You are on page 1of 90

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws.

f you acquired this


document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 1 of 90




GMC Securty, Remote Start, Keyess Entry & Navgaton
Wre Coors Verson 4.2









PLEASE NOTE

The information contained is accurate to the best of our knowledge. 12 Volt Resource LLC
makes no representation or warranty with respect to the information contained in this
document including its accuracy or completeness. 12 Volt Resource LLC disclaims all
liability or responsibility for errors or omissions therein or any decision made by the
recipient in reliance thereon.

nstallations should be attempted by experienced installers only. Proper installation
remains the responsibility of the installer. t is the installer's responsibility to test and verify
all circuitry with the proper test equipment prior to installation.


Additional nformation:

This information is sorted alphabetically by vehicle model. f there are multiple
years for a particular vehicle model, then the oldest year comes first.

The installation notes referenced below and the full installation guide are located
in the nstall nstructions & Notes folder on this CD-ROM.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 2 of 90


Make: Model: Year:
GMC CabaIIero 1983-1987


FUNCTON COLOR LOCATON
Start: PURPLE GNTON SWTCH HARNESS **
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS (HEAT/AC) ***
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: WHTE (+) SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE AT DSTRBUTOR *
Parking Lights: BROWN (+) AT LGHT SWTCH
Headlights: YELLOW (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Some Models Carburated, Some Throttle Body njection. ** See Note #300 - GM Rear
Wheel Drive Vehicles. *** See Note #233 - High Current gnition Wires Diagram.

GMC CabaIIero 1983-1987

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
WHTE (-) AT PN SWTCH
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: LGHT BLUE DRVER'S KCK PANEL ****
Power Unlock: BLACK DRVER'S KCK PANEL ****
Trunk Release: N/A
Alarm nput Wire: WHTE (-) AT PN SWTCH

NOTES: **** See Note #202 - Positive Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 3 of 90

GMC Canyon 2004-2006

FUNCTON COLOR LOCATON
Start: See Note Below* See Note Below*
gnition #1: Dk. Blue gnition switch harness
gnition #2: N/A
gnition #3: See Note Below* See Note Below*
Accessory: Brown gnition switch harness
Brake Light: Lt. Blue (+) Above the brake pedal switch
Tach Signal: White (ac) gnition Control Module Above Engine
Parking
Lights:
Brown (+) Found at BCM**
Headlights:
Diesel Glow
Plug:

Clutch
Bypass Wire:

Notes: * The white/black wires found on the Key Sense Module. Two relays and resistors will have to be
obtained. You will need a vehicle specific bypass module. ** BCM (Body Control Module) located in
the passengers kit panel.

GMC Canyon 2004-2006

FUNCTON COLOR LOCATON
Constant +12
Volts:
Red Found at the BCM**
OEM Alarm
Disarm:

Dome
Lights/Superv:
See Note Below*** See Note Below***
OEM Horn: Black (-) Found at BCM
Power Lock: Dk.Blue BCM, Black Plug
Power Unlock: Lt.Blue BCM, Black Plug
Trunk Release:
Alarm nput
Wire:
See Note Below*** See Note Below***
Notes:
*** The driver door trigger is lt. green/black. The passenger door is lt. blue, must diode isolate both
wires. These wires are located at the BCM (Body control).


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 4 of 90

Make: Model: Year:
GMC CycIone 1991-1993


FUNCTON COLOR LOCATON
Start: YELLOW OR PURPLE GNTON SWTCH HARNESS
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS (HEAT/AC)
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: WHTE (+) SWTCH ON BRAKE PEDAL SUPPORT
BRACKET
Tach Signal: WHTE AT DSTRBUTOR *
Parking Lights: BROWN (+) AT LGHT SWTCH
Headlights: YELLOW (+) HEADLGHT SWTCH OR BEAM SELECT
SW.
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Throttle Body njection. ** See Note #300 - GM Rear Wheel Drive Vehicles

GMC CycIone 1991-1993

FUNCTON COLOR LOCATON
Constant +12 Volts: RED AND RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
WHTE/BLACK OR
WHTE
(-) DRVER PN SWTCH OR COURTESY
LGT
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS OR AT
RELAY
Power Lock: LT BLUE BEHND OR BELOW DRVER SPEAKER ***
Power Unlock: BLACK/WHTE OR
BLACK
BEHND OR BELOW DRVER SPEAKER ***
Trunk Release: N/A
Alarm nput Wire: WHTE/BLACK OR
WHTE
(-) DRVER PN SWTCH OR COURTESY
LGT

NOTES: *** See Note #203 - Reverse Polarity Door Lock Diagram.
Make: Model: Year:

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 5 of 90

GMC DenaIi 1999




FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS *
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: WHTE GNTON SWTCH HARNESS (ECM)
gnition #3: N/A
Accessory: ORANGE GNTON SWTCH HARNESS (HEAT/AC) **
Brake Light: WHTE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE
AT COL ON PASSENGER REAR OF
ENGNE
Parking Lights: BROWN (+) AT HEADLGHT SWTCH
Headlights: YELLOW (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Equipped With GM's PASSLOCK Anti-Theft System as standard equipment; See
Note #113 - Bypassing GM's PASSLOCK Passive Theft System Diagram. ** See Note #233 -
High Current gnition Wires Diagram.

GMC DenaIi 1999

FUNCTON COLOR LOCATON
Constant +12 Volts: RED (2) GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A N SCHEMATCS
Dome
Lights/Superv:
PURPLE (-) 4 PN BLACK CONN. N DR. KCK PANEL***
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: L BLUE DRVER'S KCK PANEL ****
Power Unlock: WHTE DRVER'S KCK PANEL ****
Trunk Release: N/A
Alarm nput Wire: PURPLE (-) 4 PN BLACK CONN. N DR. KCK PANEL***

NOTES: *** PURPLE (-) Wire Also Located At Headlight Switch. See Tech Notes For Additional
nformation On Dome Light. **** 2 Door Without OEM Keyless Entry See Note #203 - Reverse
Polarity Door Lock Diagram. 2 Door With OEM Keyless Entry See Note #202 - Positive Pulse
Door Lock Diagram. 4 Door With Or Without OEM Keyless See Note #202 - Positive Pulse Door
Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 6 of 90

Make: Model: Year:
GMC DenaIi 2000-2002


FUNCTON COLOR LOCATON
Start: YELLOW (18 AWG) GNTON SWTCH HARNESS *
gnition #1: PNK (16 AWG) GNTON SWTCH HARNESS
gnition #2: WHTE (18 AWG) GNTON SWTCH HARNESS(ECM)
gnition #3: N/A
Accessory: ORANGE GNTON SWTCH HARNESS (HEAT/AC)
Brake Light: WHTE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: VOLET/WHTE
AT PLUG ABOVE VALVE COVER ON DR.
SDE
Parking Lights: BROWN (+) 12 PN PLUG N FUSE PANEL OR AT
SWTCH
Headlights: YELLOW (+) AT HEALGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * This Vehicle s Equipped With GM's PASSLOCK Anti-Theft System; See Note #113.

GMC DenaIi 2000-2002

FUNCTON COLOR LOCATON
Constant +12 Volts: RED (2) GNTON SWTCH HARNESS
OEM Alarm Disarm: GREEN N FLAT CONNECTOR N DR. KCK PANEL
Dome
Lights/Superv:
WHTE AT PLUG N CONVENENCE CENTER **
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: LT. BLUE 12 PN PLUG AT FUSE PANEL ON DR. SDE
Power Unlock: WHTE DRVER'S KCK PANEL N BODY CAVTY ***
Trunk Release: N/A
Alarm nput Wire: WHTE AT PLUG N CONVENENCE CENTER **

NOTES: ** Convenience Center s Locate Under Driver's Dash Near Fire Wall (Listen for dome
light relay). *** See Note #202 - Positive Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 7 of 90

Make: Model: Year:
GMC Envoy 1999-2001


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS **
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: PNK/WHTE OR WHTE GNTON SWTCH HARNESS ***
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS (HEAT/AC)
Brake Light: WHTE (+) AT SWTCH BAOVE BRAKE PEDAL
Tach Signal: WHTE AT GNTON COL *
Parking Lights: LT. BLUE (+) AT HEADLGHT SWTCH
Headlights: YELLOW (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * WHT/BLK At Distributor gnition Module Can Also Be Used For Tach.gnition Coil And
Distributor Module Both Located On Passenger Side Of Engine. ** 1998+ Vehicle is equipped
with PASSLOCK Anti-theft system. See Note #113 - Bypassing PASSLOCK Theft Deterrent
System Diagram. *** This Wire Powers the PCM in the Vehicle and Must Be Active in Both ""
Start"" and ""Run"".

GMC Envoy 1999-2001

FUNCTON COLOR LOCATON
Constant +12 Volts: RED (2) GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A SEE NOTES *****
Dome
Lights/Superv:
WHTE (-) AT PN SWTCH OR COURTESY LGHT
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: L BLUE 76 PN CONN. ABOVE DRVER'S KCK ****
Power Unlock: WHTE 76 PN CONN. ABOVE DRVER'S KCK ****
Trunk Release: BLACK/WHTE (+) AT TRUNK RELEASE SWTCH
Alarm nput Wire: WHTE (-) AT PN SWTCH OR COURTESY LGHT

NOTES: **** See Note #202 - Positive Pulse Door Lock Diagram. ***** Disarm requires a +12
Volt pulse to both gnition #1 and gnition #2 wires simultaneously. Use a relay.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 8 of 90

Make: Model: Year:
GMC Envoy 2002-2003


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS *
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: WHTE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: ORANGE GNTON SWTCH HARNESS
Brake Light: WHTE AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE
N BLUE PLUG AT THE ECM ON DRVER'S
SDE OF MOTOR
Parking Lights: BROWN (+) DRVER'S KCK PANEL
Headlights:
Diesel Glow Plug: N/A
Clutch Bypass Wire: N/A
NOTES: * This Vehicle s Equipped With GM's PASSLOCK Anti-Theft System - a universal
alarm bypass module. For alternative bypass method see Note #113 , Bypassing Passlock /.

GMC Envoy 2002-2003

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm: LT. GREEN (-) NSDE OF DRVER'S DOOR AT MODULE **
Dome
Lights/Superv:
GRAY/BLACK (+) UNDERNEATH DASH AT COURTESY LAMP
OEM Horn: BLACK/YELLOW (-) STEERNG COLUMN HARNESS
Power Lock: SEE NOTE BELOW ***
Power Unlock: SEE NOTE BELOW ***
Trunk Release: N/A
Alarm nput Wire: GRAY/BLACK (+) UNDERNEATH DASH AT COURTESY LAMP
NOTES: ** Module s Part Of Power Windows/Locks Switch Assembly n Driver's Door. *** Use a
Vehicle Specific Door Lock nterface. This interface module will also arm/disarm the OEM alarm,
elliminating the need to go into the drivers door. As an alternative, one can go nside Of Driver's,
Front Passenger And Rear Hatch To Wire Three Separate 5-Wire Reverse Polarity Systems To
The Lock Motors n Each Door. The Wires Are GRAY For Lock And TAN For Unlock. This Will
Unlock/Lock The Two Front Doors And The Rear Hatch. The Middle Doors, Must Be Diode
solated And Wired As A Negative Trigger System Using LT. BLUE For Lock And WHTE For
Unlock. The Wires Are Located Under The Rear Seat On The Driver's Side. See nstallation Note
#201 - Negative Pulse Door Locks And nstallation Note #203 - Reverse Polarity Door Lock
System.



This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 9 of 90

ENVOY 2004 -2006



KEY
T-
HARNESS
MMOBLZER
N/A N/A GM's PASSLOCK 2 ANT-THEFT System, Requires Bypass Module

FUNCTON COLOR LOCATON
12 VOLT CONSTANT RED (+) and RED/WHTE (+) GNTON SWTCH HARNESS
STARTER YELLOW (+) GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 PNK (+) GNTON SWTCH HARNESS
GNTON 2 WHTE (+) See NOTE *4 GNTON SWTCH HARNESS
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
ORANGE (+) GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE LGHT GREEN (-) GNTON SWTCH HARNESS
PARKNG LGHTS ( - ) GRAY/BLACK (-)
@ BCM,TAN plug, Pin E5, See
NOTE *5
PARKNG LGHTS ( + ) BROWN (+)
@ FUSEBOX under REAR
SEAT
POWER LOCK See NOTE *1 S
POWER UNLOCK See NOTE *1 S
DOOR TRGGER See NOTE *2
DOMELGHT SUPERVSON GRAY/BLACK (-)
N DRVERS DOOR MODULE
in DOOR
TRUNK RELEASE N/A
SLDNG POWER DOOR N/A

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 10 of 90

HORN BLACK (-)


@ STEERNG COLUMN
HARNESS or BCM. TAN Plug,
Pin E12 See NOTE *5
TACH WHTE @ PCM, See NOTE *3
WAT TO START LGHT N/A
BRAKE WHTE (+)
@ SWTCH ABOVE BRAKE
PEDAL
FACTORY ALARM DSARM LGHT GREEN (-)
in DRVERS DOOR MODULE in
DRVERS DOOR
ANT-THEFT
YELLOW (+), BLACK (-) and
RED/WHTE (Not Used)
GM's PASSLOCK 2 System,
these wires exit the gnition
Switch Tumbler together and
are in the Main gnition Switch
Harness in the Column.

EXTRA NFORMATON
NOTE *1 this vehicle uses a Special Multi-plex Type Door Locking System that will require (4)extra
Relays Part #775, to do the Door Locks, NOTE *2 This vehicle has 4 door pin trigger wires,
DRVERS DOOR is a GRAY/BLACK (-) in the DRVERS DOOR MODULE in the DRVERS DOOR,
the PASSENGER DOOR is a BLACK/WHTE (-) in the PASSENGERS DOOR at the PASSENGER
DOOR MODULE, the DRVERS REAR DOOR is a LGHT BLUE/BLACK (-) and the PASSENGERS
REAR DOOR is a LGHT GREEN/BLACK (-) the wires are located at the FUSEBOX under the
DRVERS REAR SEAT. When connecting to an ALARM SYSTEM use all 4 Door Trigger wires and
DODE SOLATE. to connect, NOTE *3 The PCM (Power Control Module) is located on the
DRVERS SDE of the ENGNE, on the 4.2L engine, it is a BLUE Plug, Pin 49. On the 5.3L engine it
is on the LOWER front driver side of engine GREEN Plug Pin 10. NOTE *4 MPORTANT !!!!! this wire
MUST BE CONNECTED as GNTON #2 for REMOTE STARTNG!!!!!! NOTE *5 The BCM is
attached to the FUSEBOX under the LEFT REAR SEAT.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 11 of 90

Make: Model: Year:
GMC Envoy XL 2002-2003


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS *
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: WHTE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: ORANGE GNTON SWTCH HARNESS
Brake Light: WHTE AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE
N BLUE PLUG AT THE ECM ON DRVER'S
SDE OF MOTOR
Parking Lights: BROWN (+) DRVER'S KCK PANEL
Headlights:
Diesel Glow Plug: N/A
Clutch Bypass Wire: N/A
NOTES: * This Vehicle s Equipped With GM's PASSLOCK Anti-Theft System - a universal
alarm bypass module. For alternative bypass method see Note #113 , Bypassing Passlock /.

