Professional Documents
Culture Documents
of Printed Pages : 4 ]
ME-305
B.E. ( III Semester )
PUT EXAMINATION, 2010
( Common to All Branches )
MACHINE DRAWING & DESIGN
Time : Three Hours
Maximum Marks : 100
Minimum Pass Marks : 35
Note : Attempt any one question from each unit. Assume suitable
missing/ misprint data, if necessary.
UNIT- I
....2
UNIT – II
Q.3 (a) Draw the projections of the following points on the same Q.7 (a) A right circular cone of base diameter 45 mm and axis 55
ground lines, keeping the projectors 15 mm apart : 8 mm long is lying one one of its generators on H.P. It is cut
(i) A, in the H.P. And 20 mm behind V.P. by a horizontal section plane passing through the mid point
(ii) B, 25 mm below the H.P. And 25 mm behind V.P. of the axis. Draw the projections of the cone and its true
(iii) C, 15 mm above the H.P. & 30 mm in front of V.P. section. 8
(iv) D, 40 mm below H.P. And 25 mm in front of V.P.
(b) A cylinder has been truncated by a circular surface as
(b) The front view of a line, inclined at 30O to the V.P. Is 65 shown in the following fig. 1 Draw the development of surface
mm long. Draw the projections and true length of the line of the cylinder.
when it is parallel to and 40 mm above the H.P. And its one
end being 30 mm in front of the V.P. 8
Or
Q.4 The projectors of the ends of line AB are 6 cm apart. The
end A is 2 cm above H.P. 3 cm in front of V.P. The end B is
1 cm below H.P. and 4 cm behind the V.P. Determine the
true length and traces of AB and its inclinations with the two
planes. 16
UNIT - III
Or
Q.6 (a) Draw the projections of a regular hexagon of 25 mm side
having one of its sides in the H.P. and inclined at 60O to the
V.P. and its surface making an angle of 45Owith the H.P. 8 (b) A hexagonal pyramid base 30 mm side and axis 65 mm long is
resting on its base on the H.P. with two edges parallel to the
(b) Draw the projections of a cube 20 mm long edges resting on V.P. It is cut by a section plane, perpendicular to the V.P.
the H.P. on one of its corners with a solid diagonal and inclined at 45O to the H.P. and intersecting the axis at a
perpendicular to the V.P. 8 point 25 mm above the base. Draw front view and sectional
top view of the section. 8
UNIT – IV