You are on page 1of 12

Make a single click to prompt

CENTRIFUGAL

CASTING

Submitted to Mr. Jagtar Singh Deptt of Mechanical Engg GTBIT,New Delhi

Prestented by Parminder Singh CSE 1


00413202711

CENTRIFUGAL CASTING
In this process molten metal is poured in the mould and allowed to solidify while the mould is rotating. Metal is poured into the centre of the mould at its axis of rotation. Due to centrifugal force the liquid metal is thrown out towards the periphery.

PREREQIUSTIES
Mould Material
Steel Cast Iron Graphite Sand Rotation Speed of Centrifugal Mould about 1000 rpm A Centrifugal Casting Machine.

A CENTRIFUGAL CASTING MACHINE

PROCEDURE
1) The Mould wall is coated with a refractory ceramic coating (applying Ceramic Slurry , spinning, dying , baking). 2) Starting rotation of the mould at a pre determined speed. 3) Pouring of Molten metal directly into the mould (no gating system is employed). 4) The mould is stopped after the casting has been solidified. 5) Extraction of the casting from the mould.

CHARACTERISTICS OF CENTRIFUGAL CASTING

1) The casting is relatively free from defects. 2) Non metallic impurities which segregate toward the bore can be machined off. 3) Less loss of metal in tundish compared to that in gating and risering in conventional and sand casting. 4) Better mechanical properties. 5) Production rate is high. 6) Can be employed to manufacture bimetallic pipes. 7) Centrifugal casting process can be used for fabricating functionally gradient metal matrix composite material.

DEFECTS IN THE CENTRIFUGAL CASTING


Conventional static casting defects like internal shrinkage, gas porosity and nonmetallic inclusions are less likely to occur in centrifugal casting. Hot Tears Hot tears are developed in centrifugal castings for which the highest rotation speeds are used. Longitudinal tears occur when contraction of casting combined with the expansion of the mould, generates hoop stresses exceeding the cohesive strength of the metal at temperatures in the solidus region. Segregation - Centrifugal castings are under various forms of segregation thus pushing less dense constituents at centre. Banding Sometimes castings produce zones of segregated low melting point constituents such as eutectic phases and sulphide and oxide inclusions. Various theories explain this, one states vibration is the main cause of banding.

APPLICATIONS OF CENTRIFUGAL CASTING


Pipes for water gas sewage. Bearing Bushes. Cylinder Liners. Piston rings Paper making rollers Clutch Plates. Pulleys.

SOME CENTRIFUGAL CASTINGS

CENTRIFUGAL CASTING SET UP


Water Nozzles Tundish

Mould Roller Mould Cover

Rotameter

POURING OPERATION IN CENTRIFUGAL CASTING

Ladle

Platinum/ Platinum 10% Rhodium thermocouple

Molten steel poured into the tundish

You might also like