You are on page 1of 1

SRN I I I II !

I I I 1 I I

PES PES University, Bangalore


uNtvcit§iy (Established under Karnataka Act No. 16 of 2013) UE16EE253

May 2018: END SEMESTER ASSESSMENT (ESA) B.TECH.


IV SEMESTER
UE16EE 253- POWER ELECTRONICS
Time: 3 Hrs
Answer All Questions Max Marks: 100
1. a)
Draw two transistor analogy of SCR and then derive expression for anode current
b) 05
A thyristor is connected with R=30 and inductance L in series. Find the value of L in
order to protect thyristor from rate of change of current. Where the supply voltage is 05
di
500V &d— t
50A/p.sec
c)
Draw the turn ON characteristics of SCR and then define delay and rise time of
thyristor current 05
d)
30 converter used for HVDC Transmission from 25KV supply and each thyristor
rated 1600V/16A are available, the current difference is 35mA and string efficiency is 05
85% and also change in charge is 25pC, Calculate the number of devices to be
connected in a string and also find values of equalizing components
2. a)
With circuit and waveforms of resonant pulse commutation, derive the expression for
turn-off time. Find Toff 7+3
for the same circuit has Im=50A,Vs=200V, L=4µ11 and C=30µF
b)
With the circuit and waveform of Boost regulator, derive the expression for L & C.
Find the values i)duty ratio ii) inductor ripple current & iii) ripple voltage, if V 7+3
V0=15V, I0=0.8A, F,=25kHz, L=15001, C=220pF. S 5V,
3. a)
10 Full bridge inverter with RLC load R=100, L=31.5mH, C=112µF, F=60Hz and
Vs 10
=220V. obtain expression for instantaneous load current using Fourier series up to
9th Harmonic
b) 30 inverter circuit with 1800
conduction, circuit, equivalent circuits with Y-connected 10
R-load, obtain line & phase voltage waveform with gating signals. (use booklet graph
sheet only)
4. a) 10 Half wave controlled rectifier, V
g 230V, 50Hz, with the water heater of 1KW,
05
230V rated is connected. SCR firing angle is 45° find power absorb by the heating
element
b) With the circuit & waveforms, derive the expression for avg. value of output voltage &
RMS value voltage for 10 fully controlled rectifier with R-L load. 05
c)
10 dual converter operated from 120V, 50Hz supply, R=100, 4=40mH and the delay
angle of converterl is 60°, calculate peak circulating current of converterl 05
d)
30 Fully controlled rectifier, operated from 30, Y-connected supply voltage 208V
05
60Hz with R=100 if it is required to obtained max. value of 50% of possible output
voltage calculate i) delay angle ii) RMS voltage iii) Avg. voltage
5 a)
10 Full wave AC voltage controller working ON-OFF control, V,=230V, 50Hz, load
05
R=500, converter is ON for 30 cycles and OFF for 40 cycles, calculate i) ON-OFF time
interval ii)RMS output voltage iii) input PF
b)
10 Half wave AC voltage controller, inputs supply Vs=230V, 50Hz, load R=500
transformer has turns ratio 1:1. if the thyristor is triggered at a = 60° OS
. Calculate
i) RMS output voltage ii) output power iii) Avg. voltage
10 Full wave controller with R-L load derives expression for
c) extinction angle 13, with current & voltage waveforms(DCM). Vo S & 1,, where 10

You might also like