You are on page 1of 30

3412C Generator Set 9EP00001-UP(SEBP3105 - 31) - Estructura del documento

Pgina 1 de 30

Cerrar SIS

Pantalla anterior
Producto: GENERATOR SET Modelo: 3412C GENERATOR SET 9EP Configuracin: 3412C Generator Set 9EP00001-UP

Pruebas y Ajustes
VR6 Voltage Regulator
Nmero de medio -RENR2480-04 Fecha de publicacin -01/12/2007 Fecha de actualizacin -17/12/2007

i02654568

Wiring Diagrams
SMCS - 4467; 7566 The following wiring diagrams are shown below: Table 1 No. of Generator Leads Excitation Permanent Magnet (PM) 10/12 Self-Excited (SE) three-phase PM 4/6 SE three-phase PM Medium Voltage SE three-phase 9 three-phase single-phase 6 7 8 three-phase single-phase 3 4 5 Voltage Sensing three-phase single-phase No. of Illustration 1 2

https://127.0.0.1/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb/mediasearch/mediaheaderinfoframeset.jsp&cal... 29/07/2011

3412C Generator Set 9EP00001-UP(SEBP3105 - 31) - Estructura del documento

Pgina 2 de 30

Attachments Series Boost Module Cross Current Compensation Manual Voltage Control for SE Generators Manual Voltage Control for PM Generators VAR/PF Controller 10 11 12 13 14

The following notes are referred to throughout each illustration: Table 2 Note Note 1 Comment Connect the wire to terminal 5 for a 1 Ampere CT. Connect the wire to terminal 5A for a 5 Ampere CT. Do not use 1 ampere CT with a VAR/PF Controller. Connect the remote voltage adjust potentiometer between terminals 6A and 7. Remove the jumper between terminals 4 and 7. The remote voltage adjust potentiometer should be rated at 10 K Ohm and 2 Watt. Place the jumper between terminals 6A and 8 for 1 V/Hz underfrequency slope. Remove the jumper between terminals 6A and 8 for 2 V/Hz underfrequency slope. Place the jumper between terminals 6A and 9 for three-phase sensing. Remove the jumper between terminals 6A and 9 for single-phase sensing. Connect terminals 2 and 3 to the VAR/PF controller. Short terminals 2 and 3 when the VAR/PF controller is not used. For three-phase voltage sensing, connect the wiring to the secondary winding. Phase rotation with transformer T1 is important. Connect terminal 22 to the PT on T1. Connect terminal 24 to the PT on T2. Connect terminal 20 to the PT on T3. Use twisted, shielded cables. Single-phase, 220 VAC to 240 VAC secondary transformer winding, 50 / 60 Hz, 3125 VA Three-phase, 63 VAC to 105 VAC, 50 / 60 Hz, 3125 VA Connect jumper from terminal 28 to ground terminal on "Permanent Magnet" generators as per the following qualifications. 1) LS65-12 Revisions A through E

Note 2

Note 3 Note 4 Note 5 Note 6 Note 7

Note 8

https://127.0.0.1/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb/mediasearch/mediaheaderinfoframeset.jsp&cal... 29/07/2011

3412C Generator Set 9EP00001-UP(SEBP3105 - 31) - Estructura del documento

Pgina 3 de 30

2) VR6 Revisions A through B 3) VR6 Revisions C and later have an internal jumper and do not require and external jumper.

10/12 Lead Permanent Magnet (PM) Excited Generators with Three-Phase Sensing

https://127.0.0.1/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb/mediasearch/mediaheaderinfoframeset.jsp&cal... 29/07/2011

3412C Generator Set 9EP00001-UP(SEBP3105 - 31) - Estructura del documento

Pgina 4 de 30

https://127.0.0.1/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb/mediasearch/mediaheaderinfoframeset.jsp&cal... 29/07/2011

3412C Generator Set 9EP00001-UP(SEBP3105 - 31) - Estructura del documento

Pgina 5 de 30

Illustration 1 (CR1-CR6) Rotating rectifiers (CR7, CR8) Surge suppression diodes (E1) Positive heat sink (E2) Negative heat sink (L1) Exciter field (stator) (L2) Exciter armature (rotor) (L3) Revolving field (main rotor) (L4) Main stator (L5) PM exciter stator (M) Rotating permanent magnet (R2) Remote level potentiometer (R5) Suppression resistor (RFA) Revolving field assembly (T1) Voltage droop transformer (option)

g01333122

Note: Refer to Table 2 for notes.

