Software Update for Sharp Models LC32LE265X, LC40LE265X,
LC60LE660X and LC70LE660X
In some New Zealand regional centres you may experience an issue where not all of the Freeview channels are being received. If this occurs, please use the provided USB and follow the instructions below to update your Television software.
If you experience difficulties please contact Sharp Customer Care on 0800 501 201 or email ccare@sharp.net.nz
1. Ensure the TV Antenna is connected and the
unit is plugged into the wall socket and the wall switch is on.
Press the POWER button located on the Left
rear of the TV to turn the TV on. If this is the first time the TV has been turned on the Auto installation wizard will appear. If the TV has previously run the “Auto Installation” Please go to step 3
2. Using the left, right, up and down arrow
buttons on the remote:
Press ▼ or ▲ to highlight NEW
ZEALAND, and then press ENTER. Press ▼ or ▲ to highlight the desired language, and then press ENTER. Press ▼ or ▲ to select HOME, and then press ENTER.
Auto search will be started to Auto Tune the
TV which takes about 5 minutes to complete.
3. Check that you have the correct model
written on the USB memory stick.
Insert the supplied USB memory stick in slot
(2) at the left rear of the TV
4. Enter the menu by pressing “MENU” button
on the remote:
Please Turn Page Over
5. Press ◄or ► button on the remote control to select the “Option” menu
6. Repeatedly press the ▼ down arrow button
on the remote control, scroll all the way down to the hidden section until “SYSTEM DATA” is highlighted, and then press the “ENTER” button on the remote
7. Press “ENTER” on the remote control to
select “USB DATA TRANS”
8. Press ▲arrow up button on the remote
control to highlight “YES” then press “ENTER”
9. The update will start automatically, progress
is shown on screen.
10. The TV picture will reappear once the update
is complete.
If the picture does not appear after 3 minutes
turn the wall socket off then on and power on the TV.
11. If some channels are missing, please select
Auto Installation from the “Programme Setup” Menu (and press “Enter”) .Now that the software update has been performed, any missing channels should be located after the auto tuning scan has finished.