GMC Envoy XL 2002-2003

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm: LT. GREEN (-) NSDE OF DRVER'S DOOR AT MODULE **
Dome
Lights/Superv:
GRAY/BLACK (+) UNDERNEATH DASH AT COURTESY LAMP
OEM Horn: BLACK/YELLOW (-) STEERNG COLUMN HARNESS
Power Lock: SEE NOTE BELOW ***
Power Unlock: SEE NOTE BELOW ***
Trunk Release: N/A
Alarm nput Wire: GRAY/BLACK (+) UNDERNEATH DASH AT COURTESY LAMP
NOTES: ** Module s Part Of Power Windows/Locks Switch Assembly n Driver's Door. *** Use a
Vehicle Specific Door Lock nterface. This interface module will also arm/disarm the OEM alarm,
elliminating the need to go into the drivers door. As an alternative, one can go nside Of Driver's,
Front Passenger And Rear Hatch To Wire Three Separate 5-Wire Reverse Polarity Systems To
The Lock Motors n Each Door. The Wires Are GRAY For Lock And TAN For Unlock. This Will
Unlock/Lock The Two Front Doors And The Rear Hatch. The Middle Doors, Must Be Diode
solated And Wired As A Negative Trigger System Using LT. BLUE For Lock And WHTE For
Unlock. The Wires Are Located Under The Rear Seat On The Driver's Side. See nstallation Note
#201 - Negative Pulse Door Locks And nstallation Note #203 - Reverse Polarity Door Lock
System.



This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 12 of 90

ENVOY XL 2004 -2006



KEY T-HARNESS MMOBLZER
N/A N/A PASSLOCK 2, Requires Bypass Module

FUNCTON COLOR LOCATON
12 VOLT CONSTANT RED (+) and RED/WHTE (+) GNTON SWTCH HARNESS
STARTER YELLOW (+) GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 PNK (+) GNTON SWTCH HARNESS
GNTON 2 WHTE (+) See NOTE *3 GNTON SWTCH HARNESS
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
ORANGE (+) GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE LGHT GREEN (-) GNTON SWTCH HARNESS
PARKNG LGHTS ( - ) GRAY/BLACK (-)
@ BCM,TAN plug, Pin E5, See
NOTE *4
PARKNG LGHTS ( + ) BROWN (+)
@ FUSEBOX UNDER
DRVERS REAR SEAT
POWER LOCK See NOTE *1
POWER UNLOCK See NOTE *1
DOOR TRGGER GRAY/BLACK (+)
@ FUSEBOX UNDER
DRVERS REAR SEAT
DOMELGHT SUPERVSON TURNS ON WTH DSARM
TRUNK RELEASE N/A
SLDNG POWER DOOR N/A
HORN
BLACK (-) or BLACK/YELLOW
(-)
@ BCM, TAN Plug, Pin E12,
See NOTE *4

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 13 of 90

TACH WHTE @ PCM, See NOTE *2


WAT TO START LGHT N/A
BRAKE WHTE (+)
@ SWTCH ABOVE BRAKE
PEDAL
FACTORY ALARM DSARM LGHT GREEN (-)
@ DRVER DOOR MODULE in
DRVERS DOOR.
ANT-THEFT
YELLOW (+), BLACK (-) and
RED/WHTE (Not Used)
GM's PASSLOCK 2 System,
these wires exit the gnition
Switch Tumbler together and
are in the Main gnition Switch
Harness in the Column.

EXTRA NFORMATON
NOTE *1 this vehicle uses a Special Multi-plex Type Door Locking System that will require (4) extra
Relays Part #775, to do the Door Locks, NOTE *2 The PCM (Power Control Module) is located on
the DRVERS SDE of the ENGNE. The 4.2L engine TACH wire is in a BLUE Plug, Pin49. On the
5.3L engine the PCM is on the LOWER front drivers side of engine, TACH wire is in a GREEN Plug,
Pin 10. NOTE *3 MPORTANT !!!!! this wire MUST BE CONNECTED as GNTON #2 for REMOTE
STARTNG!!!!!! NOTE *4 The BCM is attached to the FUSEBOX, under the LEFT REAR SEAT.




This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 14 of 90

ENVOY XUV 2004 -2005



KEY
T-
HARNESS
MMOBLZER
N/A N/A GM's PASSLOCK 2 ANT-THEFT System, Requires Bypass Module

FUNCTON COLOR LOCATON
12 VOLT CONSTANT RED (+) and RED/WHTE (+) GNTON SWTCH HARNESS
STARTER YELLOW (+) GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 PNK (+) GNTON SWTCH HARNESS
GNTON 2 WHTE (+) See NOTE *4 GNTON SWTCH HARNESS
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
ORANGE (+) GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE LGHT GREEN (-)
@ BCM, TAN Plug, Pin E3, See
NOTE *3
PARKNG LGHTS ( - ) GRAY/BLACK (-)
@ BCM,TAN plug, Pin E5, See
NOTE *3
PARKNG LGHTS ( + ) BROWN (+)
@ FUSEBOX UNDER
DRVERS REAR SEAT
POWER LOCK See NOTE *1 S
POWER UNLOCK See NOTE *1 S
DOOR TRGGER GRAY/BLACK (+)
@ FUSEBOX UNDER
DRVERS REAR SEAT
DOMELGHT SUPERVSON TURNS ON WTH DSARM
TRUNK RELEASE N/A
SLDNG POWER DOOR N/A

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 15 of 90

HORN BLACK/YELLOW to BLACK (-)


@ BCM, TAN Plug, Pin E12,
See NOTE *3
TACH WHTE @ PCM, See NOTE *2
WAT TO START LGHT N/A
BRAKE WHTE (+)
@ SWTCH ABOVE BRAKE
PEDAL
FACTORY ALARM DSARM LGHT GREEN (-)
@ DRVER DOOR MODULE in
DRVERS DOOR.
ANT-THEFT
YELLOW (+), BLACK (-) and
RED/WHTE (Not Used)
GM's PASSLOCK 2 System,
these wires exit the gnition
Switch Tumbler together and
are in the Main gnition Switch
Harness in the Column.

EXTRA NFORMATON
NOTE *1 this vehicle uses a Special Multi-plex Type Door Locking System that will require (4) extra
Relays Part #775, to do the Door Locks, NOTE *2 The PCM (Power Control Module) is located on
the DRVERS SDE of the ENGNE. The 4.2L engine TACH wire is in a BLUE Plug, Pin49. On the
5.3L engine the PCM is on the LOWER front drivers side of engine, TACH wire is in a GREEN Plug,
Pin 10. NOTE *3 The BCM (Body Control Module) is attached to the FUSEBOX UNDER the
DRVERS SDE REAR SEAT. NOTE *4 MPORTANT !!!!! this wire MUST BE CONNECTED as
GNTON #2 for REMOTE STARTNG!!!!!!


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 16 of 90

Make: Model: Year:
GMC FuIIsize Jimmy 1978-1986


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS (HEAT/AC)
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: WHTE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE AT DSTRBUTOR *
Parking Lights: BROWN (+) AT LGHT SWTCH
Headlights: YELLOW (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Carburated Engine. ** See Note #300 - GM Rear Wheel Drive Vehicles

GMC FuIIsize Jimmy 1978-1986

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
WHTE (-) AT PN SWTCH
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: LGHT BLUE DRVER'S KCK OR BELOW SPEAKER ***
Power Unlock: BLACK/WHTE DRVER'S KCK OR BELOW SPEAKER ***
Trunk Release: N/A
Alarm nput Wire: WHTE (-) AT PN SWTCH

NOTES: *** See Note #202 - Positive Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 17 of 90

Make: Model: Year:
GMC FuIIsize Jimmy 1987


FUNCTON COLOR LOCATON
Start: PURPLE OR YELLOW YELLOW - MANUAL TRANSMSSON
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS (HEAT/AC)
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: WHTE/LGHT BLUE (+) AT SWTCH ABOVE BRAKE PREDAL
Tach Signal: WHTE AT DSTRBUTOR OR TEST CONNECTOR *
Parking Lights: BROWN (+) AT LGHT SWTCH
Headlights: YELLOW (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Throttle Body njection Engine. ** See Note #300 - GM Rear Wheel Drive Vehicles

GMC FuIIsize Jimmy 1987

FUNCTON COLOR LOCATON
Constant +12 Volts: RED AND RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
WHTE (-) AT PN SWTCH
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: LGHT BLUE DRVER'S KCK OR BELOW SPEAKER ***
Power Unlock: BLACK/WHTE DRVER'S KCK OR BELOW SPEAKER ***
Trunk Release: N/A
Alarm nput Wire: WHTE (-) AT PN SWTCH

NOTES: *** See Note #202 - Positive Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 18 of 90

Make: Model: Year:
GMC FuIIsize Jimmy 1988-1991


FUNCTON COLOR LOCATON
Start: PURPLE OR YELLOW GNTON SWTCH HARNESS **
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS (HEAT-A/C)
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
(RADO/WPER)
Brake Light: WHTE AT SWTCH ON BRAKE PEDAL BRACKET
Tach Signal: WHTE AT DSTRBUTOR OR TEST CONNECTOR *
Parking Lights: BROWN (+) AT LGHT SWTCH
Headlights: YELLOW (+) HEADLGHT SWTCH OR BEAM SELECT
SW.
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Throttle Body njection Engine. ** See Note #300 - GM Rear Wheel Drive Vehicles

GMC FuIIsize Jimmy 1988-1991

FUNCTON COLOR LOCATON
Constant +12 Volts: RED AND RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
WHTE (-) PN SWTCH OR AT COURTESY LGHT
OEM Horn: BLACK STEERNG COLUMN HARNESS
Power Lock: LGHT BLUE DRVER'S KCK OR BELOW SPEAKER ***
Power Unlock: BLACK/WHTE OR
BLK/RED
DRVER'S KCK OR BELOW SPEAKER ***
Trunk Release: BROWN (+) AT RELEASE SWTCH
Alarm nput Wire: WHTE (-) PN SWTCH OR AT COURTESY LGHT

NOTES: *** See Note #203 - Reverse Polarity Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 19 of 90

Make: Model: Year:
GMC FuII Size Pickup 1981-1986


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS **
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS (HEAT/AC)
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: WHTE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE AT DSTRBUTOR *
Parking Lights: BROWN (+) AT LGHT SWTCH
Headlights: YELLOW (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Carburated Engine. ** See Note #300 - GM Rear Wheel Drive Vehicles

GMC FuII Size Pickup 1981-1986

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
WHTE (-) AT PN SWTCH
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: LGHT BLUE DRVER'S KCK OR BELOW SPEAKER ***
Power Unlock: BLACK/WHTE DRVER'S KCK OR BELOW SPEAKER ***
Trunk Release: N/A
Alarm nput Wire: WHTE (-) AT PN SWTCH

NOTES: ** Some vehicles are positive trigger, some are reverse polarity. Must test. See Note
#202 - Positive Pulse Door Lock Diagram. See also Note #203.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 20 of 90

Make: Model: Year:
GMC FuII Size Pickup 1987


FUNCTON COLOR LOCATON
Start: PURPLE OR YELLOW GNTON SWTCH HARNESS **
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS (HEAT/AC)
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: WHTE (+) (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE AT DSTRBUTOR OR TEST CONNECTOR *
Parking Lights: BROWN (+) AT LGHT SWTCH
Headlights: YELLOW (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Throttle Body njection. ** See Note #300 - GM Rear Wheel Drive Vehicles

GMC FuII Size Pickup 1987

FUNCTON COLOR LOCATON
Constant +12 Volts: RED AND RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
WHTE (-) AT PN SWTCH
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: LGHT BLUE DRVER'S KCK OR BELOW SPEAKER ***
Power Unlock: BLACK/WHTE DRVER'S KCK OR BELOW SPEAKER ***
Trunk Release: N/A
Alarm nput Wire: WHTE (-) AT PN SWTCH

NOTES: *** See Note #202 - Positive Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 21 of 90

Make: Model: Year:
GMC FuII Size Pickup 1988-1991


FUNCTON COLOR LOCATON
Start: PURPLE OR YELLOW GNTON SWTCH HARNESS *
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS (HEAT-A/C)
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
(RADO/WPER)
Brake Light: WHTE AT SWTCH ON BRAKE PEDAL BRACKET
Tach Signal: WHTE AT DSTRBUTOR OR GNTON COL
Parking Lights: BROWN (+) AT LGHT SWTCH
Headlights: YELLOW (+) HEADLGHT SWTCH OR BEAM SELECT
SW.
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * See Note #300 - GM Rear Wheel Drive Vehicles

GMC FuII Size Pickup 1988-1991

FUNCTON COLOR LOCATON
Constant +12 Volts: RED AND RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
WHTE (-) PN SWTCH OR AT COURTESY LGHT
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS OR AT
RELAY
Power Lock: L BLUE DRVER'S KCK OR BELOW SPEAKER **
Power Unlock: BLACK/WHTE DRVER'S KCK OR BELOW SPEAKER **
Trunk Release: N/A
Alarm nput Wire: WHTE (-) PN SWTCH OR AT COURTESY LGHT

NOTES: ** See Note #203 - Reverse Polarity Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 22 of 90

Make: Model: Year:
GMC FuII Size Pickup 1992-1994


FUNCTON COLOR LOCATON
Start: PURPLE OR YELLOW GNTON SWTCH HARNESS **
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS (HEAT-A/C)
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
(RADO/WPER)
Brake Light: WHTE (+) AT SWTCH ON BRAKE PEDAL BRACKET
Tach Signal: WHTE AT DSTRBUTOR OR COL *
Parking Lights: BROWN (+) AT LGHT SWTCH
Headlights: YELLOW (+) HEADLGHT SWTCH OR BEAM SELECT
SW.
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Can Also Be Found n A Single Wire Test Connector Which s Taped To Harness
Near Distributor. ** See Note #300 - GM Rear Wheel Drive Vehicles

GMC FuII Size Pickup 1992-1994

FUNCTON COLOR LOCATON
Constant +12 Volts: RED AND RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
WHTE (-) PN SWTCH OR AT COURTESY LGHT
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS OR AT
RELAY
Power Lock: L BLUE DRVER'S KCK OR BELOW SPEAKER ***
Power Unlock: BLACK/WHTE DRVER'S KCK OR BELOW SPEAKER ***
Trunk Release: N/A
Alarm nput Wire: WHTE (-) PN SWTCH OR AT COURTESY LGHT

NOTES: *** See Note #203 - Reverse Polarity Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 23 of 90

Make: Model: Year:
GMC FuII Size Pickup 1995


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS *
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: PNK/WHTE OR WHTE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: ORANGE GNTON SWTCH HARNESS (HEAT/AC)
Brake Light: WHTE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal:
WHTE OR
PURPLE/WHTE
AT DSTRBUTOR
Parking Lights: BROWN (+) AT HEADLGHT SWTCH
Headlights: YELLOW (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * See Note #300 - GM Rear Wheel Drive Vehicles

GMC FuII Size Pickup 1995

FUNCTON COLOR LOCATON
Constant +12 Volts: RED AND RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
WHTE (-) ETHER PN SWTCH OR COURTESY LGHT
**
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: LGHT BLUE DRVER'S KCK PANEL ***
Power Unlock: WHTE DRVER'S KCK PANEL ***
Trunk Release: BLACK (+) AT RELEASE SWTCH
Alarm nput Wire: WHTE (-) ETHER PN SWTCH OR COURTESY LGHT
**

NOTES: ** f Equipped With Auxillary Lighting Option, Use PURPLE (-) At Any Pin Switch Or
Dome Lamp Override Switch. Will Trigger Alarm Regardless f Dome Light s Turned Off. **
Without OEM Keyless See Note #203 - Reverse Polarity Door Lock Diagram., With OEM Keyless
See Note #202 - Positive Pulse Door Lock Diagram.



This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 24 of 90
Make: Model: Year:
GMC FuII Size Pickup 1996-1998


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS *
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: PNK/WHTE OR WHTE GNTON SWTCH HARNESS(ECM)
gnition #3: N/A
Accessory: ORANGE GNTON SWTCH HARNESS (HEAT/AC)
Brake Light: WHTE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE
AT COL ON PASSENGER REAR OF
ENGNE
Parking Lights: BROWN (+) AT HEADLGHT SWTCH
Headlights: YELLOW (+) AT HEALGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * 1998+ Vehicle is equipped with PASSLOCK Anti-theft system. See Note #113 -
Bypassing PASSLOCK Theft Deterrent System Diagram.