10/12 Lead Self-Excited (SE) Generators with Single-Phase Sensing

https://127.0.0.1/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb/mediasearch/mediaheaderinfoframeset.jsp&cal... 29/07/2011

3412C Generator Set 9EP00001-UP(SEBP3105 - 31) - Estructura del documento

Pgina 6 de 30

Illustration 2 (CR1-CR6) Rotating rectifiers

g00779534

https://127.0.0.1/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb/mediasearch/mediaheaderinfoframeset.jsp&cal... 29/07/2011

3412C Generator Set 9EP00001-UP(SEBP3105 - 31) - Estructura del documento

Pgina 7 de 30

(CR7, CR8) Surge suppression diodes (E1) Positive heat sink (E2) Negative heat sink (L1) Exciter field (stator) (L2) Exciter armature (rotor) (L3) Revolving field (main rotor) (L4) Main stator (R2) Remote level potentiometer (R5) Suppression resistor (RFA) Revolving field assembly (T1) Voltage droop transformer (option)

Note: Refer to Table 2 for notes.

10/12 Lead Self-Excited (SE) Generators with Three-Phase Sensing

https://127.0.0.1/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb/mediasearch/mediaheaderinfoframeset.jsp&cal... 29/07/2011

3412C Generator Set 9EP00001-UP(SEBP3105 - 31) - Estructura del documento

Pgina 8 de 30

Illustration 3 (CR1-CR6) Rotating rectifiers

g00779536

https://127.0.0.1/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb/mediasearch/mediaheaderinfoframeset.jsp&cal... 29/07/2011

3412C Generator Set 9EP00001-UP(SEBP3105 - 31) - Estructura del documento

Pgina 9 de 30

(CR7, CR8) Surge suppression diodes (E1) Positive heat sink (E2) Negative heat sink (L1) Exciter field (stator) (L2) Exciter armature (rotor) (L3) Revolving field (main rotor) (L4) Main stator (R2) Remote level potentiometer (R5) Suppression resistor (RFA) Revolving field assembly (T1) Voltage droop transformer (option)

Note: Refer to Table 2 for notes.

4/6 Lead Permanent Magnet (PM) Excited Generators with Three-Phase Sensing

https://127.0.0.1/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb/mediasearch/mediaheaderinfoframeset.jsp&cal... 29/07/2011

3412C Generator Set 9EP00001-UP(SEBP3105 - 31) - Estructura del documento

Pgina 10 de 30

https://127.0.0.1/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb/mediasearch/mediaheaderinfoframeset.jsp&cal... 29/07/2011

3412C Generator Set 9EP00001-UP(SEBP3105 - 31) - Estructura del documento

Pgina 11 de 30

Illustration 4 (CR1-CR6) Rotating rectifiers (CR7, CR8) Surge suppression diodes (E1) Positive heat sink (E2) Negative heat sink (L1) Exciter field (stator) (L2) Exciter armature (rotor) (L3) Revolving field (main rotor) (L4) Main stator (L5) PM exciter stator (M) Rotating permanent magnet (R2) Remote level potentiometer (R5) Suppression resistor (RFA) Revolving field assembly (T1) Voltage droop transformer (option)

g01333154

Note: Refer to Table 2 for notes.

4/6 Lead Self-Excited (SE) Generators with Single-Phase Sensing

https://127.0.0.1/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb/mediasearch/mediaheaderinfoframeset.jsp&cal... 29/07/2011

3412C Generator Set 9EP00001-UP(SEBP3105 - 31) - Estructura del documento

Pgina 12 de 30

Illustration 5 (CR1-CR6) Rotating rectifiers

g00847793

https://127.0.0.1/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb/mediasearch/mediaheaderinfoframeset.jsp&cal... 29/07/2011

3412C Generator Set 9EP00001-UP(SEBP3105 - 31) - Estructura del documento

Pgina 13 de 30

(CR7, CR8) Surge suppression diodes (E1) Positive heat sink (E2) Negative heat sink (L1) Exciter field (stator) (L2) Exciter armature (rotor) (L3) Revolving field (main rotor) (L4) Main stator (R2) Remote level potentiometer (R5) Suppression resistor (RFA) Revolving field assembly (T1) Voltage droop transformer (option)

Note: Refer to Table 2 for notes.

