You are on page 1of 4

PCB Solder Mask

PCB Component Layout


Important Notes

These full size images are shown at 200% scale. You should reduce it to actual size before
printing it to a photo-resist material. The part numbers refer to the schematic.

The PCB allows you to jumper the +12v and +15v power lines together. This can save you the
expense of the third power supply, but it can also introduce the high-power switching noise into
your delicate control circuits. So I don't recommend connecting them. Your mileage may vary, so
first make it work with an independent +12v supply, and then see if it still works after
connecting the jumper and using just +/- 15v supplies.
Resistors
Resistors listed in order by value are 1/4-watt, 5% unless otherwise indicated.

300 ohms R11


500 ohms R2
1,000 ohms R1, R12, R13, R14
1,500 ohms R10
10,000 ohms R4
11,000 ohms R6
22,000 ohms R8
56,000 ohms R3
100,000 ohms R5
150,000 ohms R7
370,000 ohms R9
50K linear taper VR1 (and VR2 opt.)

Capacitors
C1,C2 47 uF electrolytic
C3 0.1 uF ceramic or tantalum (must not be electrolytic)

Semiconductors
Q1,Q2 OP505A infrared photo detector, or equivalent
Q3 2N3055 NPN power transistor
LED1,2,4 Red light-emitting diode
LED 3 Infrared LED emitter
IC1-4 LM741 op amp, Radio Shack 276-007
D1 1N4001 (or 1N4004) silicon diode, 50v (or more) peak inverse voltage

Miscellaneous
+/- 15 vdc power supply, 1 amp
9 vdc power supply, 1 amp
Breadboard wiring pad (or printed circuit board by Amadeus)
18-ga stranded wire for power
Solid hook-up wire
24-ga (or thicker) magnet wire for lifting coil
6-terminal barrier strip (2 ea.)
Wood for base and frame

Alternatives for the LM741 Op-Amp


I chose the LM741 op-amp out of nostalgia and convenience. It was an extremely successful and
common op-amp about twenty years ago.
There are lots of modern choices for dual- and quad-package op-amps. By using a package with
multiple op-amps, you can reduce the number of parts and lower the cost. For example, you
could use a single quad-package op-amp instead of four separate 741s. This would allow a very
small printed circuit board to contain all the electronics!

Different packages also provide improved parameters such as noise immunity, speed, power,
etc. Here are several good choices recommended by David at www.ninetrees.com. All these are
better in every parameter than the trustworthy but ancient LM741.

These parts are commonly available on-line suppliers such as Digikey or Future-Active.

National Maxim Integrated


Analog Devices
Semiconductor Circuits
OP270, OP271,
Duals LF353, LF412 MAX412
OP249
Quads LF347 MAX414 OP470, OP471
Instrumentation
AD620, AMP02
amp

You might also like