Professional Documents
Culture Documents
This threaded
HC Series insert
insertsis designed to be molded into the
offer the same Recommended
plastic component during hole thesizes
molding cycle.as
benefits Typically,
C Seriesthe insert
plus is placed on a core pin in the mold during the
a flanged
molding cycle.
head. TheyThe insert
offer is designed
a large areaaggressiveSee
contact with the chart
knurling and below.
undercutsHoletosizes
resistare not
rotational and tensile
for electrical pull loads.
connection The
and part has a closed
greater necessarily corethread)
bottom (blind pin sizes.
to The core
eliminate plastic
pull-out flow into
strengths forthe threads.
reverse pins should
Although our catalog
entry insertbeis designed
brass, thistoproduct
allow for
can also be manufactured
applications. in stainless steel, steel shrinkage
and aluminum. of the plastic. For easier
release of core pins a 1˚ overall taper is
* Note: The manufacturing process may leave a smallacceptable. cut-off nib The
on the closed
depth end.
of the hole
Recommended Hole Size – See chart for installation hole size. should be the length of the insert plus
.030”
Additional information can be found on page 5, Design Guidelines. minimum to contain any flash that
might be displaced.
B
D
C “A” Stock ø
before knurl
Min. Thread
† Non-stocking items.