You are on page 1of 27

BASIC Config & Crosconect E-line & ELAN Service

RTN

- Login U2000WebLCTV100R003C00SPC100_en_win32_x86
User Name : admin
Password : admin

- Click Ne Search
- Click Advanced search (For To Add NE ID)

- Block NE ID
- Click Add NE

- Login to NE ID
- User Name : lct
- Password : password

- View LCT NE After Login

- IF / ODU Configuration ( click link Configuration)

- Input Link Configuration data based on the design engineer and link budget

- For the service type Hybrid :


* click microwave Interface
* Click General Attributes
* Change port mode to Layer 2
* Click Apply

- For the service type Hybrid :


* click microwave Interface
* Click Layer 2 Attributes
* Change Tag service for the Tag Aware (But The Tag service base on the design engineer)
* Click Apply

- For the service type Hybrid :


* click Ethernet Interface
* Click Layer 2 Attributes
* Change 4-EM6T-1 (Port 1 & Port 2) Tag service for the Access (if the port allocation for BTS 2G or 3G)
* Click Apply

- Set the system clock source priority (Choice the ISU2 priority base on Design engineer)

- Set the E-LAN Service


* Click Ethernet Service management
* Click E-LAN Service
* Create New E-LAN Service (Data Base On Design Engineer)

- Create NE E-Lan Service


* Input The Service ID
* Input Service Name
* choice The BPDU (Not Transparently, Transmitted)
* choice TAG Type (C-Awared)
* Self learning MAC Address Is The Enabled
* Get UNI Port

- Get UNI Port


* Choice the Board Type 3-ISU2-1 and input the VLAN ID
* Choice the Board Type 4-EM6T-3(Port-3) For The BTS 2G and Input VLAN BTS 2G
* Choice the Board Type 4-EM6T-3(Port-4) For The BTS 3G and Input VLAN BTS 3G
* Click OK

- Click OK After Get UNI Port

- View LCT After Create E-LAN Service

- Set the E-LINE Service


* Click Ethernet Service management
* Click E-LINE Service
* Create New E-LINE Service (Data Base On Design Engineer)

- Create NE E-Line Service


* Input The Service ID * Choice Source Interface (3-ISU2-1)
* Get UNI Port
* Input Source VLAN ID (Example VLAN ID 6 For BTS2G)
* Input Service Name * Choice Sink Interface (4-EM6F-3 Port-3 for BTS 2G)
* choice The Direction (UNI_UNI) * Input Sink VLAN ID (Example VLAN ID 6 For BTS2G)
* choice The BPDU (Not Transparent)

- LB Test For The Check E-LAN or E-Line Service already OK


* Click Ethernet OAM Management
* Click Ethernet Service OAM
* Create Maintenance Domain (Create NEW Or Default)
* Create NEW Maintenance Association
* Create NEW MEP Point
* Click OAM and Choice The LB Test

- LB Test already ok is the loserate 0

- Test Ping laptop to laptop


* Change Default Vlan ID port to VLAN ID Based on Design engineer

- Connect your laptop to 4-EM6F-3 port 3 or any port will your test ping
- open your cmd ping to laptop
- ping your ip laptop far end

- Create Split Horizon Group for ring protection (based on ELAN service)
* click Ethernet service management
* Choice E-Lan Service
* Click Split horizon group

- Choice for the ISU2 and EM6F Port to selected port list(Based on Design Engineer)

- View After create split horizon group

You might also like