Professional Documents
Culture Documents
id
BMGS 1740.Containerized
1905.0 KVA / 1524.0 KW 1740.0 KVA / 1392.0 KW 1560.0 KVA / 1248.0 KW 2040.0 KVA / 1632.0 KW 1845.0 KVA / 1476.0 KW 1570.0 KVA / 1256.0 KW 5300 x 2590 x 3104 [ L x W x H ] 13.300 Neon Blue .245 - 7432 Space Black .245 - 2852
General
Applicable Condition Ambient Temperature Altitude Place of Installation 5 - 40 Up to 1500 meters above sea level In Door
Shop Test [Diesel engine running test shall be carried out by the following items] Starting Test 10 minutes Load Test Standard BMJ Governor Test Governor Test should be done along with respective governor control Safety stop device test Standard BMJ
SAE J620C. 21 in except screw size SAE J617b. No.00 except screw size Rubber Type
Paper element type Donaldson FTG13L X 4 pcs Paper element type with screen cap Mitsubishi TD Type Jacket Water cooled type Plated element type 4131 cfm 1500 rpm [Prime Rating] 4484 cfm 1800 rpm [Prime Rating]
Air Cooled type with heat insulator Up side direction type [For Blow off to outside of engine room] 600 mm H2O or 23.6 In H2O
DGS/BMJ-ENG/2010
Page 1
www.bmj.co.id
Lubricating System Oil Pump Capacity Oil Pump Lube oil pressure Max oil temperature Quantity of oil [approx] Cooling System Water Pump Capacity of water pump Max coolant temp Max cooling air temp Coolant Flow Coolant capacity Fuel System Injection Pump Max Section head Fuel filter Control System Governor Actuator Magnetic Pick Up Starting System Starting motor Alternator Fuel limit Solenoid Gear pump type 480 liters/min at 1500 rpm 580 liters/min at 1800 rpm 4.0 6.5 kg/cm 110 230 liters
Gear drive centrifugal pump 1650 liters at 1500 rpm 1850 liters at 1800 rpm 98 40 [ TAA type ] 1650 liters/min 1500 rpm [Prime Rating] 1850 liters/min 1800 rpm [Prime Rating] 445 liters
Bosch type PS8 X 2 75 mm Hg [of feed pump] Paper element cartridge type
Electronic Speed Governor [Toho XS.400B] Speed Droop 0 5% adjustable DC24V 20% Current Consumption With 2 pole connector
DC24V, 7.5KW X 2 pcs DC24VDC, 30 A with voltage regulator Fuel limit at engine starting Energize to fuel control until rated speed
Safety Device Low oil pressure High Water temperature Over speed
Noise Level [1 mtr height and distance] 109 dB [A] 1500 rpm [Prime Rating] 109 dB [A] 1800 rpm [Prime Rating] Standard Instruments Lubricating oil pressure gauge, Lubricating oil temperature gauge, Exhaust gas temperature gauge, Tachometer.
Generator Data
Model Type Phase Pole Temp Rise Voltage Star Voltage Regulation AVR Type Insulation System Protection Rated Power Factor Stator Winding Winding Pitch Winding Leads Stator Wdg Resistance Rotor Wdg Resistance RFI Suppression Waveform Distortion Max overspeed Newage Generator Stamford PI 734 E 3 4 125 240V/415V 0.5% with 4% engine governor MX.321 Class H IP23 0.8 Double Layer Trap Two Thirds 6 0.00093 Ohms / Phase at 22 Star Conection 1.65 Ohms at 22 BS EN 61000-6-2 and BS EN 61000-6-4, VDE0875G, VDE0875N No Load < 1.5% Non distorting balanced linear load < 5.0% 2250 Rev / Min
DGS/BMJ-ENG/2010
Page 2
www.bmj.co.id
Bearing Drive End Bearing Non Drive End Coupling Type Weight Comp Gen Weight Wound Stator Weight Wound Rotor WR Inertia Shipping Weight Telephone Interface Cooling Air Ball 6228 [ ISO ] Ball 6319 [ ISO ] Single Bearing 3541 kg 1852 kg 1494 kg 45.5872 kgm 3614 kg [Gross] THF <2% 2.64 m / sec 5600 cfm
Standard Equipment
Industrial Silencer Material Exhaust Flexible Battery Battery Cable Battery Rack Flexible Fuel Line Tool Exhaust Thermometer IS 355 / 14 Steel Plate Tch. 4 / Pipe Sch.40 [ Flange JIS Std ] EF 355 / 14 [ Stainless Steel material with flange JIS Std ] 24 Volt DC 95 mm x 1.5 mtr x 4pcs 95 mm x 0.5 mtr x 2pcs Standard Inlet and Return mounted on the DG [included fuel valve] Standard Tool YKS-600, 100 - 650
DGS/BMJ-ENG/2010
Page 3
www.bmj.co.id
Protection Device Low Oil Pressure, High Water Temperature, Over speed / Over HZ, Open circuit Oil and Temperature sensing, Under Speed / Under Hz, Lost AC signal, HZ Fail, Run Failure, Stop Failure. Warning indicate, Excitation warning, Charger warning, Low Battery warning, Trip Lock warning Automatic or manual Start Stop
Control System
2.
DGCP 2002
Model DGCP 2002 [ Digital ] The DGCP 2002 provides for the fully automatic or manual control of a standby generator whilst also allowing for remote monitoring through the use of a customer supplied modem. The unit has similar control to the DGCP 2002 including 4 inputs and 4 outputs but with the addition of 3 phase generator voltage and current measurement, display and fault tripping. The unit also offers shutdowns as standard for over frequency, under frequency, under voltage and over current. Complete with display for displaying, 15 instruments, Error message and programming and useful signals for generator set management. Indoor type mounted on the Skid Base IP54 Voltmeter, Ammeter, Frequency meter, Operating Hour meter, Tachometer, Speed Adjuster, Oil Press Gauge, DC Volt, Water Temp Gauge, Emergency Stop, Charging Indicator Lamp, Low Oil Pressure, High Water Temperature, Over speed / Over HZ, Open circuit Oil and Temperature sensing, Under Speed / Under Hz, Lost AC signal, HZ Fail, Run Failure, Stop Failure, Under / Over Voltage and Over Current. Warning indicate, Excitation warning, Charger warning, Low Battery warning, Trip Lock warning Automatic or manual Start Stop, programmable with PC. Programming of parameters [threshold, time counts, etc] made easy by dip switch. 5 completely programmable fault available [times, polarity, possibility of stopping and massage about the fault]. Programmable weekly auto test
Protection Device
Control System
Optional Equipment
Residential Silencer Digital Setting Unit Type CT Droop Kit Generator Heater Bearing Temperature RS 355 / 14 ND-SB1 [ 04410-31600 ] HC 7 HC7
DGS/BMJ-ENG/2010
Page 4