You are on page 1of 1

FLEXOVIT USA, INC

Material Safety Data Sheet


Used to comply with OSHA's Hazard Communication Standard, 29 CFR 1910.1200

Flammability

0 SECTION I - NAME AND PRODUCT


Company Name: Flexovit Abrasives Address: 1305 Eden-Evans Road

0 Health 0

0 Reactivity

Angola, NY 14006
Phone: 800-689-3539 Date Updated: 11/1/2011 Product: Quick-Change Sanding Discs

Hazard Rating NFPA HAZARD RATING CODE SECTION II - COMPOSITION OSHA Regulate OSHA PEL ACGIH TLV Other Limits Carcinogen

Ingredient

% By Weight

Cas #

This material contains no ingredients known to retain hazardous properties of which is defined as hazardous by OSHA SECTION III - PHYSICAL/CHEMICAL CHARACTERISTICS
Physical State Vapor Pressure (mm HG) Vapor Density (Air=1) Solubility in Water Odor/Appearance N/A Boiling Point N/A N/A N/A Freezing Point Melting Point % Volatile N/A N/A N/A N/A Specific Gravity (H2O=1) Odor Threshold pH Evaporation Rate N/A N/A N/A N/A N/A

Endless mini discs of cloth backing

Coefficient of Water/Oil Distribution

SECTION IV - FIRE AND EXPLOSION DATA


Means Of Extinction Flammable Limits Flash Point Water, CO2, Dry chemical N/A N/A Lower And Upper Explosion Limits Special Fire Fighting Procedures Unusual Fire or Explosion Hazards N/A None None

SECTION V - REACTIVITY DATA


Stability: Stable Hazardous Decomposition or Byproducts: None Incompatability (Materials to Avoid): Hazardous Polymerization: None Will not Occur

SECTION VI - HEALTH HAZARD DATA Route(s) of Entry


Inhalation

Signs and Symptoms of Exposure


Coughing, shortness of breath Choking sensation if allowed to become very dusty. (Nuisance dust, Respirable-5 mg/m3)

Emergency & First-Aid Procedures


Remove to fresh air Obtain first aid or medical attention N/A

Skin

May cause irritation by abrasion

SECTION VII- STORAGE HANDLING AND USE PROCEDURES


Steps to be taken in case material is released or spilled: Normal clean-up procedures Waste Disposal Method: Standard landfill consistent with applicable federal, state, and local laws. Precautions to be taken in handling and storing: Store at room temperature, relative humidity 25 to 50% 60 to 80% w/ ventilation Other precautions: Normal precaution should be taken for nuisance dust particulates generated during grinding operation

SECTION VIII- CONTROL MEASURES Protection


Respiratory Ventilation Protective Gloves Eye Protection Hearing Protection Hygienic Practices Other

Requirements and Referrals


If needed Local exhaust: Recommended Recommended while handling OSHA 29 CFR 1910.33 N/A N/A N/A Mechanical (General): Recommended

COMPANY USE
The information and recommendations set forth herein are taken from sources and references believed to be accurate & complete as of the date hereof. However, Flexovit U.S.A., Inc. makes no expressed or implied warranty with respect to the accuracy of the information or the suitability of the recommendations, and assumes no liability to any user thereof.

Flexovit Quick-Change Sanding Discs

pg 1 of 1

You might also like