GMC FuII Size Pickup 1996-1998

FUNCTON COLOR LOCATON
Constant +12 Volts: RED (2) GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A N SCHEMATCS
Dome
Lights/Superv:
PURPLE (-) 4 PN BLACK CONN. N DR. KCK PANEL **
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: L BLUE DRVER'S KCK PANEL ***
Power Unlock: WHTE DRVER'S KCK PANEL ***
Trunk Release: N/A
Alarm nput Wire: PURPLE (-) 4 PN BLACK CONN. N DR. KCK PANEL **

NOTES: ** PURPLE (-) Wire Also Located At Headlight Switch. WHTE (-) Wire At Courtesy
Light Can Also Be Used But Will Not Trigger Alarm f Dome Lamp Override Switch s Turned On.
*** Without OEM Keyless See Note #203 - Reverse Polarity Door Lock Diagram. With OEM
Keyless See Note #202 - Positive Pulse Door Lock Diagram



This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 25 of 90

FULL SIZE PICKUP (NEW BODY STYLE) 1999 -2002



KEY
T-
HARNESS
MMOBLZER
N/A GM-11 GM's PASSLOCK 2 ANT-THEFT System, Requires Bypass Module

FUNCTON COLOR LOCATON
12 VOLT CONSTANT RED (+) GNTON SWTCH HARNESS
STARTER YELLOW (+) GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 PNK (+) GNTON SWTCH HARNESS
GNTON 2 WHTE (+) See NOTE *6 GNTON SWTCH HARNESS
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
ORANGE (+) GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE N/A
PARKNG LGHTS ( - ) WHTE (-)
@ BCM, LGHT BLUE Plug,
See NOTE *1
PARKNG LGHTS ( + ) BROWN (+)
@ BCM, LGHT BLUE Plug,
See NOTE *1
POWER LOCK LGHT BLUE (TYPE A)
@ BCM, BROWN Plug, See
NOTE *1
POWER UNLOCK WHTE (TYPE A)
@ BCM, BROWN Plug, See
NOTE *1
DOOR TRGGER See NOTE *2 @ BCM, See NOTE *1
DOMELGHT SUPERVSON TAN (-)
@ BCM, PURPLE Plug, Pin B4,
See NOTE *1
TRUNK RELEASE N/A
SLDNG POWER DOOR N/A

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 26 of 90

HORN BLACK (-)


@ BCM, BROWN plug, See
NOTE *1
TACH WHTE See NOTE *4 @ ECM, See NOTE *3
WAT TO START LGHT See NOTE *5
BRAKE WHTE (+)
@ SWTCH ABOVE BRAKE
PEDAL
FACTORY ALARM DSARM LGHT GREEN (-) N DRVERS KCK PANEL
ANT-THEFT
YELLOW (+), ORANGE/BLACK
(-) and RED/WHTE (Not used)
GM's PASSLOCK 2 System,
these wires exit the gnition
Switch Tumbler together and
are in the Main gnition Switch
Harness in the Column.

EXTRA NFORMATON
NOTE *1 The BCM (Body Control Module) is located behind the drivers side of dash. The plugs on
the BCM face the rear of the vehicle. NOTE *2 At the BCM the DRVER DOOR is a TAN (-) Pin B4 of
the PURPLE PLUG, the PASSENGER DOOR is a ORANGE (-) Pin B2. When connecting to an
ALARM SYSTEM, use both Door Trigger wires and DODE SOLATE. to connect, NOTE *3 The
ECM (Engine Control Module) is located near the battery and down low between the fender and fan
under a BLACK plastic cover. On the 4.3L engine the TACH wire in at Pin 20 in the connector marked
"RED" On the 4.8L, 5.3L and 6.0L engines, it is located at Pin10 in the RED connector. NOTE *4 THE
DESEL TACH wire is also a WHTE but at the nstrument Cluster. NOTE *5 when hooking up a
remote starter, if you cannot get the (+) or (-) Wait to Start wire on the Remote Starter to work
properly, you will then need to disconnect this wire and Program the Remote Starter for the 5, 10, 15
or 20 Second Wait to Start Timmer in the nstallation manual. NOTE *6 MPORTANT !!!!! this wire
MUST BE CONNECTED as GNTON #2 for REMOTE STARTNG!!!!!!



This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 27 of 90

FULL SIZE PICKUP (NEW BODY STYLE) 2003 -2006



KEY
T-
HARNESS
MMOBLZER
N/A GM-12 GM's PASSLOCK 2 ANT-THEFT System, Requires Bypass Module

FUNCTON COLOR LOCATON
12 VOLT CONSTANT RED (+) GNTON SWTCH HARNESS
STARTER YELLOW (+) GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 PNK (+) GNTON SWTCH HARNESS
GNTON 2 WHTE (+) See NOTE *6 GNTON SWTCH HARNESS
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
ORANGE (+) GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE N/A
PARKNG LGHTS ( - ) GRAY/BLACK (-)
@ BCM, BROWN Plug, Pin B2,
See NOTE *1
PARKNG LGHTS ( + ) BROWN (+) N DRVERS KCK PANEL
POWER LOCK See NOTE *4 S
POWER UNLOCK See NOTE *4 See DAGRAMS
DOOR TRGGER
GRAY/BLACK (-) DRVERS and
BLACK/WHTE (-)
PASSENGER, Use both, See
NOTE * 2
@ EACH DOOR MODULE in
EACH DOOR
DOMELGHT SUPERVSON GRAY/BLACK (-)
@ BCM, BLACK Plug PN F,
See NOTE *1
TRUNK RELEASE N/A
SLDNG POWER DOOR N/A

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 28 of 90

HORN BLACK/YELLOW to BLACK (-)


@ STEERNG COLUMN
HARNESS
TACH WHTE
@ PCM, GREEN PLUG PN 36,
See NOTE *3
WAT TO START LGHT DARK BLUE (-) See NOTE *5 @ PCM, See NOTE *3
BRAKE WHTE (+)
@ SWTCH ABOVE BRAKE
PEDAL
FACTORY ALARM DSARM LGHT GREEN (-)
N DRVERS DOOR MODULE
in DRVERS DOOR
ANT-THEFT
YELLOW (+), BLACK (-) and
RED/WHTE (Not Used)
GM's PASSLOCK 2 System,
these wires exit the gnition
Switch Tumbler together and
are in the Main gnition Switch
Harness in the Column.

EXTRA NFORMATON
NOTE *1 The BCM (Body Control Module) is located UNDER the drivers side of dash. The unit has
(6) plugs on it with the PUPRLE Plug on the back of the unit. NOTE *2 on the BASE model trucks the
wires are in the LGHT BLUE PLUG at the BCM, PNS B4 and B5. On the 4 door trucks the
DRVERS REAR door is a LGHT BLUE/BLACK (-) PN A3 and the PASSENGERS REAR DOOR is a
LGHT GREEN/BLACK (-) PN A2 these wires are in the the PURPLE PLUG at the BCM. NOTE *3
The PCM (Powertrain Control Module) is located in the LEFT FRONT of the engine compartment to
the left of the fan shroud. On DESELS the TACH wire is at the GRAY PLUG, PN 37 and on the
hybrid models the tach wire is in a GREEN PLUG PN 35 NOTE *4 this vehicle uses a Special Multi-
plex Type Door Locking System that will require (4)Extra Relays Part #775, to do the Door Locks,
NOTE *5 when hooking up a remote starter, if you cannot get the (+) or (-) Wait to Start wire on the
Remote Starter to work properly, you will then need to disconnect this wire and Program the Remote
Starter for the 5, 10, 15 or 20 Second Wait to Start Timmer in the nstallation manual. NOTE *6
MPORTANT !!!!! this wire MUST BE CONNECTED as GNTON #2 for REMOTE STARTNG!!!!!!



This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 29 of 90

FULL SIZE PICKUP (OLD BODY STYLE) 1999 -2000



KEY
T-
HARNESS
MMOBLZER
N/A GM-1 GM's PASSLOCK 2 ANT-THEFT System, Requires Bypass Module

FUNCTON COLOR LOCATON
12 VOLT CONSTANT RED (+) GNTON SWTCH HARNESS
STARTER YELLOW (+) or PURPLE (+) GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 PNK (+) GNTON SWTCH HARNESS
GNTON 2 WHTE (+) See NOTE *6 GNTON SWTCH HARNESS
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
ORANGE (+) GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE N/A
PARKNG LGHTS ( - ) N/A
PARKNG LGHTS ( + ) BROWN (+)
@ HEADLGHT SWTCH or
FUSE PANEL
POWER LOCK
LGHT BLUE (TYPE C) See
NOTE *1
N ETHER DOOR BOOT
POWER UNLOCK WHTE (TYPE C) See NOTE *1 N ETHER DOOR BOOT
DOOR TRGGER See NOTE * 2
@ BCM, BEHND the DRVERS
SDE of DASH
DOMELGHT SUPERVSON TAN (-)
@ BCM, BEHND dirvers SDE
OF dash
TRUNK RELEASE N/A
SLDNG POWER DOOR N/A
HORN BLACK (-)
@ STEERNG COLUMN
HARNESS
TACH WHTE, See NOTE *4 @ ECM, See NOTE *3

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 30 of 90
WAT TO START LGHT DARK BLUE (-) See NOTE *5 @ NSTRUMENT CLUSTER
BRAKE WHTE (+)
@ SWTCH ABOVE BRAKE
PEDAL
FACTORY ALARM DSARM N/A
ANT-THEFT
YELLOW (+), ORANGE/BLACK
(-) and RED/WHTE (Not used)
GM's PASSLOCK 2 System,
these wires exit the gnition
Switch Tumbler together and
are in the Main gnition Switch
Harness in the Column.

EXTRA NFORMATON
NOTE *1 if vehicle is a 2-Door it is a TYPE C door lock system, if vehicle is a 4-Door or if it has a
FACOTRY KEYLESS ENTRY System it is a TYPE A door lock system. NOTE *2 At the BCM the
DRVER DOOR is a TAN (-) Pin B4 of the PURPLE PLUG, the PASSENGER DOOR is a ORANGE (-
) Pin B2. When connecting to an alarm system use both wires and DODE SOLATE. NOTE *3 the
ECM is located on the DRVERS SDE inner fender, with 2 plugs, look for the WHTE wire in the plug
labled "WHTE" NOTE *4 THE DESEL TACH wire is also a WHTE but at the nstrument cluster.
NOTE *5 when hooking up a remote starter, if you cannot get the (+) or (-) Wait to Start wire on the
Remote Starter to work properly, you will then need to disconnect this wire and Program the Remote
Starter for the 5, 10, 15 or 20 Second Wait to Start Timmer in the nstallation manual. NOTE *6
MPORTANT !!!!! this wire MUST BE CONNECTED as GNTON #2 for REMOTE STARTNG!!!!!!


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 31 of 90

Make: Model: Year:
GMC FuIIsize Van (see Savana 2003+) 1983-1984


FUNCTON COLOR LOCATON
Start: YELLOW OR PURPLE GNTON SWTCH HARNESS **
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS (HEAT-A/C)
***
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: WHTE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE AT DSTRBUTOR *
Parking Lights: BROWN (+) AT LGHT SWTCH
Headlights: YELLOW (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Carburated Engine. ** See Note #300 - GM Rear Wheel Drive Vehicles *** See Note
#233 - High Current gnition Wires Diagram.

GMC FuIIsize Van (see Savana 2003+) 1983-1984

FUNCTON COLOR LOCATON
Constant +12 Volts: RED AND RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
WHTE (-) AT PN SWTCH
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: L BLUE OR D GRN/YEL DRVER'S KCK PANEL ****
Power Unlock: BLACK/WHTE DRVER'S KCK PANEL ****
Trunk Release: N/A
Alarm nput Wire: WHTE (-) AT PN SWTCH

NOTES: **** See Note #202 - Positive Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 32 of 90

Make: Model: Year:
GMC FuIIsize Van (see Savana 2003+) 1985-1986


FUNCTON COLOR LOCATON
Start: YELLOW OR PURPLE GNTON SWTCH HARNESS **
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS (HEAT-A/C)
***
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: WHTE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE AT DSTRBUTOR *
Parking Lights: BROWN (+) AT LGHT SWTCH
Headlights: YELLOW (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Carburated Engine. ** See Note #300 - GM Rear Wheel Drive Vehicles *** See Note
#233 - High Current gnition Wires Diagram.

GMC FuIIsize Van (see Savana 2003+) 1985-1986

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
WHTE (-) AT PN SWTCH
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: LGHT BLUE DRVER'S KCK PANEL ****
Power Unlock: BLACK/WHTE DRVER'S KCK PANEL ****
Trunk Release: N/A
Alarm nput Wire: WHTE (-) AT PN SWTCH

NOTES: **** See Note #202 - Positive Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 33 of 90

Make: Model: Year:
GMC FuIIsize Van (see Savana 2003+) 1985-1986


FUNCTON COLOR LOCATON
Start: YELLOW OR PURPLE GNTON SWTCH HARNESS **
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS (HEAT-A/C)
***
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: WHTE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE AT DSTRBUTOR *
Parking Lights: BROWN (+) AT LGHT SWTCH
Headlights: YELLOW (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Carburated Engine. ** See Note #300 - GM Rear Wheel Drive Vehicles *** See Note
#233 - High Current gnition Wires Diagram.

GMC FuIIsize Van (see Savana 2003+) 1985-1986

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
WHTE (-) AT PN SWTCH
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: LGHT BLUE DRVER'S KCK PANEL ****
Power Unlock: BLACK/WHTE DRVER'S KCK PANEL ****
Trunk Release: N/A
Alarm nput Wire: WHTE (-) AT PN SWTCH

NOTES: **** See Note #202 - Positive Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 34 of 90

Make: Model: Year:
GMC FuIIsize Van (see Savana 2003+) 1987-1994


FUNCTON COLOR LOCATON
Start: PURPLE OR YELLOW GNTON SWTCH HARNESS **
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS (HEAT-A/C)
***
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: WHTE (+) SWTCH ON BRAKE PEDAL SUPPORT
BRACKET
Tach Signal: WHTE AT COL OR DSTRBUTOR *
Parking Lights: BROWN (+) AT LGHT SWTCH
Headlights: YELLOW (+) HEADLGHT SWTCH OR BEAM SELECT
SW.
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Throttle Body njection. ** See Note #300 - GM Rear Wheel Drive Vehicles *** See
Note #233 - High Current gnition Wires Diagram.

GMC FuIIsize Van (see Savana 2003+) 1987-1994

FUNCTON COLOR LOCATON
Constant +12 Volts: RED AND RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
WHTE SAME CRCUT AS FRONT DOORS
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS OR AT
RELAY
Power Lock: LGHT BLUE DRVER'S KCK PANEL ****
Power Unlock: BLACK/WHTE DRVER'S KCK PANEL ****
Trunk Release: N/A
Alarm nput Wire: WHTE SAME CRCUT AS FRONT DOORS

NOTES: **** See Note #202 - Positive Pulse Door Lock Diagram.



This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 35 of 90
Make: Model: Year:
GMC FuIIsize Van (see Savana 2003+) 1995


FUNCTON COLOR LOCATON
Start: VOLET GNTON SWTCH HARNESS **
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS (HEAT-A/C)
***
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: WHTE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE AT DSTRBUTOR *
Parking Lights: BROWN (+) AT HEADLGHT SWTCH
Headlights: YELLOW (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * All Models Are Throttle Body njection. ** See Note #300 - GM Rear Wheel Drive
Vehicles *** See Note #233 - High Current gnition Wires Diagram.

