Professional Documents
Culture Documents
Vignola Gazebo
Item Num: PC-10811
***Important***
Use the parts list above and check the contents of your box for any missing parts. Do NOT return to place of purchase. Call the toll free number below for customer service and warranty information:
888-474-2770
Page 2
Assembly Instructions
Thank you for choosing a Pacific Currents Product! Please make sure you have carefully read and understood these assembly instructions before you begin. Prepare the work area
First, choose and measure the final location where you would like to place the product so that it will fit a 15 x 15 square with 11 height clearance. Then, choose an assembly area as close as possible to this final location and large enough to layout and pre-assemble all the parts for this Gazebo. Check all the parts with the parts list on the previous page and make sure that none are missing. If you discover any missing parts, please visit www.pacificcurrentsinc.com or call 888-474-2770. Save your sales receipt as you will need this to obtain replacement parts. It is highly recommended that you cover the work surface with a tarp or other fabric to prevent scratches to the finish during assembly. You will need these additional tools: 10mm socket, 10mm ratchet, combination wrench, and a ladder. Once a unit has been pre-assembled in each step, please set it aside until further instructions. IMPORTANT Do not completely tighten any bolts or nuts until the last step prior to attaching the canvas top.
(see fig. 1)
Figure 1:
4 Decorative Panels (Part A4) 4 Panel Frame Columns (Part A1) 4 Panel Frame Columns (Part A3) 4 Panel Frame Bars (Part A5) 8 20 mm Bolt and Washer (Part S) 8 40 mm Bolt Assemblies (Part U) 8 60 mm Bolt Assemblies (Part X) Gather the required parts for this step. Fasten one Frame Column (A1 or A3) at a time to the Decorative Panel (A4) with the bolts and nuts provided (U and X). Do not fully tighten the bolts at this time. Finally, attach the top Frame Bar and secure loosely with the bolts (S) at both ends. Repeat above for remaining 3 panels.
(fig. 3, 4)
Page 4
Figure 5:
Figure 6:
Page 5
4 Roof Frame Corner Bars (Part J) 4 Roof Frame Corner Bars (Part K) 4 Roof Frame Corner Bars (Part P1) 4 Roof Frame Corner Bars (Part P2) 32 32 mm Bolt Assemblies (Part R) 8 Corner Bar Sleeve Connectors (Part Z)
Insert Roof Frame Corner Bar (J) into end of Roof Frame Corner Bar (K) and line up the pre-drilled holes. Add the Corner Bar Sleeve Connector and loosely fasten using 4 sets of Bolts/Washers/Nuts (R). Repeat for remaining 3 sets of Roof Frame Corner Bars. Insert Roof Vent Support Bars (P1) into end of Roof Vent Support Bars (P2) and line up the pre-drilled holes. Join P1 and P2 with a corner bar sleeve connector (Part Z) and loosely secure with 4 sets of Bolts/Washers/Nuts/ (Part R). Repeat the above for remaining 3 sets of Roof Frame Corner Bars.
Figure 8:
Step 6 (P1+P2)
Figure 9:
Page 6
Your gazebo should now resemble the image below. Please check to make sure all parts are in their respective locations.
Q: Does the gazebo include the fabric top? A: Yes! All our gazebos are sold with a weather and UV light resistant polyester fabric top.
Q: Will the gazebo move or blow away in strong winds? A: Several features of our design were considered to allow the gazebo to remain very stable across a wide range of weather conditions. The four vents in the canopy top help to allow low to medium winds to pass through the covering. However, if you install the gazebo in an area where strong winds are persistent, it is advisable to take further steps to fasten the gazebo to the ground. If the gazebo is installed over a soft natural surface (grass or dirt), you may drive metal stakes (included) through the holes located at the bottom of the panels and into the ground. If the gazebo is installed over a hard surface (wooden decks or concrete patios) it will be necessary to separately purchase screws or bolts and nuts to affix the frame to your installation surface. Please visit your local hardware store for more options. For all customers, we highly recommend that you remove your canopy top in cases of severe inclement weather such as thunderstorms. Please exercise good judgement.
Q: I like being outdoors, but cannot stay for long because of mosquitoes. Are bug screens available for my gazebo? A: Yes! Bug screens for all gazebo models are available separately for purchase as an accessory.
Q: I live in an area that snows in the winter. Should I be concerned about the weight of snow on my gazebo? A: You do not have to disassemble the gazebo during winter months. However, to prevent damage to your gazebo frame from heavy snow loads, remove the canvas top and store it in a dry location until spring.
Your satisfaction is very important to us. Please contact us at info@pacificcurrentsinc.com if you have any questions or visit www.pacificcurrentsinc.com for more information.
Page 8
Care Instructions:
The polyester top (Canvas Top) can be machine washed using a small amount of detergent. Do not machine dry or use bleach. Top may also be spray rinsed while attached to Gazebo and lightly scrubbed with a soft broom. Do not use hard abrasive cleansers to scrub.
All components carry a one year limited warranty from date of purchase against defects in material and workmanship arising under normal use. This warranty does not cover normal wear and tear, nor weathering due to climate and other environmental factors, nor does it cover failure resulting from accident, misuse, abuse, neglect , mishandling, alteration or modification, failure to maintain, or damage that is attributed to acts of nature. This warranty does not cover incidental or consequential damages resulting from use of product, or losses arising out of any breach of this warranty other than the replacement parts. Fulfillments of this warrant shall only include replacement of parts damaged while inside original packing materials or a defective allowance with the place of purchase to be arranged at the discretion of Pacific Currents Inc.
This warranty only extends to the original purchaser. Proof of purchase (such as sales receipt) will be required before warranty performance is rendered.
Customer Service:
Please contact us should you have any questions concerning assembly, care information, warranty coverage, and missing or defective parts.
Page 9