4/6 Lead Self-Excited (SE) Generators with Three-Phase Sensing

https://127.0.0.1/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb/mediasearch/mediaheaderinfoframeset.jsp&cal... 29/07/2011

3412C Generator Set 9EP00001-UP(SEBP3105 - 31) - Estructura del documento

Pgina 14 de 30

Illustration 6 (CR1-CR6) Rotating rectifiers

g00847798

https://127.0.0.1/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb/mediasearch/mediaheaderinfoframeset.jsp&cal... 29/07/2011

3412C Generator Set 9EP00001-UP(SEBP3105 - 31) - Estructura del documento

Pgina 15 de 30

(CR7, CR8) Surge suppression diodes (E1) Positive heat sink (E2) Negative heat sink (L1) Exciter field (stator) (L2) Exciter armature (rotor) (L3) Revolving field (main rotor) (L4) Main stator (R2) Remote level potentiometer (R5) Suppression resistor (RFA) Revolving field assembly (T1) Voltage droop transformer (option)

Note: Refer to Table 2 for notes.

Medium Voltage Permanent Magnet Generators with Three-Phase Sensing

https://127.0.0.1/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb/mediasearch/mediaheaderinfoframeset.jsp&cal... 29/07/2011

3412C Generator Set 9EP00001-UP(SEBP3105 - 31) - Estructura del documento

Pgina 16 de 30

https://127.0.0.1/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb/mediasearch/mediaheaderinfoframeset.jsp&cal... 29/07/2011

3412C Generator Set 9EP00001-UP(SEBP3105 - 31) - Estructura del documento

Pgina 17 de 30

Illustration 7 (CR1-CR6) Rotating rectifiers (CR7, CR8) Surge suppression diodes (E1) Positive heat sink (E2) Negative heat sink (L1) Exciter field (stator) (L2) Exciter armature (rotor) (L3) Revolving field (main rotor) (L4) Main stator (L5) PM exciter stator (M) Rotating permanent magnet (R2) Remote level potentiometer (R5) Suppression resistor (RFA) Revolving field assembly (T1) Voltage droop transformer (option)

g01333228

Note: Refer to Table 2 for notes.

Medium Voltage Self-Excited Generators with Single-Phase Sensing

https://127.0.0.1/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb/mediasearch/mediaheaderinfoframeset.jsp&cal... 29/07/2011

3412C Generator Set 9EP00001-UP(SEBP3105 - 31) - Estructura del documento

Pgina 18 de 30

Illustration 8 (CR1-CR6) Rotating rectifiers

g00779543

https://127.0.0.1/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb/mediasearch/mediaheaderinfoframeset.jsp&cal... 29/07/2011

3412C Generator Set 9EP00001-UP(SEBP3105 - 31) - Estructura del documento

Pgina 19 de 30

(CR7, CR8) Surge suppression diodes (E1) Positive heat sink (E2) Negative heat sink (L1) Exciter field (stator) (L2) Exciter armature (rotor) (L3) Revolving field (main rotor) (L4) Main stator (R2) Remote level potentiometer (R5) Suppression resistor (RFA) Revolving field assembly (T1) Voltage droop transformer (option)

Note: Refer to Table 2 for notes.

Medium Voltage Self-Excited Generators with Three-Phase Sensing

https://127.0.0.1/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb/mediasearch/mediaheaderinfoframeset.jsp&cal... 29/07/2011

3412C Generator Set 9EP00001-UP(SEBP3105 - 31) - Estructura del documento

Pgina 20 de 30

Illustration 9 (CR1-CR6) Rotating rectifiers

g00847804

https://127.0.0.1/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb/mediasearch/mediaheaderinfoframeset.jsp&cal... 29/07/2011

3412C Generator Set 9EP00001-UP(SEBP3105 - 31) - Estructura del documento

Pgina 21 de 30

(CR7, CR8) Surge suppression diodes (E1) Positive heat sink (E2) Negative heat sink (L1) Exciter field (stator) (L2) Exciter armature (rotor) (L3) Revolving field (main rotor) (L4) Main stator (R2) Remote level potentiometer (R5) Suppression resistor (RFA) Revolving field assembly (T1) Voltage droop transformer (option)

Note: Refer to Table 2 for notes.