GMC FuIIsize Van (see Savana 2003+) 1995

FUNCTON COLOR LOCATON
Constant +12 Volts: RED AND RED GNTON SW.HARNESS (BOTH 1 CRCUT)
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
WHTE (-) AT ETHER PN SWTCH
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: LGHT BLUE AT DOOR LOCK RELAY MODULE BEHND
Power Unlock: BLACK RGHT SDE OF STEERNG COLUMN ****
Trunk Release: N/A
Alarm nput Wire: WHTE (-) AT ETHER PN SWTCH

NOTES: **** See Note #202 - Positive Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 36 of 90

Make: Model: Year:
GMC FuIIsize Van (see Savana 2003+) 1996-2002


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS **
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: WHTE GNTON SWTCH HARNESS (ECM)
gnition #3: N/A
Accessory: ORANGE GNTON SWTCH HARNESS (HEAT/AC) ***
Brake Light: WHTE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE AT GNTON COL *
Parking Lights: BROWN (+) AT HEADLGHT SWTCH
Headlights: YELLOW (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * WHTE Wire Located At gnition Coil On Passenger Front Of Engine. ** 1998 Vehicles
Are Equipped With GM's PASSLOCK Anti-Theft System; See Note #113. *** See Note #233 -
High Current gnition Wires Diagram.

GMC FuIIsize Van (see Savana 2003+) 1996-2002

FUNCTON COLOR LOCATON
Constant +12 Volts: RED & RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A N SCHEMATCS
Dome
Lights/Superv:
PURPLE (-) 10 PN CONN. N PASS. KCK PANEL****
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: L BLUE DRVER'S KCK PANEL *****
Power Unlock: WHTE DRVER'S KCK PANEL *****
Trunk Release: BLACK (+) AT OEM KEYLESS MODULE
Alarm nput Wire: PURPLE (-) 10 PN CONN. N PASS. KCK PANEL****

NOTES: **** PURPLE (-) Wire Can Be Accessed At Any Pin Switch, Rear Door On Same Circuit
As Front Doors. ***** See Note #202 - Positive Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 37 of 90

Make: Model: Year:
GMC Jimmy 1995-1998


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS **
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: PNK/WHTE OR WHTE GNTON SWTCH HARNESS ***
gnition #3: N/A
Accessory: ORANGE GNTON SWTCH HARNESS (HEAT/AC)
Brake Light: WHTE (+) AT SWTCH BAOVE BRAKE PEDAL
Tach Signal: WHTE AT GNTON COL *
Parking Lights: BROWN (+) AT HEADLGHT SWTCH
Headlights: YELLOW (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * WHT/BLK At Distributor gnition Module Can Also Be Used For Tach.gnition Coil And
Distributor Module Both Located On Passenger Side Of Engine. ** 1998+ Vehicle is equipped
with PASSLOCK Anti-theft system. See Note #113 - Bypassing PASSLOCK Theft Deterrent
System Diagram. *** This Wire Powers the PCM in the Vehicle and Must Be Active in Both ""
Start"" and ""Run"".

GMC Jimmy 1995-1998

FUNCTON COLOR LOCATON
Constant +12 Volts: RED (2) GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A N SCHEMATCS
Dome
Lights/Superv:
WHTE (-) AT PN SWTCH OR COURTESY LGHT
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: L BLUE DRVER'S KCK PANEL ****
Power Unlock: WHTE DRVER'S KCK PANEL ****
Trunk Release: BLACK/WHTE (+) AT TRUNK RELEASE SWTCH
Alarm nput Wire: WHTE (-) AT PN SWTCH OR COURTESY LGHT

NOTES: **** See Note #202 - Positive Pulse Door Lock Diagram.



This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 38 of 90
Make: Model: Year:
GMC Jimmy 1999-2001


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS **
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: WHTE GNTON SWTCH HARNESS ***
gnition #3: N/A
Accessory: ORANGE GNTON SWTCH HARNESS (HEAT/AC)
Brake Light: WHTE (+) AT SWTCH BAOVE BRAKE PEDAL
Tach Signal: WHTE AT GNTON COL *
Parking Lights: LT. BLUE (+) AT HEADLGHT SWTCH
Headlights: YELLOW (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * WHT/BLK At Distributor gnition Module Can Also Be Used For Tach.gnition Coil And
Distributor Module Both Located On Passenger Side Of Engine. ** 1998+ Vehicle is equipped
with PASSLOCK Anti-theft system. See Note #113 - Bypassing PASSLOCK Theft Deterrent
System Diagram. *** This Wire Powers the PCM in the Vehicle and Must Be Active in Both ""
Start"" and ""Run"".

GMC Jimmy 1999-2001

FUNCTON COLOR LOCATON
Constant +12 Volts: RED (2) GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A SEE NOTES *****
Dome
Lights/Superv:
WHTE (-) AT PN SWTCH OR COURTESY LGHT
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: L BLUE 76 PN CONN. ABOVE DRVER'S KCK ****
Power Unlock: WHTE 76 PN CONN. ABOVE DRVER'S KCK ****
Trunk Release: BLACK/WHTE (+) AT TRUNK RELEASE SWTCH
Alarm nput Wire: WHTE (-) AT PN SWTCH OR COURTESY LGHT

NOTES: **** See Note #202 - Positive Pulse Door Lock Diagram. ***** Disarm requires a +12
Volt pulse to both gnition #1 and gnition #2 wires simultaneously. Use a relay.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 39 of 90

Make: Model: Year:
GMC S-15 Jimmy 1983-1985


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS **
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS (HEAT/AC)
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: WHTE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE AT DSTRBUTOR *
Parking Lights: BROWN (+) AT LGHT SWTCH
Headlights: YELLOW (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Carburated Engine. ** See Note #300 - GM Rear Wheel Drive Vehicles

GMC S-15 Jimmy 1983-1985

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
WHTE (-) AT PN SWTCH
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: LGHT BLUE DRVER'S KCK OR BELOW SPEAKER ***
Power Unlock: BLACK DRVER'S KCK OR BELOW SPEAKER ***
Trunk Release: BROWN (+) AT RELEASE SWTCH
Alarm nput Wire: WHTE (-) AT PN SWTCH

NOTES: *** See Note #203 - Reverse Polarity Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 40 of 90

Make: Model: Year:
GMC S-15 Jimmy 1986-1990


FUNCTON COLOR LOCATON
Start: PURPLE OR YELLOW GNTON SWTCH HARNESS
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS (HEAT/AC)
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: WHTE (+) SWTCH ON BRAKE PEDAL SUPPORT
BRACKET
Tach Signal: WHTE AT DSTRBUTOR *
Parking Lights: BROWN (+) AT HEADLGHT SWTCH
Headlights: YELLOW (+) HEADLGHT SWTCH OR BEAM SELECT
SW.
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Throttle Body njection Engine. ** See Note #300 - GM Rear Wheel Drive Vehicles

GMC S-15 Jimmy 1986-1990

FUNCTON COLOR LOCATON
Constant +12 Volts: RED AND RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
WHTE/BLACK OR
WHTE
(-) AT PN SWTCH OR COURTESY LGHT
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS OR AT
RELAY
Power Lock: LT BLUE DRVER'S KCK OR BELOW SPEAKER ***
Power Unlock: BLACK/WHTE OR
WHTE
DRVER'S KCK OR BELOW SPEAKER ***
Trunk Release: BROWN (+) AT REAR WNDOW RELEASE SWTCH
Alarm nput Wire: WHTE/BLACK OR
WHTE
(-) AT PN SWTCH OR COURTESY LGHT

NOTES: *** See Note #203 - Reverse Polarity Door Lock Diagram.



This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 41 of 90
Make: Model: Year:
GMC S-15 Jimmy 1991-1994


FUNCTON COLOR LOCATON
Start: PURPLE OR YELLOW GNTON SWTCH HARNESS **
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS (HEAT/AC)
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: WHTE (+) SWTCH ON BRAKE PEDAL SUPPORT
BRACKET
Tach Signal: WHTE AT DSTRBUTOR *
Parking Lights: BROWN (+) AT HEADLGHT SWTCH
Headlights: YELLOW (+) HEADLGHT SWTCH OR BEAM SELECT
SW.
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Throttle Body njection Engine. ** See Note #300 - GM Rear Wheel Drive Vehicles

GMC S-15 Jimmy 1991-1994

FUNCTON COLOR LOCATON
Constant +12 Volts: RED AND RED GNTON SWTCH HARNESS (1 CRCUT)
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
WHTE (-) DRVER PN SWTCH OR COURTESY
LGHT
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS OR AT
RELAY
Power Lock: LGHT BLUE DRVER'S KCK PANEL ***
Power Unlock: BLACK OR
BLACK/WHTE
DRVER'S KCK PANEL ***
Trunk Release: BROWN (+) AT REAR WNDOW RELEASE SWTCH
Alarm nput Wire: WHTE (-) DRVER PN SWTCH OR COURTESY
LGHT

NOTES: *** 2 Door Without OEM Keyless Entry See Note #203 - Reverse Polarity Door Lock
Diagram. 4 Door & 2 Door With OEM Keyless Entry See Note #202 - Positive Pulse Door Lock
Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 42 of 90

Make: Model: Year:
GMC S-15 Jimmy 1995


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS **
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS (ECM)
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS (HEAT/AC)
Brake Light: WHTE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE GNTON CONTROL MODULE (4 CYLD.) *
Parking Lights: BROWN (+) AT HEADLGHT SWTCH
Headlights: YELLOW (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * gnition Control Module Located On Lower Passenger Side Of Engine. 6 Cylinder
Engine (VN Z Throttle Body njection) WHTE Tach Wire At Distributor On Top Rear Of Engine.
** See Note #300 - GM Rear Wheel Drive Vehicles

GMC S-15 Jimmy 1995

FUNCTON COLOR LOCATON
Constant +12 Volts: RED AND RED GNTON SW.HARNESS (BOTH 1 CRCUT)
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
BLACK(-) @ PN
SWTCH
OR WHTE AT COURTESY LGHT
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: LGHT BLUE DRVER'S KCK PANEL ***
Power Unlock: WHTE DRVER'S KCK PANEL ***
Trunk Release: BLACK/WHTE (+) N CONN. DR. SDE OF STEER. COL.
Alarm nput Wire: BLACK(-) @ PN
SWTCH
OR WHTE AT COURTESY LGHT

NOTES: ** 2 Door Without OEM Keyless Entry See Note #203 - Reverse Polarity Door Lock
Diagram. 2 Door With OEM Keyless Entry See Note #202 - Positive Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 43 of 90

Make: Model: Year:
GMC S-15 Pickup 1982-1985


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS (HEAT/AC)
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: WHTE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE AT DSTRBUTOR *
Parking Lights: BROWN (+) AT LGHT SWTCH
Headlights: YELLOW (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Carburated Engine. ** See Note #300 - GM Rear Wheel Drive Vehicles

GMC S-15 Pickup 1982-1985

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
WHTE (-) AT PN SWTCH
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: LGHT BLUE DRVER KCK #203
Power Unlock: BLACK PANEL
Trunk Release: N/A
Alarm nput Wire: WHTE (-) AT PN SWTCH

NOTES: ** See Note #203 - Reverse Polarity Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 44 of 90

Make: Model: Year:
GMC S-15 Pickup 1986-1994


FUNCTON COLOR LOCATON
Start: YELLOW OR PURPLE GNTON SWTCH HARNESS **
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS (HEAT/AC)
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: WHTE (+) SWTCH ON BRAKE PEDAL SUPPORT
BRACKET
Tach Signal: WHTE AT DSTRBUTOR *
Parking Lights: BROWN (+) AT LGHT SWTCH
Headlights: YELLOW (+) HEADLGHT SWTCH OR BEAM SELECT
SW.
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Throttle Body njection. ** See Note #300 - GM Rear Wheel Drive Vehicles

GMC S-15 Pickup 1986-1994

FUNCTON COLOR LOCATON
Constant +12 Volts: RED AND RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
WHTE/BLACK OR
WHTE
(-) AT PN SWTCH
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS OR AT
RELAY
Power Lock: LT BLUE BEHND DRVER SPEAKER OR
Power Unlock: BLACK/WHTE OR
BLACK
N DRVER KCK PANEL
Trunk Release: N/A
Alarm nput Wire: WHTE/BLACK OR
WHTE
(-) AT PN SWTCH

NOTES: *** See Note #203 - Reverse Polarity Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 45 of 90

Make: Model: Year:
GMC Safari 1985-1987


FUNCTON COLOR LOCATON
Start: PURPLE-AUTOMATC
TRANS
GNTON SWTCH HARNESS **
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS (HEAT/AC)***
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: WHTE OR LGHT BLUE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE AT DSTRBUTOR OR AT COL *
Parking Lights: BROWN (+) AT LGHT SWTCH
Headlights: YELLOW (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * 1985 6 Cylinder Engine Carburated, Rest Are Throttle Body njection. ** See Note
#300 - GM Rear Wheel Drive Vehicles *** See Note #233 - High Current gnition Wires Diagram.

GMC Safari 1985-1987

FUNCTON COLOR LOCATON
Constant +12 Volts: RED AND RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
BLACK/ORANGE (-) AT PN SWTCH ****
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: LGHT BLUE DRVER'S KCK PANEL *****
Power Unlock: BLACK/WHTE DRVER'S KCK PANEL *****
Trunk Release: N/A
Alarm nput Wire: BLACK/ORANGE (-) AT PN SWTCH ****

NOTES: **** f Equipped With Auxillary Lighting Option, The Dome Lights Can Be Turned Off By
A Switch That nterrupts The Door Pin Circuit To The Courtesy Light. f Connection s Made At
This Switch, Use Diodes To solate, Cathode (Band) Faces OEM Wires. ***** See Note #203 -
Reverse Polarity Door Lock Diagram.



This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 46 of 90
Make: Model: Year:
GMC Safari 1987-1989


FUNCTON COLOR LOCATON
Start: PURPLE GNTON SWTCH HARNESS **
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS (HEAT/AC) ***
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: WHTE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE AT COL *
Parking Lights: BROWN (+) AT LGHT SWTCH
Headlights: YELLOW (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Carburated Engine. ** See Note #300 - GM Rear Wheel Drive Vehicles *** See Note
#233 - High Current gnition Wires Diagram.

GMC Safari 1987-1989

FUNCTON COLOR LOCATON
Constant +12 Volts: RED AND RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
WHTE (-) AT PN SWTCH OR COURTESY LGHT
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: LGHT BLUE DRVER'S KCK PANEL ****
Power Unlock: BLACK DRVER'S KCK PANEL ****
Trunk Release: N/A
Alarm nput Wire: WHTE (-) AT PN SWTCH OR COURTESY LGHT

NOTES: **** See Note #202 - Positive Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 47 of 90

Make: Model: Year:
GMC Safari 1988-1994


FUNCTON COLOR LOCATON
Start: PURPLE OR YELLOW GNTON SWTCH HARNESS **
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS (HEAT/AC) ***
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
(RADO/WPER)
Brake Light: WHTE AT SWTCH ON BRAKE PEDAL BRACKET
Tach Signal: WHTE AT DSTRBUTOR OR AT COL *
Parking Lights: BROWN (+) AT LGHT SWTCH
Headlights: YELLOW (+) HEADLGHT SWTCH OR BEAM SELECT
SW.
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Throttle Body njection Engine. ** See Note #300 - GM Rear Wheel Drive Vehicles ***
See Note #233 - High Current gnition Wires Diagram.

