Professional Documents
Culture Documents
Mass, density or weight of Ammonium Nitrate, Ammonium Sulphate, Asbestos, Asbestos rock, Ashes, Bauxite, Bricks, Cement, Cement clinker, Chalk, Clay, Coal,
anthracite, Coke,
The mass of over 300 different 'dry' materials are listed below. Liquids, metals and woods are on other pages and
a site search facility is on the home page. While the data is useful for the design and selection of bulk materials
handling plant, bulk transport and packaging, individual samples will differ. Moisture content will have a marked
influence.
As 1000kg of pure water = 1 cubic metre, those materials under 1000kg/cu.m will float; more dense will sink ie.
those materials with a specific gravity more than 1.
Pure water was chosen as the 'base line' for specific gravity and given the value of 1. The specific gravity of all
other materials are compared to water as a fraction heavier or lighter density. For example, ammonium nitrate ha
a specific gravity (sg) of 0.73 while dry ammonium sulphate has a sg of 1.13 (1130 kilograms/cubic metre) (see
table below)
As specific gravity is just a comparison, it can be applied across any units. The density of pure water is also 62.4
lbs/cu.ft (pounds per cubic foot) and if we know that ammonium nitrate has a sg of 0.73 then we can calculate tha
its density is 0.73 x 62.4 = 45.552 lbs/cu.ft.
Note, kg/cu.m divided by 16.02 = lbs/cu.ft
[ back to conversion home page ] [ density of liquids ] [ density of water ] [ density of metals ] [ density of woods ]
Grain, Maize, Barley, Kaffir Corn, millet, Wheat, Iron ore, Iron Pyrites, Iron sulphate, Lead, steel, cast iron, Lignite, quick Lime, Limestone, Magnesium sulphate,
Magnesium oxide, Marble, Mica, Molybdenum ore, Nickel ore, Peat, Peanuts, Phosphate, Platinum ore, Potash ore, Pyrites, Quartz, soft Rock, Salt, Sand and gravel,
Sand, Sandstone, Sawdust, Shale, oyster Shells, Sinter, Slag, Slate, Soap, Soapstone talc, Soda ash, Soy beans, Sugar, Sulphur, Wood chips, Hard Wood, Soft Wood,
Zinc ore.
http://www.simetric.co.uk/si_materials.htm 17-08-2004
Mass, Weight, Density or Specific Gravity of Bulk Materials Page 2 of 10
http://www.simetric.co.uk/si_materials.htm 17-08-2004
Mass, Weight, Density or Specific Gravity of Bulk Materials Page 3 of 10
http://www.simetric.co.uk/si_materials.htm 17-08-2004
Mass, Weight, Density or Specific Gravity of Bulk Materials Page 4 of 10
http://www.simetric.co.uk/si_materials.htm 17-08-2004
Mass, Weight, Density or Specific Gravity of Bulk Materials Page 5 of 10
http://www.simetric.co.uk/si_materials.htm 17-08-2004
Mass, Weight, Density or Specific Gravity of Bulk Materials Page 6 of 10
http://www.simetric.co.uk/si_materials.htm 17-08-2004
Mass, Weight, Density or Specific Gravity of Bulk Materials Page 7 of 10
http://www.simetric.co.uk/si_materials.htm 17-08-2004
Mass, Weight, Density or Specific Gravity of Bulk Materials Page 8 of 10
http://www.simetric.co.uk/si_materials.htm 17-08-2004
Mass, Weight, Density or Specific Gravity of Bulk Materials Page 9 of 10
goto top
We have tried to be accurate with the above table but cannot be held responsible for in-accuracies.
Go back to first principals and double check your calculations if the result is 'mission critical'.
Remember that you cannot create energy only convert it. Likewise, you will not find a conversion from
pounds to metres - the basic units must remain the same - mass converted to mass, length converted to
length, et al.
You won't usually find a conversion from kilograms to grams - the prefix 'kilo' means '1,000' so a kilogram is
in fact 1,000 grams in the same way as a kilometer is 1,000 metres [or about 1,000 yards in 'old money']. I
have put a few in the tables because visitors have asked for them. More prefixes can be found on another
table.
One handy metric link between units to remember is that 1 Litre [1000cc] of pure water weighs 1 kilogram.
If accuracy is critical beware of old versions of MS Excel which had problems rounding off numbers.
More information on the SI System (Le Système International d'Unités) base units and definitions.
http://www.simetric.co.uk/si_materials.htm 17-08-2004