HOW TO SELECT 3) Finally, refer to the pressure-temperature
THE G-LOK® CONNECTOR rating charts, on pages 28 to 35, to ensure that the selected G-LOK ® 1) Determine the following connector meets the design information needed to correctly size pressure and temperature the G-LOK® connector: requirements for the code to which it is being specified. • Maximum Service Pressure and Temperature (Your Design Conditions) The standard line of G- • The engineering or industry LOK ® connectors and code your project has products are available in specified. (ASME VIII, B31.3, materials and sizes to fit etc.) nearly any requirement. But if your requirements, • Pipe size and schedule or pipe size, material or the I.D. and O.D. of the design conditions, are weld end. not covered by one of • Your piping material. our charts, please contact Galperti 2) Refer to the tables in this Engineering. We have an catalogue: engineering and design staff ready to help you • Locate your pipe size and solve your most demanding schedule in the Butt weld hub needs. table on pages 16 to 23, then read across to the corresponding hub size (third column). As an HOW TO ORDER example, the 12” schedule 160 Pipe THE G-LOK® requires a G-LOK® Hub size 12M102. CONNECTOR Also note that this chart has weights and After following the selection procedures the dimensions for this hub and for most popular hub information necessary for ordering G-LOK® connectors sizes. is the quantity, the hub number and material, the seal • The G-LOK® number 12M102 designates the correct number and seal material, and the clamp number and clamp, bolting and seal ring sizes for this connection. clamp material. The first number refers to the pipe and clamp size, in our example the pipe size is 12” and the clamp would A G-LOK® assembly consists of the following: be the 12M. More information on the clamp can be • Two G-LOK® Hubs located in the Clamp table on page 26 to 27. • One G-LOK® Clamp Set, with four studs and eight • The final set of figures is the G-LOK® seal for this nuts (Spherical washer available on request) connection (in our example this would be a 102). The G-LOK® seal chart is located on page 24 to 25. • One G-LOK® Seal Ring