GMC Safari 1988-1994

FUNCTON COLOR LOCATON
Constant +12 Volts: RED OR RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
BLACK/ORANGE (-) AT PN SWTCH ****
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS OR AT
RELAY
Power Lock: LGHT BLUE DRVER'S KCK PANEL *****
Power Unlock: BLACK/WHTE OR
BLACK
DRVER'S KCK PANEL *****
Trunk Release: RED (+) AT RELEASE SWTCH
Alarm nput Wire: BLACK/ORANGE (-) AT PN SWTCH ****

NOTES: **** f Equipped With Auxillary Lighting Option, Dome Light Can Be Turned Off By A
Switch That nterrrupts The The Door Pin Circuit To The Courtesy Lights. f Connection s Made
At This Switch. ***** See Note #202 - Positive Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 48 of 90

Make: Model: Year:
GMC Safari 1995


FUNCTON COLOR LOCATON
Start: PURPLE OR YELLOW GNTON SWTCH HARNESS*
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS (HEAT/AC)**
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: WHTE (+)@ SWTCH ABOVE BRAKE PEDAL
BRACKET
Tach Signal: WHTE AT DSTRBUTOR
Parking Lights: BROWN (+) AT HEADLGHT SWTCH
Headlights: YELLOW (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * See Note #300 - GM Rear Wheel Drive Vehicles ** See Note #233 - High Current
gnition Wires Diagram.

GMC Safari 1995

FUNCTON COLOR LOCATON
Constant +12 Volts: RED AND RED GNTON SW. HARNESS (BOTH 1 CRCUT)
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
WHTE (-) AT DRVER PN SWTCH
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: LGHT BLUE DRVER'S KCK PANEL ***
Power Unlock: BLACK/WHTE DRVER'S KCK PANEL ***
Trunk Release: N/A
Alarm nput Wire: WHTE (-) AT DRVER PN SWTCH

NOTES: *** See Note #202 - Positive Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 49 of 90

Make: Model: Year:
GMC Safari 1996-2002


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS **
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: PNK/WHTE OR WHTE GNTON SWTCH HARNESS (ECM)
gnition #3: N/A
Accessory: ORANGE GNTON SWTCH HARNESS (HEAT/AC) ***
Brake Light: WHTE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE AT POWERTRAN CONTROL MODULE *
Parking Lights: BROWN (+) AT HEADLGHT SWTCH
Headlights: YELLOW (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * gnition Coil Located On Top Of Engine Behind Generator. ** 1998+ Vehicles Are
Equipped With GM's PASSLOCK Anti-Theft System; See Note #113 - Bypassing GM's
PASSLOCK Passive Theft System Diagram. ** See Note #233 - High Current gnition Wires
Diagram.

GMC Safari 1996-2002

FUNCTON COLOR LOCATON
Constant +12 Volts: RED (2) GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A N SCHEMATCS
Dome
Lights/Superv:
PURPLE (-) AT ANY PN SWTCH ****
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: L BLUE DRVER'S KCK PANEL ****
Power Unlock: WHTE DRVER'S KCK PANEL ****
Trunk Release: L GREEN (-) AT REAR WNDOW RELEASE SWTCH
Alarm nput Wire: PURPLE (-) AT ANY PN SWTCH ****

NOTES: **** WHTE (-) Wire At Courtesy Light Can Also Be Used For Door Trigger. ***** See
Note #202 - Positive Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 50 of 90

Make: Model: Year:
GMC Safari 2003-2005


FUNCTON COLOR LOCATON
Start: Yellow (+) gnition switch harness
gnition #1: Pink (+) gnition switch harness*
gnition #2: White (+) gnition switch harness
gnition #3: N/A gnition switch harness
Accessory: Orange (+) gnition switch harness
Brake Light: White (+) Brake pedal switch
Tach Signal: White (AC) At PCM below battery
Parking Lights: Brown (+) Drivers kick panel
Headlights: N/A
Diesel Glow Plug: N/A
Clutch Bypass Wire: N/A

NOTES: *This vehicle is equipped with GM's Passlock Anti-Theft security system. Use a
universal alarm bypass module.

GMC Safari 2003-2005

FUNCTON COLOR LOCATON
Constant +12 Volts: Red & Red/White (+) gnition switch harness
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
Gray/Black (-) Relay above diagnostic plug
OEM Horn: Black (-) Steering column harness
Power Lock: Lt.Blue (+) Drivers kick panel door harness**
Power Unlock: White (+) Drivers kick panel door harness
Trunk Release: Lt.Blue (-) Relay above diagnostic plug
Alarm nput Wire: Gray/Black (-) Relay above diagnostic plug

NOTES: ** See Note #202 Positive Door Lock Systems


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 51 of 90

Make: Model: Year:
GMC Savana Van 2003-2006


FUNCTON COLOR LOCATON
Start: Yellow (+) gnition switch harness
gnition #1: Pink (+) gnition switch harness*
gnition #2: White (+) gnition switch harness
gnition #3: N/A gnition switch harness
Accessory: Orange (+) gnition switch harness
Brake Light: White (+) Brake pedal switch
Tach Signal: White or Purple (AC) Green plug at the PCM**
Parking Lights: Brown (+) Fuse box under driver seat
Headlights: N/A
Diesel Glow Plug: N/A
Clutch Bypass Wire: N/A

NOTES: *This vehicle is equipped with GM's Passlock Anti-Theft Security System. Use a
universal alarm bypass module. **The Powertrain Control Module (PCM) is on the driver side
fender.

GMC Savana Van 2003-2006

FUNCTON COLOR LOCATON
Constant +12 Volts: Red/Black (x2) (+) gnition switch harness
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
Gray/Black or
Dk.Blue/White (+)
Black plug at BCM***
OEM Horn: Tan (-) Gray plug at BCM***
Power Lock: Lt.Blue (-) Lt.Blue plug at BCM***
Power Unlock: White (-) Lt.Blue plug at BCM***
Trunk Release: N/A
Alarm nput Wire: Gray/Black or
Dk.Blue/White (+)
Black plug at BCM***

NOTES: ***The Body Control Module (BCM) is under the passenger side dash, behind the knee
bolster.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 52 of 90

SIERRA 2003 -2006

KEY
T-
HARNESS
MMOBLZER
N/A GM-12 GM's PASSLOCK 2 ANT-THEFT System, Requires 791 Bypass Module

FUNCTON COLOR LOCATON
12 VOLT CONSTANT (2) RED (+) GNTON SWTCH HARNESS
STARTER YELLOW (+) GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 PNK (+) GNTON SWTCH HARNESS
GNTON 2 WHTE (+) See NOTE *6 GNTON SWTCH HARNESS
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
ORANGE (+) GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE N/A
PARKNG LGHTS ( - ) GRAY/BLACK (-)
@ BCM, BROWN Plug, Pin B2,
See NOTE *1
PARKNG LGHTS ( + ) BROWN (+) N DRVERS KCK PANEL
POWER LOCK See NOTE *4
POWER UNLOCK See NOTE *4
DOOR TRGGER
GRAY/BLACK (-) DRVERS and
BLACK/WHTE (-)
PASSENGER, Use both, See
NOTE * 2
@ EACH DOOR MODULE in
EACH DOOR
DOMELGHT SUPERVSON GRAY/BLACK (-)
@ BCM, BLACK Plug PN F,
See NOTE *1
TRUNK RELEASE N/A
SLDNG POWER DOOR N/A
HORN BLACK/YELLOW to BLACK (-)
@ STEERNG COLUMN
HARNESS

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 53 of 90
TACH WHTE
@ PCM, GREEN PLUG PN 36,
See NOTE *3
WAT TO START LGHT DARK BLUE (-) See NOTE *5 @ PCM, See NOTE *3
BRAKE WHTE (+)
@ SWTCH ABOVE BRAKE
PEDAL
FACTORY ALARM DSARM LGHT GREEN (-)
N DRVERS DOOR MODULE
in DRVERS DOOR
ANT-THEFT
YELLOW (+), BLACK (-) and
RED/WHTE (Not Used)
GM's PASSLOCK 2 System,
these wires exit the gnition
Switch Tumbler together and
are in the Main gnition Switch
Harness in the Column.

EXTRA NFORMATON
NOTE *1 The BCM (Body Control Module) is located UNDER the drivers side of dash. The unit has
(6) plugs on it with the PUPRLE Plug on the back of the unit. NOTE *2 on the BASE model trucks the
wires are in the LGHT BLUE PLUG at the BCM, PNS B4 and B5. On the 4 door trucks the
DRVERS REAR door is a LGHT BLUE/BLACK (-) PN A3 and the PASSENGERS REAR DOOR is a
LGHT GREEN/BLACK (-) PN A2 these wires are in the the PURPLE PLUG at the BCM. NOTE *3
The PCM (Powertrain Control Module) is located in the LEFT FRONT of the engine compartment to
the left of the fan shroud. On DESELS the TACH wire is at the GRAY PLUG, PN 37 and on the
hybrid models the tach wire is in a GREEN PLUG PN 35 NOTE *4 this vehicle uses a Special Multi-
plex Type Door Locking System that will require (4)Extra Relays to do the Door Locks. NOTE *5
when hooking up a remote starter, if you cannot get the (+) or (-) Wait to Start wire on the Remote
Starter to work properly, you will then need to disconnect this wire and Program the Remote Starter
for the 5, 10, 15 or 20 Second Wait to Start Timmer in the nstallation manual. NOTE *6 MPORTANT
!!!!! this wire MUST BE CONNECTED as GNTON #2 for REMOTE STARTNG!!!!!!

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 54 of 90

Make: Model: Year:
GMC Sonoma 1991-1993


FUNCTON COLOR LOCATON
Start: PURPLE OR YELLOW GNTON SWTCH HARNESS **
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS (HEAT/AC)
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: WHTE (+) SWTCH ON BRAKE PEDAL SUPPORT
BRACKET
Tach Signal: WHTE AT DSTRBUTOR *
Parking Lights: BROWN (+) AT HEADLGHT SWTCH
Headlights: YELLOW (+) HEADLGHT SWTCH OR BEAM SELECT
SW.
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Throttle Body njection. ** See Note #300 - GM Rear Wheel Drive Vehicles.

GMC Sonoma 1991-1993

FUNCTON COLOR LOCATON
Constant +12 Volts: RED AND RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
WHTE/BLACK OR
WHTE
(-) AT PN SWTCH OR COURTESY LGHT
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS OR AT
RELAY
Power Lock: LT BLUE DRVER'S KCK OR BELOW SPEAKER ***
Power Unlock: BLACK/WHTE OR
BLACK
DRVER'S KCK OR BELOW SPEAKER ***
Trunk Release: N/A
Alarm nput Wire: WHTE/BLACK OR
WHTE
(-) AT PN SWTCH OR COURTESY LGHT

NOTES: *** See Note #203 - Reverse Polarity Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 55 of 90

Make: Model: Year:
GMC Sonoma 1994


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS **
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS (HEAT/AC)
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: WHTE (+) SWTCH ON BRAKE PEDAL BRACKET
Tach Signal: WHTE AT DSTRBUTOR *
Parking Lights: BROWN (+) AT HEADLGHT SWTCH
Headlights: YELLOW (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Throttle Body njection. ** See Note #300 - GM Rear Wheel Drive Vehicles.

GMC Sonoma 1994

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
WHTE (-) DRVER KCK PANEL OR PN SWTCH
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS OR CHME
MOD.
Power Lock: LT BLUE DRVER'S KCK OR BELOW SPEAKER ***
Power Unlock: BLACK/WHTE OR
WHTE
DRVER'S KCK OR BELOW SPEAKER ***
Trunk Release: N/A
Alarm nput Wire: WHTE (-) DRVER KCK PANEL OR PN SWTCH

NOTES: *** See Note #203 - Reverse Polarity Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 56 of 90

Make: Model: Year:
GMC Sonoma 1995


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS **
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: PNK/WHTE OR WHTE GNTON SWTCH HARNESS (ECM)
gnition #3: N/A
Accessory: ORANGE GNTON SWTCH HARNESS (HEAT/AC)
Brake Light: WHTE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE GNTON CONTROL MODULE (4 CYLD.) *
Parking Lights: BROWN (+) AT HEADLGHT SWTCH
Headlights: YELLOW (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * gnition Control Module Located On Lower Passenger Side Of Engine. 6 Cylinder
Engine (VN Z Throttle Body njection) WHTE Tach Wire At Distributor On Top Rear Of Engine.
6 Cylinder (VN W Port Fuel njection) WHTE Tach Wire At gnition Control Module. ** See Note
#300 - GM Rear Wheel Drive Vehicles

GMC Sonoma 1995

FUNCTON COLOR LOCATON
Constant +12 Volts: RED AND RED GNTON SW.HARNESS (BOTH 1 CRCUT)
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
BLACK (-) PN SWTCH OR COURTESY LGHT
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: LGHT BLUE DRVER'S KCK PANEL ***
Power Unlock: WHTE DRVER'S KCK PANEL ***
Trunk Release: N/A
Alarm nput Wire: BLACK (-) PN SWTCH OR COURTESY LGHT

NOTES: *** Without OEM Keyless Entry See Note #203 - Reverse Polarity Door Lock Diagram.
With OEM Keyless Entry See Note #202 - Positive Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 57 of 90

Make: Model: Year:
GMC Sonoma 1996-2003


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS **
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: PNK/WHTE OR WHTE GNTON SWTCH HARNESS (ECM)
gnition #3: N/A
Accessory: ORANGE GNTON SWTCH HARNESS (HEAT/AC)
Brake Light: WHTE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE AT POWERTRAN CONTROL MODULE *
Parking Lights: BROWN (+) AT HEADLGHT SWTCH
Headlights: YELLOW (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * WHT/BLK At Distributor gnition Module Can Also Be Used For Tach. gnition Coil And
Distributor Module Both Located On Passenger Side Of Engine. ** 1998+ Vehicle is equipped
with PASSLOCK Anti-theft system. See Note #113 - Bypassing PASSLOCK Theft Deterrent
System Diagram. *** This Wire Powers the PCM in the Vehicle and Must Be Active in Both ""
Start"" and ""Run"".

GMC Sonoma 1996-2003

FUNCTON COLOR LOCATON
Constant +12 Volts: RED (2) GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A N SCHEMATCS
Dome
Lights/Superv:
BLACK (-) AT ETHER PN SWTCH
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: L BLUE DRVER'S KCK PANEL ***
Power Unlock: WHTE DRVER'S KCK PANEL ***
Trunk Release: N/A
Alarm nput Wire: BLACK (-) AT ETHER PN SWTCH

NOTES: ** Without OEM Keyless Entry See Note #203 - Reverse Polarity Door Lock Diagram.
With OEM Keyless Entry See Note #202 - Positive Pulse Door Lock Diagram.




This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 58 of 90
GMC Sonoma 2004

FUNCTON COLOR LOCATON
Start: YELLOW (+) GNTON SWTCH HARNESS **
gnition #1: PNK (+) GNTON SWTCH HARNESS
gnition #2: WHTE (+) GNTON SWTCH HARNESS (ECM)
gnition #3: N/A
Accessory: ORANGE (+) GNTON SWTCH HARNESS (HEAT/AC)
Brake Light: WHTE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE AC AT POWERTRAN CONTROL MODULE *
Parking
Lights:
BROWN (+) BCM Lt. Blue plug
Headlights: N/a
Diesel Glow
Plug:

Clutch
Bypass Wire:

Notes: * WHT/BLK At Distributor gnition Module Can Also Be Used For Tach. gnition Coil And Distributor
Module Both Located On Passenger Side Of Engine. ** 1998+ Vehicle is equipped with PASSLOCK
Anti-theft system. See Note # 113 - Bypassing PASSLOCK Theft Deterrent System Diagram. ***
This Wire Powers the PCM in the Vehicle and Must Be Active in Both " Start" and "Run".

