Professional Documents
Culture Documents
CAUTION: Fuser may be hot. Turn off printer, unplug it and allow it to sit for 20
to 30 minutes before performing these maintenance procedures.
NOTE: For the installation of the fuser in the HP 2605 skip step number 5,
to access the 4 screws to remove upper cover, lift open upper face cover
3. Carefully disengage the catches on the front part of the right side cover, remove cover
4. Unplug control ribbon cable
5. Insert a small screwdriver to loosen the release tab on each side of the upper face cover and remove
cover
9. Open two cable harness restraint (callout 3) and remove one cable harness restraint (callout 4)
3
16. REPLACING THE FUSER align the fuser tabs with there respective holes
4. Open front door, remove right cover by care fully twisting the front edges of the cover outward (to
make right cover removal easier, release the tab on the inside of the cover)
5. Remove left cover by releasing the tab on the lower front corner, pull out from bottom and then away
6. Squeeze the white link lever on left side to release
7. Remove the screw from the right white plastic catch, then remove plastic catch
13. Remove one screw from each hinge cam on the left and right sides
14. Using a needle nose pliers remove the hinge cam on both left and right sides