You are on page 1of 2

ES-Actuator-and-Valve-Body-Kit

For Residential or Commercial Radiant Heating and Snow Melt Applications


Job Name Job Location Engineer Approval Contractor Approval Contractors P.O. No. Representative

Actuator and Valve Body Kit


Size: 3/4" (19.1 mm) Sweat
Actuators and Valve Body Kits are a convenient way to add zone valve control where conditions warrant.

Specifications
Actuators are normally closed and will open when power is applied. Travel time for the actuators is approximately 90 seconds to close the end switch. Each actuator has four wires: two for power, two for an end switch (see wiring diagrams on reverse). A typical 40-VA transformer can power 12 actuators. Valve Bodies are of machined brass and sized to fit 3/4" (19.1 mm) copper pipe. Technical Details Voltage Amperage Power Endswitch Rating Minimum Ambient Temperature Maximum Ambient Temperature Minimum Storage Temperature Maximum Storage Temperature Valve Travel Time Blue/Brown Wire Black/Black Wire 24 VAC 700 mA (0.7 A) 2.5 VA (2.5 W) 175 W 32F (0.0C) 122F (50.0C) -77F (-60.5C) 140F (60.0C) 90 Seconds 24 VAC End Switch

Actuator and Valve Body

Actuator

Valve indicator window (red = closed, black = open) Swivel connector

Installation Parameters
1. Remove the actuator from the valve body. 2. Prep location the valve body is to be added. 3. Sweat valve body to copper return line. 4. When valve body cools sufficiently, re-attach actuator. 5.  Make the wiring connections according to the wiring diagram on reverse.

Black lead Brown lead Blue lead Black lead

Replacement Actuators are available separately.


!

Qty Description Actuator and Valve Body Kit, 3/4" (19.1 mm)

Order # 0955113

CAUTION

This Engineering Sheet is not intended to provide full installation instructions and safety information. In order to avoid property damage or injury, please refer to the complete installation manual and product safety information provided with the product.

OT FOR

TA

BLE

Watts product specifications in U.S. customary units and metric are approximate and are provided for reference only. For precise measurements, please contact Watts Technical Service. Watts reserves the right to change or modify product design, construction, specifications, or materials without prior notice and without incurring any obligation to make such changes and modifications on Watts products previously or subsequently sold.

PO

Thermostat

Actuator

Incoming line voltage to the pump (based on pump requirement)

Relay 24 VAC coil Less than 16 VA


Brown Blue Black Black

120 VAC input

120 VAC to 240 VAC transformer (minimum 10 VA)

Neutral

Valve actuators wired to circulator via an external relay.

Application Example - Three Zone Valves on Return with Actuators.

ES-Actuator-and-Valve-Body-Kit 1142

USA: No. Andover, MA Tel. (855) 699-2887 Fax: (978) 794-1848 radiant.watts.com Canada: Burlington, ONT. Tel. (905) 332-4090 Fax: (905) 332-7068 radiant.watts.com

2011 Watts

You might also like