GMC Sonoma 2004

FUNCTON COLOR LOCATON
Constant +12
Volts:
RED and Red/White (2) GNTON SWTCH HARNESS
OEM Alarm
Disarm:
Lt.Green (-) BCM Purple plug
Dome
Lights/Superv:
BLACK (-) AT ETHER PN SWTCH
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: L BLUE (+) BCM Brown plug
Power Unlock: WHTE (+) BCM Brown Plug
Trunk Release: N/A
Alarm nput
Wire:
BLACK (-) AT ETHER PN SWTCH
Notes:
** Without OEM Keyless Entry See Note #203 - Reverse Polarity Door Lock Diagram. With OEM
Keyless Entry See Note #202 - Positive Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 59 of 90

SONOMA 2005 - 2006



KEY
T-
HARNESS
MMOBLZER
N/A N/A GM's PASSLOCK 2 ANT-THEFT System,

FUNCTON COLOR LOCATON
12 VOLT CONSTANT RED (+) and RED/WHTE (+) GNTON SWTCH HARNESS
STARTER YELLOW (+) GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 PNK (+) GNTON SWTCH HARNESS
GNTON 2 WHTE (+) See NOTE *4 GNTON SWTCH HARNESS
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
ORANGE (+) GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE LGHT GREEN (-) GNTON SWTCH HARNESS
PARKNG LGHTS ( - ) WHTE (-)
@ BCM, LGHT BLUE plug, Pin
A5, See NOTE *1
PARKNG LGHTS ( + ) BROWN (+)
@ BCM, LGHT BLUE plug, Pin
B6, See NOTE *1
POWER LOCK LGHT BLUE (TYPE A)
@ BCM, BROWN plug, Pin A4,
See NOTE *1
POWER UNLOCK WHTE (TYPE A)
@ BCM, BROWN Plug, Pin A3,
See NOTE *1
DOOR TRGGER See NOTE *2
@ BCM, PURPLE Plug, See
NOTE *1
DOMELGHT SUPERVSON TAN (-)
@ BCM, PURPLE Plug, Pin B4,
See NOTE *1
TRUNK RELEASE N/A
SLDNG POWER DOOR N/A
HORN BLACK (-)
@ BCM, BROWN plug, Pin A9,
See NOTE *1

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 60 of 90
TACH WHTE
@ PCM, BLUE Plug Pin 49,
See NOTE *3
WAT TO START LGHT N/A
BRAKE WHTE (+)
@ SWTCH ABOVE BRAKE
PEDAL
FACTORY ALARM DSARM LGHT GREEN (-)
@ BCM, PURPLE plug, Pin B3,
See NOTE *1
ANT-THEFT
YELLOW (+), ORANGE/BLACK
(-) and RED/WHTE (Not used)
GM's PASSLOCK 2 System,
these wires exit the gnition
Switch Tumbler together and
are in the Main gnition Switch
Harness in the Column.

EXTRA NFORMATON
NOTE *1 The BCM (Body Control Module) is located to the RGHT of the the Gas Pedal just below
the Radio, the plugs on the BCM face the DRVERS side of the vehicle. NOTE *2 This vehicle has (2)
door trigger wires, the TAN (-) at the PURPLE Plug, Pin B4 is for the DRVERS DOOR, and the
ORANGE (-) at the PURPLE Plug, Pin B2 is for the PASSENGER DOOR. When installing an ALARM
SYSTEM, use BOTH Door Trigger wires and DODE SOLATE. to connect, NOTE *3 The PCM
(Powertrain Control Module) is located on the PASSENGER FENDER. On the 2.2L engine the
WHTE tach wire is in a BLACK 80-Pin Plug, Pin 10, and on the 4.3L engine the tach wire is in a RED
32-Pin plug, Pin 20. NOTE *4 MPORTANT !!!!! this wire MUST BE CONNECTED as GNTON #2
for REMOTE STARTNG!!!!!!

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 61 of 90

Make: Model: Year:
GMC Suburban 1982-1986


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS **
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS (HEAT-A/C)
***
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: WHTE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE AT DSTRBUTOR *
Parking Lights: BROWN (+) AT LGHT SWTCH
Headlights: YELLOW (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Carburated Engine. ** See Note #300 - GM Rear Wheel Drive Vehicles *** See Note
#233 - High Current gnition Wires Diagram.

GMC Suburban 1982-1986

FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
WHTE/BLACK OR
WHTE
(-) PN SWTCH OR AT COURTESY LGHT
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: LGHT BLUE DRVER'S KCK OR BELOW SPEAKER ****
Power Unlock: BLACK/WHTE DRVER'S KCK OR BELOW SPEAKER ****
Trunk Release: N/A
Alarm nput Wire: WHTE/BLACK OR
WHTE
(-) PN SWTCH OR AT COURTESY LGHT

NOTES: **** See Note #202 - Positive Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 62 of 90

Make: Model: Year:
GMC Suburban 1987-1994


FUNCTON COLOR LOCATON
Start: YELLOW OR VOLET GNTON SWTCH HARNESS **
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS (HEAT-A/C)
***
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
(RADO/WPER)
Brake Light: WHTE (+) SWTCH ON BRAKE PEDAL BRACKET
Tach Signal: WHTE AT DSTRBUTOR OR GNTON COL *
Parking Lights: BROWN (+) AT HEADLGHT SWTCH
Headlights: YELLOW (+) HEADLGHT SWTCH OR BEAM SELECT
SW.
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * WHTE Tach Wire Also Located n Tach Test Connector Taped To Harness Near
Distributor. ** See Note #300 - GM Rear Wheel Drive Vehicles *** See Note #233 - High Current
gnition Wires Diagram.

GMC Suburban 1987-1994

FUNCTON COLOR LOCATON
Constant +12 Volts: RED AND RED GNTON SWTCH HARN./BOTH 1 CRCUT
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
WHTE (87-91)
ORG/BLK
(92-93) (-)
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS OR AT
RELAY
Power Lock: LGHT BLUE DRVER'S KCK OR BELOW SPEAKER ****
Power Unlock: BLACK/WHTE OR
BLACK
DRVER'S KCK OR BELOW SPEAKER ****
Trunk Release: N/A
Alarm nput Wire: WHTE (87-91)
ORG/BLK
(92-93) (-)

NOTES: **** See Note #202 - Positive Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 63 of 90

Make: Model: Year:
GMC Suburban 1995


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS *
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: PNK/WHTE OR WHTE GNTON SWTCH HARNESS (ECM)
gnition #3: N/A
Accessory: ORANGE GNTON SWTCH HARNESS (HEAT/AC) **
Brake Light: WHTE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal:
WHTE OR
PURPLE/WHTE
AT DSTRBUTOR
Parking Lights: BROWN (+) AT HEADLGHT SWTCH
Headlights: YELLOW (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * See Note #300 - GM Rear Wheel Drive Vehicles ** See Note #233 - High Current
gnition Wires Diagram.

GMC Suburban 1995

FUNCTON COLOR LOCATON
Constant +12 Volts: RED AND RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
WHTE (-) AT PN SWTCH OR COURTESY LGHT ***
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: LGHT BLUE DRVER'S KCK OR BELOW SPEAKER ****
Power Unlock: WHTE DRVER'S KCK OR BELOW SPEAKER ****
Trunk Release: BLACK (+) AT RELEASE SWTCH
Alarm nput Wire: WHTE (-) AT PN SWTCH OR COURTESY LGHT ***

NOTES: *** PURPLE (-) Wre Also Found At Headlight Switch. WHTE (-) Wire At Courtesy Light
Can Also Be Used For Door Trigger But Will Not Trigger Alarm f Dome Lamp Override Switch s
Turned On. **** 2 Door Without OEM Keyless Entry See Note #203 - Reverse Polarity Door Lock
Diagram. 4 Door & 2 Door With OEM Keyless Entry See Note #202 - Positive Pulse Door Lock
Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 64 of 90

Make: Model: Year:
GMC Suburban 1996-1999


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS *
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: PNK/WHTE OR WHTE GNTON SWTCH HARNESS (ECM)
gnition #3: N/A
Accessory: ORANGE GNTON SWTCH HARNESS (HEAT/AC) **
Brake Light: WHTE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE
AT COL ON PASSENGER REAR OF
ENGNE
Parking Lights: BROWN (+) AT HEADLGHT SWTCH
Headlights: YELLOW (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * 1998+ Vehicles Are Equipped With GM's PASSLOCK Anti-Theft System; See Note
#113 - Bypassing GM's PASSLOCK Passive Theft System Diagram. . ** See Note #233 - High
Current gnition Wires Diagram.

GMC Suburban 1996-1999

FUNCTON COLOR LOCATON
Constant +12 Volts: RED (2) GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A N SCHEMATCS
Dome
Lights/Superv:
PURPLE (-) 4 PN BLACK CONN. N DR. KCK PANEL***
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: L BLUE DRVER'S KCK OR BELOW SPEAKER ****
Power Unlock: WHTE DRVER'S KCK OR BELOW SPEAKER ****
Trunk Release: N/A
Alarm nput Wire: PURPLE (-) 4 PN BLACK CONN. N DR. KCK PANEL***

NOTES: *** PURPLE (-) Wre Also Found At Headlight Switch. WHTE (-) Wire At Courtesy Light
Can Also Be Used For Door Trigger But Will Not Trigger Alarm f Dome Lamp Override Switch s
Turned On. **** 2 Door Without OEM Keyless Entry See Note #203 - Reverse Polarity Door Lock
Diagram. 4 Door & 2 Door With OEM Keyless Entry See Note #202 - Positive Pulse Door Lock
Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 65 of 90

Make: Model: Year:
GMC Suburban 2000-2002


FUNCTON COLOR LOCATON
Start: YELLOW (18 AWG) GNTON SWTCH HARNESS *
gnition #1: PNK (16 AWG) GNTON SWTCH HARNESS
gnition #2: WHTE (18 AWG) GNTON SWTCH HARNESS(ECM)
gnition #3: N/A
Accessory: ORANGE GNTON SWTCH HARNESS (HEAT/AC)
Brake Light: WHTE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: VOLET/WHTE
AT PLUG ABOVE VALVE COVER ON DR.
SDE
Parking Lights: BROWN (+) 12 PN PLUG N FUSE PANEL OR AT
SWTCH
Headlights: YELLOW (+) AT HEALGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * This Vehicle s Equipped With GM's PASSLOCK Anti-Theft System; See Note #113.

GMC Suburban 2000-2002

FUNCTON COLOR LOCATON
Constant +12 Volts: RED (2) GNTON SWTCH HARNESS
OEM Alarm Disarm: GREEN N FLAT CONNECTOR N DR. KCK PANEL
Dome
Lights/Superv:
WHTE AT PLUG N CONVENENCE CENTER **
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: LT. BLUE 12 PN PLUG AT FUSE PANEL ON DR. SDE
Power Unlock: WHTE DRVER'S KCK PANEL N BODY CAVTY ***
Trunk Release: N/A
Alarm nput Wire: WHTE AT PLUG N CONVENENCE CENTER **

NOTES: ** Convenience Center s Locate Under Driver's Dash Near Fire Wall (Listen for dome
light relay). *** See Note #202 - Positive Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 66 of 90

Make: Model: Year:
GMC Typhoon 1991-1993


FUNCTON COLOR LOCATON
Start: YELLOW OR PURPLE GNTON SWTCH HARNESS **
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS (HEAT-A/C)
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: WHTE (+) SWTCH ON BRAKE PEDAL SUPPORT
BRACKET
Tach Signal: WHTE AT DSTRBUTOR *
Parking Lights: BROWN (+) AT HEADLGHT SWTCH
Headlights: YELLOW (+) HEADLGHT SWTCH OR BEAM SELECT
SW.
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Throttle Body njection. ** See Note #300 - GM Rear Wheel Drive Vehicles

GMC Typhoon 1991-1993

FUNCTON COLOR LOCATON
Constant +12 Volts: RED AND RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
WHTE (-) DRVER PN SWTCH OR COURTESY
LGHT
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS OR AT
RELAY
Power Lock: LT BLUE DRVER'S KCK OR BELOW SPEAKER ***
Power Unlock: BLK/WHT OR BLK DRVER'S KCK OR BELOW SPEAKER ***
Trunk Release: BROWN (+) REAR WNDOW RELEASE SWTCH
Alarm nput Wire: WHTE (-) DRVER PN SWTCH OR COURTESY
LGHT

NOTES: *** See Note #203 - Reverse Polarity Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 67 of 90

VANDURA 1987 -1993

KEY T-HARNESS MMOBLZER
N/A GM-3 N/A

FUNCTON COLOR LOCATON
12 VOLT CONSTANT RED (+) GNTON SWTCH HARNESS
STARTER PURPLE (+) GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 PNK (+) GNTON SWTCH HARNESS
GNTON 2 N/A
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
ORANGE (+) GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE N/A
PARKNG LGHTS ( - ) N/A
PARKNG LGHTS ( + ) BROWN (+)
@ HEADLGHT SWTCH or in
DRVERS KCK PANEL
POWER LOCK LGHT BLUE (TYPE A) N DRVERS KCK PANEL
POWER UNLOCK BLACK/WHTE (TYPE A) N DRVERS KCK PANEL
DOOR TRGGER WHTE (-)
@ PN SWTCH or COURTESY
LGHT
DOMELGHT SUPERVSON USE DOOR TRGGER
TRUNK RELEASE N/A
SLDNG POWER DOOR N/A
HORN BLACK (-)
@ STEERNG COLUMN
HARNESS
TACH WHTE @ GNTON COL

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 68 of 90

WAT TO START LGHT N/A


BRAKE WHTE (+)
@ SWTCH ABOVE BRAKE
PEDAL
FACTORY ALARM DSARM N/A
ANT-THEFT N/A




This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 69 of 90

VANDURA 1994 -1995



KEY T-HARNESS MMOBLZER
N/A GM-3 N/A

FUNCTON COLOR LOCATON
12 VOLT CONSTANT RED See NOTE *1 GNTON SWTCH HARNESS
STARTER PURPLE (+) See NOTE *1 GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 PNK (+) See NOTE *1 GNTON SWTCH HARNESS
GNTON 2 N/A
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
ORANGE (+) See NOTE *1 GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE N/A
PARKNG LGHTS ( - ) N/A
PARKNG LGHTS ( + ) BROWN (+)
@ HEADLGHT SWTCH or in
DRVERS KCK PANEL
POWER LOCK LGHT BLUE (TYPE A) N DRVERS DOOR HARNESS
POWER UNLOCK BLACK (TYPE A) N DRVERS DOOR HARNESS
DOOR TRGGER WHTE (-) @ DOOR PN SWTCH
DOMELGHT SUPERVSON USE DOOR TRGGER
TRUNK RELEASE N/A
SLDNG POWER DOOR N/A
HORN BLACK (-)
@ STEERNG COLUMN
HARNESS

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 70 of 90

TACH WHTE
@ GNTON COL or
DSTRBUTOR
WAT TO START LGHT N/A
BRAKE WHTE (+)
@ SWTCH ABOVE BRAKE
PEDAL
FACTORY ALARM DSARM N/A
ANT-THEFT N/A

EXTRA NFORMATON
NOTE *1 The GNTON SWTCH is LOCATED at the TOP OF THE STEERNG COLUMN, it may be
necessary to REMOVE the NSTRUMENT CLUSTER and DROP THE STEERNG COLUMN
(REMOVNG (2) 15mm bolts under the dash) to gain access to the GNTON SWTCH HARNESS.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 71 of 90

Make: Model: Year:
GMC Yukon 1992-1994


FUNCTON COLOR LOCATON
Start: PURPLE OR YELLOW GNTON SWTCH HARNESS *
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS (HEAT-A/C) **
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
(RADO/WPER)
Brake Light: WHTE (+) SWTCH ON BRAKE PEDAL SUPPORT
BRACKET
Tach Signal: WHTE AT DSTRBUTOR OR GNTON COL
Parking Lights: BROWN (+) AT HEADLGHT SWTCH
Headlights: YELLOW (+) HEADLGHT SWTCH OR BEAM SELECT
SW.
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * See Note #300 - GM Rear Wheel Drive Vehicles ** See Note #233 - High Current
gnition Wires Diagram.

