Professional Documents
Culture Documents
• Please read this booklet before first-time use. Keep these instructions for future reference,
as they contain important information.
• Adult assembly is required.
• Requires one 7.2V NiMH rechargeable battery pack (included) and two “AA” (LR6) alkaline
batteries (not included) for operation.
• Tool required for battery installation: coin or slotted screwdriver, and a Phillips screwdriver
(tools not included).
• Before first-time use, charge the 7.2V NiMH rechargeable battery pack for 4 hours.
Charge the 7.2V NiMH rechargeable battery only with the supplied charger. Do not use
any other charger.
• The charger is not a toy. Do not use extension cords with the charger.
• Adults Note: Periodically examine this product for damage to the cord, housing or other
parts that may result in the risk of fire, electric shock or injury. If the product is damaged,
do not use it.
• Even with proper care, the rechargeable battery will not last forever. The life of the
rechargeable battery depends on how well you follow these instructions and the total
number of hours it is used. If you should need to replace the rechargeable battery,
contact Fisher-Price®.
• Do not disassemble the sealed 7.2V NiMH rechargeable battery pack.
• Do not recharge a battery pack that shows leakage or corrosion.
• Charger specifications: Input 120 VAC, 60 Hz, 0.3 A; Output 8.4 VDC, 300 mA, 2.5 VA.
• This product is intended for indoor use only.
• This product is not recommended for use on loose dirt or wet surfaces.
• Wipe this toy with a clean cloth dampened with a mild soap and water solution. Do not use
bleach. Do not use harsh or abrasive cleaners. Do not immerse in water. Immersing this toy
can result in electric shock.
• This product has no consumer serviceable parts. Do not take this toy apart.
• Fit the socket on the arm onto the peg on the body. Push the arm to “click” into place.
Make sure you hear a “click”.
1.5V x 2
"AA" (LR6)
Remote Control
• Locate the battery compartment door on the bottom of the remote.
• Loosen the screw in the battery compartment door with a Phillips screwdriver. Remove the
battery compartment door.
• Insert two “AA” (LR6) alkaline batteries.
Hint: We recommend using alkaline batteries for longer battery life.
• Replace the battery compartment door and tighten the screw with a Phillips screwdriver.
• If the remote begins to operate erratically, you may need to reset the electronics. Slide the
power switch off and then back on.
• When the L.E.D. does not light or BigFoot does not respond to the remote, it’s time for an
adult to change the batteries.
• Protect the environment by not disposing of this product with household waste
(2002/96/EC). Check your local authority for recycling advice and facilities (Europe only).
ICES-003
• This Class B digital apparatus complies with Canadian ICES-003.
• Operation is subject to the following two conditions: (1) this device may not cause harmful
interference and (2) this device must accept any interference received, including interference
that may cause undesired operation.
NMB-003
• Cet appareil numérique de la classe B est conforme à la norme NMB-003 du Canada.
• L’utilisation de ce dispositif est autorisée seulement aux conditions suivantes: (1) il ne doit pas
produire de brouillage et (2) l’utilisateur du dispositif doit être prêt à accepter tout brouillage
radioélectrique reçu, même si ce brouillage est susceptible de compromettre le fonctionnement
du dispositif.
Fisher-Price, Inc., a subsidiary of Mattel, Inc., East Aurora, NY 14052 U.S.A.
©2010 Mattel, Inc. All Rights Reserved. ® and ™ designate U.S. trademarks of Mattel, Inc.
Charger
Connector
7.2V NiMH
Battery Connector
• Plug the 7.2V NiMH battery connector into the charger connector.
• Plug the charger into a standard wall outlet. The charger L.E.D. turns red.
Notes: If power flow to the wall outlet is controlled by a switch, make sure the switch is “ON”.
Use the charger only in a wall outlet. Do not plug the charger into a ceiling outlet. To connect to
a supply that is not in the United States, use an adapter (not included and sold separately) with
the proper configuration for the power outlet.
• Charge the battery for four hours. When charging is complete, the charger L.E.D. turns green.
• Disconnect the charger connector from the battery connector. Unplug the charger from the
wall outlet.
• Slide the power/volume switch on the bottom of BigFoot to ON with low volume , ON with
high volume or OFF .
Remote Control
Power Switch