You are on page 1of 8

1 IS:280-1978

2 IS:383-1970
3 460(P-I)-1985
4 456-2000
5 460(P-II)-1985
6 516-1959
7 650-1991
8 702-1988
9 736-1986
10 814-1974
11 823-1964
12 961-1975
13 1002-1956
14 1030-1974
15 1077-1976
16 1124-1974

17 1129-1972
18 1139-1966
19 1148-1973
20 1195-1968
21 1199-1959
22 1200-1974 part-2
23 1200-1974 part-24
24 IS 1201-1978 To 1220-
1978
25 1239-1979
26 1239-1979 part-ii
27 1364-1967

28 1367-1984
29 1387-1967
30 1398-1960
31 1442-1964
32 1448
33 1477
34 1489-1991
35 1498-1970
36 1514-1959
37 1597(P-I)-1992
38 1597(P-II)-1992
39 1732-1971
40 1785-1966
41 1785-1966
42 1786-1985
43 1791-1985
44 1838

45 1838-(part-1) 1983
46 1888-1982
47 1893-1984
48 2185(P-II)-1983
49 2386(P-II)-1963
50 2386(P-III)-1963
51 2395(P-I)-1994
52 2395(PII)-1994
53 2430-1986
54 2572-1963
55 2720(p-I)-1983
56 2720(P-II)1973
57 2720(P-III/Sec I)-1980
58 2720 (P-IV)-1985
59 2720(P-V)-1985
60 2720(P-VI)-1972
61 2720(P-XV)-1986
62 2720(p-XXVI)1987
63 2720(P-28)-1974
64 3597-1998
65 4031-1988
66 4032-1985
67 4082-1996
68 4326-1993
69 4634-1991
70 4826-1979
71 5758-1984
72 6042-1969
73 6278-1971
74 6313(P-I)-1981
75 6313(P-II)-1981
76 6461(P-VIII)-1973
77 7246-1974
78 8112-1989
79 9013-1978
80 9284-1979
81 9429-1980
82 10080-1982
83 10262-1982
84 10329-1982
85 12269-1987
86 12468-1988
87 1292(P-I)-1988
88 13727-1993
89 CED-1997
90 RVD-1997
91 SP-27-1987 (IS: 2,IS:
1200)
92 SP-35 (S & T)-1987
93 SP-36-(P-2)-1988

94 IS: 1725-1982 1888-


1982 1892-1979
95 2131-1981
96 2132-1986
97 2720-(P-28)-1974
98 2720-(P-29)-1975
99 2720-(P-31)-1969
100 2720-(P-33)-1971
101 2720-(P-34)-1972
102 2720-(P-39/sec-2)1979
103 4434-1978
104 4968(P-1)-1976
105 4968(P-2)-1976
106. 4968(P-3)-1976
107. 8763-1978
108 9214-1979
109 9640-1980
110 10042-1981
111 IS: 10108-1982
112 10379-1982
113 10442-1983
114 10593-1986
115 11593-1986
116 11594-1985
117 13827-1993
118 13828-1993
Spec. For mild steel wire for general engineering purposes.    
Spec. For coarse and fine aggregate from natural sources for concrete    
Spec. For test sieves    
Code of practice for plain and reinforced concrete    
Spec. For test sieves    
Methods of tests for strength of concrete    
Standard sand for testing cement specification    
Industrial bitumen ( second revision)    
Wrought aluminium and aluminium alloys, plates    
Covered electrodes for metal arc welding of mild steel    
Code of procedure for manual arc welding of mild steel    
Structural steel (High tensile)    
Multipurpose grease no.1,no.2 & no.3    
Steel casting for general purpose    
Common burnt clay bricks    
Method of testing for determination of water absorption, apparent specific gravity and porosity of natural
building stones    
Dressing of natural building stone    
Hot rolled mild steel & medium tensile steel deformed bars foe concrete reinforcement    
Rivet bar for structural purposes    
Procedure for testing of hardness no. of bitumen mastic    
Methods of sampling and analysis of concrete    
Method of measurement of building and civil engineering works    
Method of measurement of building and civil engineering works    
Indian standard methods for Testing of tar and bitumen    

Mild steel tubes (fourth revision)    