GMC Yukon 1992-1994

FUNCTON COLOR LOCATON
Constant +12 Volts: RED AND RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
WHTE (-) PN SWTCH OR COURTESY LGHT ***
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS OR AT
RELAYS
Power Lock: LT BLUE DRVER'S KCK PANEL BELOW SPEAKER
****
Power Unlock: BLACK/WHTE OR
BLK/RED
DRVER'S KCK PANEL BELOW SPEAKER
****
Trunk Release: BROWN (+) AT REAR GLASS RELEASE SWTCH
Alarm nput Wire: WHTE (-) PN SWTCH OR COURTESY LGHT ***

NOTES: *** Use BLACK/ORANGE (-) At Pin Switch f Equipped With Auxillary Lighting Option
(ncludes Dome Lamp Kill Switch). **** See Note #203 - Reverse Polarity Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 72 of 90

Make: Model: Year:
GMC Yukon 1995


FUNCTON COLOR LOCATON
Start: YELLOW*** GNTON SWTCH HARNESS *
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: PNK/WHTE OR WHTE GNTON SWTCH HARNESS (ECM)
gnition #3: N/A
Accessory: ORANGE GNTON SWTCH HARNESS (HEAT-A/C)**
Brake Light: WHTE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal:
WHTE OR
PURPLE/WHTE
AT DSTRBUTOR
Parking Lights: BROWN (+) AT HEADLGHT SWTCH
Headlights: YELLOW (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * See Note #300 - GM Rear Wheel Drive Vehicles ** See Note #233 - High Current
gnition Wires Diagram.

GMC Yukon 1995

FUNCTON COLOR LOCATON
Constant +12 Volts: RED AND RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
WHTE (-) A ETHER PN SWTCH OR AT COURTESY LGHT ***
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: LGHT BLUE DRVER KCK PANEL OR
Power Unlock: WHTE RELAYS BESDE GAS PEDAL ****
Trunk Release: BLACK (+) AT RELEASE SWTCH
Alarm nput Wire: WHTE (-) A ETHER PN SWTCH OR AT COURTESY LGHT ***

NOTES: *** f Eqipped With Auxillary Lighting Option, Use PURPLE (-) At Any Pin Switch Or At
Dome Lamp Override Switch, Will Trigger Alarm Regardless Of Dome Lamp Switch Position. ****
See Note #202 - Positive Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 73 of 90

Make: Model: Year:
GMC Yukon 1996-1999


FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS *
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: WHTE GNTON SWTCH HARNESS (ECM)
gnition #3: N/A
Accessory: ORANGE GNTON SWTCH HARNESS (HEAT/AC) **
Brake Light: WHTE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE
AT COL ON PASSENGER REAR OF
ENGNE
Parking Lights: BROWN (+) AT HEADLGHT SWTCH
Headlights: YELLOW (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * 1998+ Vehicles Are Equipped With GM's PASSLOCK Anti-Theft System; See Note
#113 - Bypassing GM's PASSLOCK Passive Theft System Diagram. ** See Note #233 - High
Current gnition Wires Diagram.

GMC Yukon 1996-1999

FUNCTON COLOR LOCATON
Constant +12 Volts: RED (2) GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A N SCHEMATCS
Dome
Lights/Superv:
PURPLE (-) 4 PN BLACK CONN. N DR. KCK PANEL***
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: L BLUE DRVER'S KCK PANEL ****
Power Unlock: WHTE DRVER'S KCK PANEL ****
Trunk Release: N/A
Alarm nput Wire: PURPLE (-) 4 PN BLACK CONN. N DR. KCK PANEL***

NOTES: *** PURPLE (-) Wire Also Located At Headlight Switch. See Tech Notes For Additional
nformation On Dome Light. **** 2 Door Without OEM Keyless Entry See Note #203 - Reverse
Polarity Door Lock Diagram. 2 Door With OEM Keyless Entry See Note #202 - Positive Pulse
Door Lock Diagram. 4 Door With Or Without OEM Keyless See Note #202 - Positive Pulse Door
Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 74 of 90

Make: Model: Year:
GMC Yukon 2000-2002


FUNCTON COLOR LOCATON
Start: Yellow (+) gnition switch harness
gnition #1: Pink (+) gnition switch harness*
gnition #2: White (+) gnition switch harness
gnition #3: N/A
Accessory: Orange (+) gnition switch harness
Brake Light: White (+) Brake pedal switch
Tach Signal: White (AC) ECM**
Parking Lights: Brown (+) Blue plug at the BCM***
Headlights: N/A
Diesel Glow Plug: N/A
Clutch Bypass Wire: N/A

NOTES: *This vehicle is equipped with GM's Passlock Anti-Theft security system. Use a
universal alarm bypass module. **The Engine Control Module (ECM) is located near the battery,
down low, between the fan and the fender under the black plastic cover. ***The Body Control
Module (BCM) is located behind the driver side of the dash. The plugs face towards the rear of
the vehicle.

GMC Yukon 2000-2002

FUNCTON COLOR LOCATON
Constant +12 Volts: Red (+) gnition switch harness
OEM Alarm Disarm: Lt.Green (-) Purple plug at the BCM***
Dome
Lights/Superv:
N/A
OEM Horn: Black (-) Brown plug at BCM***
Power Lock: Lt.Blue (+) Brown plug at BCM***
Power Unlock: White (+) Brown plug at BCM***
Trunk Release: N/A
Alarm nput Wire: N/A

NOTES: ***The Body Control Module (BCM) is located behind the driver side of the dash. The
plugs face towards the rear of the vehicle. See Note @202 Positive Trigger Door Locks



This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 75 of 90
Make: Model: Year:
GMC Yukon 2003-2006


FUNCTON COLOR LOCATON
Start: Yello gnition Switch Harness*
gnition #1: Pink gnition Switch Harness
gnition #2: White gnition Switch Harness
gnition #3: N/A ****
Accessory: Orange gnition Switch Harness
Brake Light: Blue or White At Brake Switch
Tach Signal: White or Purple/White At PCM or nstrument Cluster*****
Parking Lights: Brown n Kick Panel
Headlights: Not Recommended
Diesel Glow Plug: N/A
Clutch Bypass Wire: N/A

NOTES: * This vehicle is equippes with PASSLOCK . Use Universal Alarm Bypass Module,
Vehicle Specifi Bypass, or See Note #113. ****All remote starters except the 2xx22 have an
ignition 3 output - it is the white/black in the 'control harness.' This wire will be used to control the
bypass module, if needed. ***** The tach wire at the instrument cluster is labeled as databus in
the vehicle schematics, but it will supply a valid tach signal.

GMC Yukon 2003-2006

FUNCTON COLOR LOCATON
Constant +12 Volts: Red and Red/White gnition Switch Harness
OEM Alarm Disarm: Green nside of Drivers Door
Dome
Lights/Superv:
White At Light Under Dash
OEM Horn: Black (-) At Steering Column Harness
Power Lock: See Note Below **
Power Unlock: See Note Below **
Trunk Release: N/A
Alarm nput Wire: White At Light Under Dash

NOTES: ** Base models may have negative triggered door locks at the BCM vehind the
headlight switch. All others need vehicle specific door lock interface, available through
DesignTechs Sales Department.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 76 of 90

YUKON 2007

KEY
T-
HARNE
SS
MMOBLZER
N/A N/A GM's PASSKEY 3 TRANSPONDER ANT-THEFT SYSTEM, and Extra gnition Key

FUNCTON COLOR LOCATON
12 VOLT CONSTANT (2) RED/BLACK (+) @ FUSE BOX
STARTER WHTE (+) See NOTE *1
@ GNTON SWTCH
HARNESS or BCM, LGHT
GREEN Plug, Pin 4 See NOTE
*2
STARTER 2 N/A
GNTON 1 PNK (+)
@ GNTON SWTCH
HARNESS or BCM, LGHT
GREEN Plug, Pin 14 See NOTE
*2
GNTON 2 N/A
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
BROWN (+)
@ GNTON SWTCH
HARNESS or BCM, LGHT
GREEN Plug, Pin 21 See NOTE
*2
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE N/A
PARKNG LGHTS ( - ) LGHT BLUE (-)
@ HEAD LGHT Switch or
BCM, NATURAL Plug, Pin 8
See NOTE *2
PARKNG LGHTS ( + )
BROWN (+) Left and BROWN
(+) Right
@ UNDER HOOD FUSE BOX,
BLACK 30-Pin Plug
POWER LOCK No nformation at this time!!
POWER UNLOCK No nformation at this time!!
DOOR TRGGER See NOTE *3
DOMELGHT SUPERVSON GRAY (+)
@ BCM, NATURAL Plug, Pin 5
See NOTE *2

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 77 of 90
TRUNK RELEASE
PNK (-) Glass and GRAY (-)
Gate See NOTE *4
@ BCM, PNK Plug, Pins 24
and 13 See NOTE *2
SLDNG POWER DOOR N/A
HORN TAN (-)
@ HORN Switch or BCM,
BROWN Plug, Pin 18 See
NOTE *2
TACH NOT PNK, BROWN or BLACK
@ ANY FUEL-NJECTOR or
GNTON COL
WAT TO START LGHT N/A
BRAKE LGHT BLUE/WHTE (+)
@ SWTCH ABOVE BRAKE or
BCM, BROWN Plug, Pin 6, See
NOTE *2
FACTORY ALARM DSARM LGHT GREEN (-)
@ DRVERS DOOR MODULE,
BROWN 16-Pin Plug, Pin 4
ANT-THEFT
GM's PK3 TRANSPONDER
ANT-THEFT SYSTEM,
Requires Bypass Module and
Extra Programmed gnition Key
@ GNTON SWTCH
TUMBLER

EXTRA NFORMATON
NOTE *1 The STARTER 1 wire, requires a (+) POSTVE thru a 1300 OHM Resistor to Start . NOTE
*2 The BCM (Body Control Module) is located to the LEFT of the STEERNG COLUMN. NOTE *3
The DRVERS DOOR TRGGER is a GRAY/BLACK (-) at the DRVERS DOOR MODULE in the
DRVERS DOOR, BROWN 16-Pin Plug, Pin 13, the PASSENGER DOOR TRGER is a
BLACK/WHTE (-) at the PASSENGER DOOR MODULE in the PASSENGER DOOR, BROWN 16-
Pin Plug, Pin 13. The DRVERS REAR DOOR TRGGER is a LGHT BLUE/BLACK (-) PNK Plug, Pin
15 and the PASSENGER REAR DOOR TRGGER is a LGHT GREEN/BLACK (-) PNK Plug, Pin 14
both wires are located in the PNK Plug on the BCM, when connecting to an ALARM SYSTEM use all
(4) FOUR wires and DODE SOLATE, . NOTE *4 TEST these wires while OPENNG the LFTGLASS
and LFTGATE from the HANDLE on the REAR HATCH of the vehicle.

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 78 of 90

Make: Model: Year:
GMC Yukon DenaIi 2003-2006


FUNCTON COLOR LOCATON
Start: Yello gnition Switch Harness*
gnition #1: Pink gnition Switch Harness
gnition #2: White gnition Switch Harness
gnition #3: N/A ****
Accessory: Orange gnition Switch Harness
Brake Light: Blue or White At Brake Switch
Tach Signal: White or Purple/White At PCM or nstrument Cluster*****
Parking Lights: Brown n Kick Panel
Headlights: Not Recommended
Diesel Glow Plug: N/A
Clutch Bypass Wire: N/A

NOTES: * This vehicle is equippes with PASSLOCK . Use Universal Alarm Bypass Module,
Vehicle Specifi Bypass, or See Note #113. ****All remote starters except the 2xx22 have an
ignition 3 output - it is the white/black in the 'control harness.' This wire will be used to control the
bypass module, if needed. ***** The tach wire at the instrument cluster is labeled as databus in
the vehicle schematics, but it will supply a valid tach signal.

GMC Yukon DenaIi 2003-2006

FUNCTON COLOR LOCATON
Constant +12 Volts: Red and Red/White gnition Switch Harness
OEM Alarm Disarm: Green nside of Drivers Door
Dome
Lights/Superv:
White At Light Under Dash
OEM Horn: Black (-) At Steering Column Harness
Power Lock: See Note Below **
Power Unlock: See Note Below **
Trunk Release: N/A
Alarm nput Wire: White At Light Under Dash

NOTES: ** Base models may have negative triggered door locks at the BCM vehind the
headlight switch. All others need vehicle specific door lock interface, available through
DesignTechs Sales Department.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 79 of 90

YUKON DENALI 2007

KEY
T-
HARNE
SS
MMOBLZER
N/A N/A GM's PASSKEY 3 TRANSPONDER ANT-THEFT SYSTEM, and Extra gnition Key

FUNCTON COLOR LOCATON
12 VOLT CONSTANT (2) RED/BLACK (+) @ FUSE BOX
STARTER WHTE (+) See NOTE *1
@ GNTON SWTCH
HARNESS or BCM, LGHT
GREEN Plug, Pin 4 See NOTE
*2
STARTER 2 N/A
GNTON 1 PNK (+)
@ GNTON SWTCH
HARNESS or BCM, LGHT
GREEN Plug, Pin 14 See NOTE
*2
GNTON 2 N/A
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
BROWN (+)
@ GNTON SWTCH
HARNESS or BCM, LGHT
GREEN Plug, Pin 21 See NOTE
*2
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE N/A
PARKNG LGHTS ( - ) LGHT BLUE (-)
@ HEAD LGHT Switch or
BCM, NATURAL Plug, Pin 8
See NOTE *2
PARKNG LGHTS ( + )
BROWN (+) Left and BROWN
(+) Right
@ UNDER HOOD FUSE BOX,
BLACK 30-Pin Plug
POWER LOCK No nformation at this time!!
POWER UNLOCK No nformation at this time!!
DOOR TRGGER See NOTE *3
DOMELGHT SUPERVSON GRAY (+)
@ BCM, NATURAL Plug, Pin 5
See NOTE *2

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 80 of 90
TRUNK RELEASE
PNK (-) Glass and GRAY (-)
Gate See NOTE *4
@ BCM, PNK Plug, Pins 24
and 13 See NOTE *2
SLDNG POWER DOOR N/A
HORN TAN (-)
@ HORN Switch or BCM,
BROWN Plug, Pin 18 See
NOTE *2
TACH NOT PNK, BROWN or BLACK
@ ANY FUEL-NJECTOR or
GNTON COL
WAT TO START LGHT N/A
BRAKE LGHT BLUE/WHTE (+)
@ SWTCH ABOVE BRAKE or
BCM, BROWN Plug, Pin 6, See
NOTE *2
FACTORY ALARM DSARM LGHT GREEN (-)
@ DRVERS DOOR MODULE,
BROWN 16-Pin Plug, Pin 4
ANT-THEFT
GM's PK3 TRANSPONDER
ANT-THEFT SYSTEM,
Requires Bypass Module and
Extra Programmed gnition Key
@ GNTON SWTCH
TUMBLER

EXTRA NFORMATON
NOTE *1 The STARTER 1 wire, requires a (+) POSTVE thru a 1300 OHM Resistor to Start . NOTE
*2 The BCM (Body Control Module) is located to the LEFT of the STEERNG COLUMN. NOTE *3
The DRVERS DOOR TRGGER is a GRAY/BLACK (-) at the DRVERS DOOR MODULE in the
DRVERS DOOR, BROWN 16-Pin Plug, Pin 13, the PASSENGER DOOR TRGER is a
BLACK/WHTE (-) at the PASSENGER DOOR MODULE in the PASSENGER DOOR, BROWN 16-
Pin Plug, Pin 13. The DRVERS REAR DOOR TRGGER is a LGHT BLUE/BLACK (-) PNK Plug, Pin
15 and the PASSENGER REAR DOOR TRGGER is a LGHT GREEN/BLACK (-) PNK Plug, Pin 14
both wires are located in the PNK Plug on the BCM, when connecting to an ALARM SYSTEM use all
(4) FOUR wires and DODE SOLATE, . NOTE *4 TEST these wires while OPENNG the LFTGLASS
and LFTGATE from the HANDLE on the REAR HATCH of the vehicle.

