You are on page 1of 1

4,?


Š
4;@
DIST. AUTORIZADO 896  ]LU[HZ'PUK\Z[YPHSTHNaHJVT
To avoid injury (or even death), Wiring Hook-up
always make certain all power is off before
attempting to install this control or any The CBC-802 clutch/brake control is
electrical equipment. Do not touch the board interchangeable with its predecessor, the
if power is applied. MCS-802-2, but is not directly interchangeable
Installation with other Warner Electric plug-in controls. Before
actual installation of the CBC-802 into its socket,
Mounting insure all external wiring conforms to the following
 1. Select a suitable location in the panel or hook-ups:
cabinet where the CBC-802 will be
located. Insure sufficient space is 1 6
H
available for socket & wiring and control CBC 802 90 V
Clutch
120 VAC,
when plugged into the socket. ± 10% 2
50/60 Hz 90 V
 2. Mount the socket (foot mount) to the Brake

panel or attach the DIN Rail Mount to its 5 4


N
track where it will be located. Make sure
socket is properly secured.
Power and Load Wiring
 3. Once socket is mounted and secured,
proceed to the control wiring section.
 1. Connect the hot side of the 120 VAC power
Dimensions to terminal 1 of the socket and secure
tightly.
Anti-Overlap ADJ

Clutch Brake  2. Connect the neutral side of the 120 VAC


power to terminal 5 of the socket and
1.45"
3.60" MAX
Anti-Overlap MAX secure tightly.
Potentiometer
Note: The “hot line” must be connected to
terminal 1. This line measures 120 VAC to conduit
ground. The “neutral” line (color coded white or
3.80" natural-gray) is grounded at the 120 VAC
MAX
transformer and must be connected to terminal 5.
This line measures zero VAC to conduit ground. A
chassis ground should be provided as non-current
conducting ground wire (color coded green).
.07" MAX

Std. Octal Keyed Plug


 3. Connect the two (2) wires from the clutch to
terminal 2 and terminal 6 of the socket.
Octal Socket Secure terminal 2 tightly.
P/N 6001-101-001 Purchased Separately
 4. Connect the two (2) wires from the brake to
terminal 4 and terminal 6 of the socket.
.70"
(17.8)
Securely tighten both terminals.
1.57"
(39.9)
2.39" This is a floating type power
(60.7)
supply and is not referenced to AC ground.
DIN Rail Mount Socket Under no cirmcumstances should any of the
P/N 6001-101-002 Purchased Separately
output wire leads be connected to earth or
chassis ground as the unit will be destroyed.
.71"
(18)

1.57" 2.40"
(39.9) (61)

Warner Electric • 800-825-9050 P-239-35 • 819-0409 3

You might also like