Professional Documents
Culture Documents
If a full design is required then The concrete is first checked for The area of reinforcement required at
Egcostud can be designed into the shear at the column face against the first perimeter (1.5d) is then split by
slab using the same design principals allowable limits from the code and is placing at least 40% at 0.5d from the
as for shear links. All design methods then checked along a perimeter at column face and 60% at 1.25d from
are in accordance with BS 8110 part 1. a distance of 1.5d from the column the column face. If subsequent areas of
face. If shear reinforcement is not reinforcement are required, these are
required, then no further checks are spaced at 0.75d from the last perimeter
necessary. If shear reinforcement is of reinforcement.
required then the concrete is checked
along subsequent further perimeters Two perimeters of studs are used for
0.75d apart until no further shear the calculation of the area required.
reinforcement is necessary.
( 1.5M t
Internal 1.15Vt Vt 1+
(
Vt x
v
moments, both axes of the column c. C
alculate the Area of Steel
1.25
should be checked and the worst Required (A sv)
case Veff used Ifv ≤ 1.6v c then
( 100A
1
s
( not to be taken
Where 3
(v - v c ) u1d
(b d)
v greater than 3 A sv =
b. C
alculate Maximum Design 0.87f yv
Shear Capacity (v max ) 400 not less than 0.67
(
( 1
4
d If 1.6 v c < v ≤ 2v c then
Veff or less than 1 for
v max = 5(0.7v - v c ) u1d
u0d slabs greater than A sv =
0.87f yv
400mm deep
This should not exceed a maximum fcu ≤ 40 N/mm2 These must not be less than the
value of 0.8√ fcu or 5 N/mm , whichever
2
minimum steel of 0.4u1d
is the lower. b. C heck Design Shear Stress (v) 0.87f yv
at First Perimeter (1.5d) fyv = 500 N/mm 2
v = Veff
u1d d. C heck Subsequent Perimeters
t e c h n o l o g i e s fo r t h e c o n s t r u c t i o n i n d u s t r y 9