Professional Documents
Culture Documents
iMac (24-inch)
Updated 23 April 2007
iMac (24-inch)
Contents Take Apart
General Information 6
Whats New 6 23 April 2007 6 13 March 2007 6 22 February 2007 6 16 February 2007 6 January 2007 6 Product Views 7 How to identify your iMac 9 Note About Images in This Manual 9 Tools Required 10 Orientation 10 Serial Number Location 10 Safety 11 Opening the Computer 12 EMI Shielding 13
14
Front Bezel 19 Camera Board 23 Battery 27 Ambient Light Sensor (ALS) Board IR (Infrared) Board IR/ALS Cable IR/ALS Shield 36 40 43 33 30
ii
Optical Temperature Sensor 110 AirPort Extreme Card 113 Bluetooth Antenna Cable 120 Logic Board 125 Hard Drive Fan Speaker, Left 140 143
Camera/Microphone Cable AirPort Antennas Clutch Cover 171 Clutch Mechanism 174 162
179
iii
188
Additional Procedures
Installing the VESA Mount
Link to Instructions 198
198
Troubleshooting
General Information 206
Serial Number 206 DDR Memory 207 Diagnostic LEDs 209
Views
iMac (24-inch)Upper Exploded View 239 iMac (24-inch)Lower Exploded View 240
Screw Chart
241
iv
Service Source
Take Apart
iMac (24-inch)
3.
Disconnect the Bluetooth antenna from the left side of the card.
Preliminary Steps
Before you begin, remove the following: Access door Front bezel
Part Location
922-7010
3.
Disconnect the LVDS cable and inverter cable from the logic board.
4.
Remove the eight 8-mm long T8 screws from the sides of the panel frame.
922-7815
5.
Peel up the strip of tape at the lower corners of the LCD panel.