Mild steel tubular rods and other rods steel pipe fittings (revision)    
Precision and semi-precision hexagon bolts, screws, nuts & lock nuts (dia. Range 6mm to 39mm) (first
revision)   
Technical supply conditions for threaded steel fasteners    
General requirements for supply of metallurgical materials    
Packing paper, water-proof, bitumen-laminated    
Covered electrodes fir metal arc welding of high tensile structural steel    
Method of tests for petroleum and its products    
Code of practice for finishing of iron and steel/ferrous metal in building:- painting and allied finishes     
Portland-pozzolona cement    
Classification and identification of soils for general engineering purposes    
Method of sampling and test for quick lime and hydrated lime    
Construction of stone masonry (Rubble)    
Construction of stone masonry (Ashlar masonry)    
Dimensions for round and square steel bars for structural and general engineering purposes    
Plain hard drawn steel wire for pre-stressed concrete    
Cold-twisted steel bars for concrete reinforcement    
Spec. For HYSD bars and wires for concrete reinforcement    
General requirements for batch type concrete mixers    
Performed filler for expansion joint in concrete pavement and structures (non-extruding and resilient
type)    
Bitumen impregnated fibre (first revision)    
Method of load tests on soils    
Criteria for earthquake resistant design of structures    
Spec. for concrete units    
Methods of test for aggregates for concrete    
Methods of test for aggregates for concrete    
Painting of concrete, masonry and plaster surfaces    
Painting of concrete, masonry and plaster surfaces    
Method of aggregates for concrete    
Code of practice for construction of hollow concrete block masonry.    
Methods of test for soils (Dry soil samples)    
Methods of test for soils (W.L)    
Methods of test for soils (S.G)    
Methods of test for soils (Grain size analysis)    
Methods of test for soils (Liquid and plastic limit)    
Methods of test for soils (Shrinkage factors)    
Methods of test for soils (Consolidation properties)    
Methods of test for soils (PH value)    
Methods of test for soils (dry density)    
Concrete pipes-method of test    
Method of physical tests for hydraulic cement    
Method of chemical Analysis of hydraulic cement    
Stacking and storage of construction materials and component at site recommendations    
Earthquake resistant design and construction of buildings code of practice    
Batch type concrete mixers method of test performance    
Spec. for hot dipped galvanized coatings on round steel wires    
Spec. for pre cast concrete kerbs, channels edgings, quadrants and gutter aprons    
Code of practice for construction of light weight concrete block masonry    
Code of practice for construction of light weight concrete block masonry    
Code of practice for anti termite measures in buildings    
Code of practice for anti termite measures in buildings    
Glossary of terms relating to cement concrete.    
Recommendations for the use of table vibrators for consolidating concrete    
43 grade O.P.C specification    
Method of making , curing and deterning compressive strength of accelerated cured concrete test
specimens    
Method of tests for abrasion resistance of concrete    
Code of practice for Drainage system for earth and rock fill dams    
Spec. For vibration machine    
Recommended guide lines for concrete mix design    
Method for sensitometry of photo graphic papers    
Specification for 53 grade O.P.C    
General requirements for vibrators for mass concreting, immersion type    
Spec. for precast concrete man hole covers and frames    
Requirements of cluster planning for housings    
Classified list of Indian Standards (Civil engineering) (LED)    
Classified list of Indian Stands    
(River valley engineering) (RVD) Hand book of method of measurement of building works.    

Hand book of water supply and drainage (with special emphasis on plumbing)    
Compendium of Indian Standards on Soil Engineering part-2 field testing of soils for civil engineering
purposes.    
Soil product Method of local test on soils Subsurface investigation for foundations    

Standard penetration test    


Code of practice for thin-walled tube sampling of soils    
Methods of test for soils Determination of dry density of soils, in-space, by the sand replacement
method    
Determination of dry density of soils, in-space, by the core. cutter method    
Field determination of California bearing ratio    
Determination of the density of soil in-space by the ring and water replacement method    
Determination of the density of soil in-space by rubber-balloon method    
Direct shear test for soils containing gravel-in-situ shear test    
Code of practice for in-situ vane shear test for soils    
Method for subsurface sounding for soils Dynamic method using 50mm cone without Bento Nite slurry    
-Do- Dynamic method using cone and Bento Nite slurry    
-Do- Static cone penetration test    
Guide for undisturbed soil sampling of sand    
Method of deter. Of modulus of sub grade reaction (K-Value) of soils in field    
Specification for split spoon sampler    
Load of practice for site investigations for foundation in gravel boulder deposit    
Code of practice for sampling of soils by thin wall sampler with stationary piston    
Code of practice for field control of moisture and compaction of soil for embankment and sub grade    
Spec. For earth augers (spiral type)    
Spec. For equipment for subsurface sounding of soils    
Spec. For shear box (Large) for testing of soils    
Spec. For mild steel thin walled sampling tubes and sampler meads    
Guidelines for improving earthquake resistance-earthen buildings    
Improving earthquake resistance of low strength masonary buildings - guidelines    
Total Length 2100 ft

Plumbing Work
Labour Nos Rate Days Total
Plumber 1 15 0 13000 13000
Helper 2 400 5 4000
Travel 4000
1 44 5 220
2 44 5 440
660
Lunch and Tea 1 70 5 350
2 70 5 700
1050

Total 5710
3000
13000

Rate Per Foot 6.2 10.0 21000

Excavation Work

Labour Nos Rate Days Total


Labours 4 200 20 16000 13000 29000

Travel

Lunch and Tea 6 70 10 4200


20200
Rate Per Foot 9.6 20 42000

Total 63000
20000
5000
88000
41.9
45 2100 94500

42000

11400 12000
6000
18000 24000

You might also like