnerowicz, A., Padgett, P., Arbaugh, M., Parker, D., Jones, D. 2001. NADP.2009.http://nadp.sws.uiuc.edu/AccessedMay25,2009.
Passive sampler for measurements of atmospheric nitric acid vapor Padgett,P.E.,Bytnerowicz,A.,Dawson,P.J.,Riechers,G.H.,Fitz,D.R.,2004.
(HNO3)concentrations.TheScientificWorldJournal1,815Ͳ822. Design, evaluation and application of a continuously stirred tank
CASTNET,2009.http://www.epa.gov/castnet/.AccessedMay25,2009. reactorsystemforuseinanitricacidairpollutantstudies.Water,Air
Clarke,J.F.,Edgerton,E.S.,Martin,B.E.1997.Drydepositioncalculationsfor andSoilPollution151,35Ͳ51.
thecleanairstatusandtrendsnetwork.AtmosphericEnvironment31, Padgett,P.E.,Allen,E.B., Bytnerowicz,A.,Minnich R.A.,1999.Changesin
3667Ͳ3678. soil inorganic nitrogen as related to atmospheric nitrogenous
Fenn, M.E., Haeuber, R., Tonnesen, G.S., Baron, J.S., GrossmanͲClarke, S., pollutants in southern California. Atmospheric Environment 33, 769Ͳ
Hope, D., Jaffe, D.A., Copeland, S., Geiser, L., Rueth, H.M., Sickman, 781.
J.O., 2003. Nitrogen emissions, deposition, and monitoring in the Peterson,C.E.,Mickler,R.A.,1994.Considerationsforevaluatingcontrolled
westernUnitedStates.BioScience53,391Ͳ403. exposure studies of tree seedlings. Journal of Environmental Quality
Harrison,R.M.,Kitto,A.M.N.,1990.Fieldintercomparisonoffilterpackand 23,257–267
denuder sampling methods for reactive gaseous and particulate Potvin, C., 1993. ANOVA experiments in controlled environments. In:
pollutants.AtmosphericEnvironment24A,2633Ͳ2640 Design and Analysis of Ecological Experiments. Scheiner, S.M.,
Heagle, A.S., Philbeck, R.B., 1979. ‘Exposure Techniques’. in: Heck, W.W., Gurevitch,Jeds.Chapman&HallPublishing,NewYork.
Krupa, S.V., Linzon, S.N., Eds, Proceedings: A Special Conference on: Sanhueza, E., 1982. The role of the atmosphere in nitrogen cycling. Plant
Methodology for the Assessment of Air Pollution Effects on andSoil67,61Ͳ71.
Vegetation.19–21Apr.1978,pp.6Ͳ1to6Ͳ19. Seinfeld,J.H,Pandis,S.N.,1998.AtmosphericChemistryandPhysics:From
IMPROVE, 2009. http://vista.cira.colostate.edu/improve/. Accessed May AirPollutiontoClimateChange,JohnWileyandSons,Inc.,NewYork.
25,2009. Sickles,J.E.II,Shadwick,D.S.,2008.Comparisonofparticulatesulfateand
Keck,L.,Wittmaack,K.,2005.Laboratorystudiesontheretentionofnitric nitrate at collocated CASTNET and IMPROVE sites in the eastern US.
acid, hydrochloric acid and ammonia on aerosol filters. Atmospheric AtmosphericEnvironment42,2062Ͳ2073.
Environment39,2157Ͳ2162. Sickles, J.E. II, Shadwick, D.S., 2002. Biases in clean air status and trends
Kolb, C.E., Jayne, J.T., Worsnop, D.R., Davidovits, P., 1997. Solubility data network filter pack results associated with sampling protocol.
requirements and new experimental methods in atmospheric aerosol AtmosphericEnvironment36,4687Ͳ4698.
research.PureandAppliedChemistry69,959Ͳ968. Sickles,J.E.II,Hodson,L.L.,Vorburger,L.M.,1999.Evaluationofthefilter
Koutrakis,P.,Sioutas,C.,Ferguson, S.T.,Wolfson,J.M.,Mulik,J.D.,Burton pack for longͲduration sampling of ambient air. Atmospheric
R.M., 1993. Development and evaluation of a glass honeycomb Environment33,2187Ͳ2202.
denuder/filterpacksystemtocollectatmosphericgasesandparticles. Slanina, J., de Wild, P.J., Wyers, G.P., 1992, The application of denuder
EnvironmentalScienceandTechnology27,2497–2501. systemstotheanalysisofatmosphericcomponent,.inJ.O.Nriagu,J.O
Meyers, T.P., Finkelstein, P., Clarke, J., Ellestad, T.G., Sims, P.F. 1998. A Ed., Gaseous Pollutants: Characterization and Cycling, John Wiley &
multilayer model for inferring dry deposition using standard Sons,Inc.,NewYork,pp.129–154.
meteorological measurements. Journal of Geophysical Research 103, Stelson, A.W., Seinfeld, J.H., 1982. Relative humidity and temperature
22645Ͳ22661. dependence of the ammonium nitrate dissociation constant.
Musselman,R.C.,Hale,B.A.,1997.Methodsforcontrolledandfieldozone AtmosphericEnvironment16,983Ͳ992.
exposuresofforesttreespeciesinNorthAmerica.In:Sandermann,H., Tsai,CͲJ,Huang,CͲH,Lu,HͲH.,2004.Adsorptioncapacityofanylonfilterof
Wellburn, A.R., Heath, R.L., Eds. Forest Decline and Ozone. Springer, filter pack system for HCl and HNO3 gases. Separation Science and
Berlin,pp277Ͳ315. Technology39,629Ͳ643.