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 81 of 90

YUKON XL 2000 -2002

KEY
T-
HARNESS
MMOBLZER
N/A GM-11 GM's PASSLOCK 2 ANT-THEFT System, Requires Bypass Module

FUNCTON COLOR LOCATON
12 VOLT CONSTANT RED (+) GNTON SWTCH HARNESS
STARTER YELLOW (+) GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 PNK (+) GNTON SWTCH HARNESS
GNTON 2 WHTE (+) See NOTE *5 GNTON SWTCH HARNESS
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
ORANGE (+) GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE LGHT GREEN (-) GNTON SWTCH HARNESS
PARKNG LGHTS ( - ) WHTE (-)
@ BCM, LGHT BLUE plug, Pin
A5, See NOTE *1
PARKNG LGHTS ( + ) BROWN (+)
@ BCM, LGHT BLUE plug, Pin
B6, See NOTE *1
POWER LOCK LGHT BLUE (TYPE A)
@ BCM, BROWN plug, Pin A4,
See NOTE *1
POWER UNLOCK WHTE (TYPE A)
@ BCM, BROWN Plug, Pin A3,
See NOTE *1
DOOR TRGGER See NOTE *2 @ BCM, See NOTE *1
DOMELGHT SUPERVSON TAN (-) See NOTE *2
@ BCM, PURPLE Plug, Pin B4,
See NOTE *1
TRUNK RELEASE N/A

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 82 of 90

SLDNG POWER DOOR N/A


HORN BLACK (-)
@ BCM, BROWN plug, Pin A9,
See NOTE *1
TACH WHTE @ ECM, See NOTE *3
WAT TO START LGHT DARK BLUE (-) See NOTE *4
BRAKE WHTE (+)
@ SWTCH ABOVE BRAKE
PEDAL
FACTORY ALARM DSARM LGHT GREEN (-)
@ BCM, PURPLE plug, Pin B3
See NOTE *1
ANT-THEFT
YELLOW (+), ORANGE/BLACK
(-) and RED/WHTE (Not used)
GM's PASSLOCK 2 System,
these wires exit the gnition
Switch Tumbler together and
are in the Main gnition Switch
Harness in the Column.

EXTRA NFORMATON
NOTE *1 The BCM (Body Control Module) is located behind the drivers side of the dash, with the
plugs facing the rear of the vehicle. NOTE *2 This vehicle use (2) door pin triggers, the DRVERS
DOOR is a TAN (-) at the BCM, PURPLE plug, Pin B4, and for all other doors use the BLUE/WHTE
(-) at the BCM, LGHT BLUE plug , Pin B11. When connecting to an ALARM SYSTEM, use both Door
Trigger wires and DODE SOLATE. to connect, NOTE *3 The ECM (Engine Control Module) is
located near the battery, down low, between the fender and the fan, under a BLACK plastic cover. On
the 4.3L engine it is in a 20 pin connector labled RED. On the 4.8L, 5.3L and 6.0L engines it is
located at Pin 10 in the RED connector. NOTE *4 when hooking up a remote starter, if you cannot get
the (+) or (-) Wait to Start wire on the Remote Starter to work properly, you will then need to
disconnect this wire and Program the Remote Starter for the 5, 10, 15 or 20 Second Wait to Start
Timmer in the nstallation manual. NOTE *5 MPORTANT !!!!! this wire MUST BE CONNECTED as
GNTON #2 for REMOTE STARTNG!!!!!!


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 83 of 90

YUKON XL 2003 -2006



KEY
T-
HARNESS
MMOBLZER
N/A N/A GM's PASSLOCK 2 ANT-THEFT System, Requires Bypass Module

FUNCTON COLOR LOCATON
12 VOLT CONSTANT RED (+) and RED/WHTE (+) GNTON SWTCH HARNESS
STARTER YELLOW (+) GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 PNK (+) GNTON SWTCH HARNESS
GNTON 2 WHTE (+) See NOTE *5 GNTON SWTCH HARNESS
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
ORANGE (+) GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE LGHT GREEN (-) GNTON SWTCH HARNESS
PARKNG LGHTS ( - ) GRAY/BLACK (-)
@ BCM, BROWN Plug, Pin B2,
See NOTE *2
PARKNG LGHTS ( + ) BROWN (+) N DRVERS KCK PANEL
POWER LOCK See NOTE *1 S
POWER UNLOCK See NOTE *1 S
DOOR TRGGER See NOTE *3
DOMELGHT SUPERVSON GRAY/BLACK (-)
@ BCM, BLACK Plug, Pin E,
See NOTE *2
TRUNK RELEASE N/A
SLDNG POWER DOOR N/A
HORN BLACK (-)
@ BCM, GRAY Plug, Pin B9,
See NOTE *2
TACH WHTE
@ PCM, GREEN plug, Pin 10,
See NOTE *4
WAT TO START LGHT N/A

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 84 of 90
BRAKE WHTE (+)
@ SWTCH ABOVE BRAKE
PEDAL
FACTORY ALARM DSARM LGHT GREEN (-)
in DRVERS DOOR MODULE in
DRVERS DOOR
ANT-THEFT
YELLOW (+), BLACK (-) and
RED/WHTE (Not Used)
GM's PASSLOCK 2 System,
these wires exit the gnition
Switch Tumbler together and
are in the Main gnition Switch
Harness in the Column.

EXTRA NFORMATON
NOTE *1 This vehicle uses a Special Door Locking system and requires (4) extra Relays, NOTE *2
The BCM (Body Control Module) is located behind the drivers side of the dash, with the plugs facing
the rear of the vehicle. NOTE *3 This vehicle use (2) door pin triggers, the DRVERS DOOR is a
GREY/BLACK (-) at the DRVERS DOOR module in the DRVERS DOOR. The PASSENGER DOOR
is a BLACK/WHTE (-) at the PASSENGERS DOOR module in the PASSENGERS DOOR. The
DRVERS REAR DOOR is a LGHT BLUE/BLACK (-) Pin A3 and the PASSENGERS REAR DOOR is
a LGHT GREEN/BLACK (-) Pin A2, both are located at the BCM, PURPLE plug. When connecting to
an ALARM SYSTEM, use all 4 Door Trigger wires and DODE SOLATE, to connect, NOTE *4 The
PCM (Power Control Module) is located in the LEFT front of the engine compartment to the LEFT of
the fan shroud. The TACH wire is in a GREEN Plug Pin 10. NOTE *5 MPORTANT !!!!! this wire
MUST BE CONNECTED as GNTON #2 for REMOTE STARTNG!!!!!!



This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 85 of 90

YUKON XL 2007

KEY
T-
HARNE
SS
MMOBLZER
N/A N/A GM's PASSKEY 3 TRANSPONDER ANT-THEFT SYSTEM, and Extra gnition Key

FUNCTON COLOR LOCATON
12 VOLT CONSTANT (2) RED/BLACK (+) @ FUSE BOX
STARTER WHTE (+) See NOTE *1
@ GNTON SWTCH
HARNESS or BCM, LGHT
GREEN Plug, Pin 4 See NOTE
*2
STARTER 2 N/A
GNTON 1 PNK (+)
@ GNTON SWTCH
HARNESS or BCM, LGHT
GREEN Plug, Pin 14 See NOTE
*2
GNTON 2 N/A
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
BROWN (+)
@ GNTON SWTCH
HARNESS or BCM, LGHT
GREEN Plug, Pin 21 See NOTE
*2
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE N/A
PARKNG LGHTS ( - ) LGHT BLUE (-)
@ HEAD LGHT Switch or
BCM, NATURAL Plug, Pin 8
See NOTE *2
PARKNG LGHTS ( + )
BROWN (+) Left and BROWN
(+) Right
@ UNDER HOOD FUSE BOX,
BLACK 30-Pin Plug
POWER LOCK No nformation at this time!!

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 86 of 90

POWER UNLOCK No nformation at this time!!


DOOR TRGGER See NOTE *3
DOMELGHT SUPERVSON GRAY (+)
@ BCM, NATURAL Plug, Pin 5
See NOTE *2
TRUNK RELEASE
PNK (-) Glass and GRAY (-)
Gate See NOTE *4
@ BCM, PNK Plug, Pins 24
and 13 See NOTE *2
SLDNG POWER DOOR N/A
HORN TAN (-)
@ HORN Switch or BCM,
BROWN Plug, Pin 18 See
NOTE *2
TACH NOT PNK, BROWN or BLACK
@ ANY FUEL-NJECTOR or
GNTON COL
WAT TO START LGHT N/A
BRAKE LGHT BLUE/WHTE (+)
@ SWTCH ABOVE BRAKE or
BCM, BROWN Plug, Pin 6, See
NOTE *2
FACTORY ALARM DSARM LGHT GREEN (-)
@ DRVERS DOOR MODULE,
BROWN 16-Pin Plug, Pin 4
ANT-THEFT
GM's PK3 TRANSPONDER
ANT-THEFT SYSTEM,
Requires Bypass Module and
Extra Programmed gnition Key
@ GNTON SWTCH
TUMBLER

EXTRA NFORMATON
NOTE *1 The STARTER 1 wire, requires a (+) POSTVE thru a 1300 OHM Resistor to Start . NOTE
*2 The BCM (Body Control Module) is located to the LEFT of the STEERNG COLUMN. NOTE *3
The DRVERS DOOR TRGGER is a GRAY/BLACK (-) at the DRVERS DOOR MODULE in the
DRVERS DOOR, BROWN 16-Pin Plug, Pin 13, the PASSENGER DOOR TRGER is a
BLACK/WHTE (-) at the PASSENGER DOOR MODULE in the PASSENGER DOOR, BROWN 16-
Pin Plug, Pin 13. The DRVERS REAR DOOR TRGGER is a LGHT BLUE/BLACK (-) PNK Plug, Pin
15 and the PASSENGER REAR DOOR TRGGER is a LGHT GREEN/BLACK (-) PNK Plug, Pin 14
both wires are located in the PNK Plug on the BCM, when connecting to an ALARM SYSTEM use all
(4) FOUR wires and DODE SOLATE, . NOTE *4 TEST these wires while OPENNG the LFTGLASS
and LFTGATE from the HANDLE on the REAR HATCH of the vehicle.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 87 of 90

YUKON XL DENALI 2003 -2006

KEY
T-
HARNESS
MMOBLZER
N/A N/A GM's PASSLOCK 2 ANT-THEFT System, Requires Bypass Module

FUNCTON COLOR LOCATON
12 VOLT CONSTANT RED (+) and RED/WHTE (+) GNTON SWTCH HARNESS
STARTER YELLOW (+) GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 PNK (+) GNTON SWTCH HARNESS
GNTON 2 WHTE (+) See NOTE *5 GNTON SWTCH HARNESS
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
ORANGE (+) GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE LGHT GREEN (-) GNTON SWTCH HARNESS
PARKNG LGHTS ( - ) GRAY/BLACK (-)
@ BCM, BROWN Plug, Pin B2,
See NOTE *2
PARKNG LGHTS ( + ) BROWN (+) N DRVERS KCK PANEL
POWER LOCK See NOTE *1 S
POWER UNLOCK See NOTE *1 S
DOOR TRGGER See NOTE *3
DOMELGHT SUPERVSON GRAY/BLACK (-)
@ BCM, BLACK Plug, Pin E,
See NOTE *2
TRUNK RELEASE N/A
SLDNG POWER DOOR N/A
HORN BLACK (-)
@ BCM, GRAY Plug, Pin B9,
See NOTE *2
TACH WHTE
@ PCM, GREEN plug, Pin 10,
See NOTE *4
WAT TO START LGHT N/A

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 88 of 90
BRAKE WHTE (+)
@ SWTCH ABOVE BRAKE
PEDAL
FACTORY ALARM DSARM LGHT GREEN (-)
in DRVERS DOOR MODULE in
DRVERS DOOR
ANT-THEFT
YELLOW (+), BLACK (-) and
RED/WHTE (Not Used)
GM's PASSLOCK 2 System,
these wires exit the gnition
Switch Tumbler together and
are in the Main gnition Switch
Harness in the Column.

EXTRA NFORMATON
NOTE *1 This vehicle uses a Special Door Locking system and requires (4) extra Relays, NOTE *2
The BCM (Body Control Module) is located behind the drivers side of the dash, with the plugs facing
the rear of the vehicle. NOTE *3 This vehicle use (2) door pin triggers, the DRVERS DOOR is a
GREY/BLACK (-) at the DRVERS DOOR module in the DRVERS DOOR. The PASSENGER DOOR
is a BLACK/WHTE (-) at the PASSENGERS DOOR module in the PASSENGERS DOOR. The
DRVERS REAR DOOR is a LGHT BLUE/BLACK (-) Pin A3 and the PASSENGERS REAR DOOR is
a LGHT GREEN/BLACK (-) Pin A2, both are located at the BCM, PURPLE plug. When connecting to
an ALARM SYSTEM, use all 4 Door Trigger wires and DODE SOLATE, to connect, NOTE *4 The
PCM (Power Control Module) is located in the LEFT front of the engine compartment to the LEFT of
the fan shroud. The TACH wire is in a GREEN Plug Pin 10. NOTE *5 MPORTANT !!!!! this wire
MUST BE CONNECTED as GNTON #2 for REMOTE STARTNG!!!!!!



This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 89 of 90

YUKON XL DINALI 2007

KEY
T-
HARNE
SS
MMOBLZER
N/A N/A GM's PASSKEY 3 TRANSPONDER ANT-THEFT SYSTEM, and Extra gnition Key

FUNCTON COLOR LOCATON
12 VOLT CONSTANT (2) RED/BLACK (+) @ FUSE BOX
STARTER WHTE (+) See NOTE *1
@ GNTON SWTCH
HARNESS or BCM, LGHT
GREEN Plug, Pin 4 See NOTE
*2
STARTER 2 N/A
GNTON 1 PNK (+)
@ GNTON SWTCH
HARNESS or BCM, LGHT
GREEN Plug, Pin 14 See NOTE
*2
GNTON 2 N/A
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
BROWN (+)
@ GNTON SWTCH
HARNESS or BCM, LGHT
GREEN Plug, Pin 21 See NOTE
*2
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE N/A
PARKNG LGHTS ( - ) LGHT BLUE (-)
@ HEAD LGHT Switch or
BCM, NATURAL Plug, Pin 8
See NOTE *2
PARKNG LGHTS ( + )
BROWN (+) Left and BROWN
(+) Right
@ UNDER HOOD FUSE BOX,
BLACK 30-Pin Plug
POWER LOCK No nformation at this time!!

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
GMC - Copyright 2004-2006 - 12 Volt Resource LLC Page 90 of 90

POWER UNLOCK No nformation at this time!!


DOOR TRGGER See NOTE *3
DOMELGHT SUPERVSON GRAY (+)
@ BCM, NATURAL Plug, Pin 5
See NOTE *2

You might also like