Series Boost Module

https://127.0.0.1/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb/mediasearch/mediaheaderinfoframeset.jsp&cal... 29/07/2011

3412C Generator Set 9EP00001-UP(SEBP3105 - 31) - Estructura del documento

Pgina 22 de 30

Illustration 10 (1) Refer to Illustration 12.

g01441828

Note: Refer to Table 2 for notes.

Cross Current Compensation

https://127.0.0.1/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb/mediasearch/mediaheaderinfoframeset.jsp&cal... 29/07/2011

3412C Generator Set 9EP00001-UP(SEBP3105 - 31) - Estructura del documento

Pgina 23 de 30

https://127.0.0.1/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb/mediasearch/mediaheaderinfoframeset.jsp&cal... 29/07/2011

3412C Generator Set 9EP00001-UP(SEBP3105 - 31) - Estructura del documento

Pgina 24 de 30

Illustration 11

g01441832

Note: Refer to Table 2 for notes. Note: Transformer T1 must be a 5 Ampere CT.

Manual Voltage Control for SE Generators

https://127.0.0.1/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb/mediasearch/mediaheaderinfoframeset.jsp&cal... 29/07/2011

3412C Generator Set 9EP00001-UP(SEBP3105 - 31) - Estructura del documento

Pgina 25 de 30

https://127.0.0.1/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb/mediasearch/mediaheaderinfoframeset.jsp&cal... 29/07/2011

3412C Generator Set 9EP00001-UP(SEBP3105 - 31) - Estructura del documento

Pgina 26 de 30

Illustration 12 (CR1-CR6) Rotating rectifiers (CR7, CR8) Surge suppression diodes (E1) Positive heat sink (E2) Negative heat sink (L1) Exciter field (stator) (L2) Exciter armature (rotor) (L3) Revolving field (main rotor) (L4) Main stator (R2) Remote level potentiometer (R5) Suppression resistor (RFA) Revolving field assembly (T1) Voltage droop transformer (option)

g01333375

Note: Refer to Table 2 for notes.

Manual Voltage Control for PM Generators

https://127.0.0.1/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb/mediasearch/mediaheaderinfoframeset.jsp&cal... 29/07/2011

3412C Generator Set 9EP00001-UP(SEBP3105 - 31) - Estructura del documento

Pgina 27 de 30

Illustration 13 (CR1-CR6) Rotating rectifiers

g01333600

https://127.0.0.1/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb/mediasearch/mediaheaderinfoframeset.jsp&cal... 29/07/2011

3412C Generator Set 9EP00001-UP(SEBP3105 - 31) - Estructura del documento

Pgina 28 de 30

(CR7, CR8) Surge suppression diodes (E1) Positive heat sink (E2) Negative heat sink (L1) Exciter field (stator) (L2) Exciter armature (rotor) (L3) Revolving field (main rotor) (L4) Main stator (L5) PM exciter stator (M) Rotating permanent magnet (R2) Remote level potentiometer (R5) Suppression resistor (RFA) Revolving field assembly (T1) Voltage droop transformer (option)

Note: Refer to Table 2 for notes.

VAR/PF Controller

https://127.0.0.1/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb/mediasearch/mediaheaderinfoframeset.jsp&cal... 29/07/2011

3412C Generator Set 9EP00001-UP(SEBP3105 - 31) - Estructura del documento

Pgina 29 de 30

https://127.0.0.1/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb/mediasearch/mediaheaderinfoframeset.jsp&cal... 29/07/2011

3412C Generator Set 9EP00001-UP(SEBP3105 - 31) - Estructura del documento

Pgina 30 de 30

Illustration 14 (CR1-CR6) Rotating rectifiers (CR7, CR8) Surge suppression diodes (E1) Positive heat sink (E2) Negative heat sink (L1) Exciter field (stator) (L2) Exciter armature (rotor) (L3) Revolving field (main rotor) (L4) Main stator (R2) Remote level potentiometer (R5) Suppression resistor (RFA) Revolving field assembly (T1) Voltage droop transformer (option)

g01441865

Note: Refer to Table 2 for notes.

Copyright 1993 - 2011 Caterpillar Inc. Todos los derechos reservados. Red privada para licenciados del SIS.

Fri Jul 29 22:35:38 CST 2011

https://127.0.0.1/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb/mediasearch/mediaheaderinfoframeset.jsp&cal... 29/07/2011

You might also like