You are on page 1of 13

ACTIVE MOBILE DETECTOR

SYSTEM

ABSTRACT
In this project we used ring detector, EMI
detector, Bluetooth, PIC Microcontroller. When
people use their mobiles ring detector finds its
frequency and gives signal to the controller then
controller gives intimation to the Bluetooth and
buzzer unit.EMI detector is used to fine the
density of the incoming or outgoing signal.
Bluetooth is used to intimate the user when
mobile is in use which is shown in the application
developed in our android mobile. If mobile phones
are used in the ring detector range then the alarm
starts rising.

INTRODUCTION
Nowadays everyone has mobile
phones but people, doesnt care
about the places to use the mobile
phones. So that, atmosphere of the
place has been changed.
This project has designed to avoid
this problem and find the mobile
phones, which is in use.

COMPONENTS

MICROCONTROLLER
POWER SUPPLY
MOBILE DETECTOR
EMI DETECTOR
LCD
RELAY
BLUETOOTH
ANDROID APP

MICROCONTROLLER
Specification
RISC architecture
Operating frequency 020 MHz
Power supply voltage
2.0-5.5V
Power-Saving Sleep Mode
Brown-out Reset (BOR)
with software control
option
35 input/output pins

Pin Detail

POWER SUPPLY
Specification
Output Current up to
1A
Output Voltages of
5v & 12v
Thermal Overload
Protection
Short Circuit
Protection
Output Transistor
Safe Operating Area
Protection

Block Diagram

MOBILE DETECTOR
Specification
Operating range up to
0.75 to 1 meters.
The transmission
frequency of mobile
phones ranges from
0.9 to 3 GHz with a
wavelength of 3.3 to
10 cm.

Block Diagram

EMI DETECTOR
Specification

Electromagnetic
interference
(EMI) is the branch of electrical
engineering concerned with the
unintentional
generation,
propagation and reception of
electromagnetic energy which
may cause unwanted effects such
as electromagnetic interference
(EMI) or even physical damage in
operational equipment.

Block Diagram

RELAY
Definition
Relays
are
simple
switches which are
operated
both
electrically
and
mechanically. Relays
consist
of
a
n
electromagnet
and
also a set of contacts.
The
switching
mechanism is carried
out with the help of
the electromagnet.

Block Diagram

LCD
Specification
Display Mode: STN, BLUB
Display Formate: 16 Character
x 2 Line
Viewing Direction: 6 OClock
Input Data: 4-Bits or 8-Bits
interface available
Display Font : 5 x 8 Dots
Power Supply : Single Power
Supply (5V10%)
Driving Scheme :
1/16Duty,1/5Bias
BACKLIGHT SIDE
LED WHITE

Block Diagram

BLUETOOTH
Specification
Typical -80dBm sensitivity
Up to +4dBm RF transmit
power
Low Power 1.8V Operation
,1.8 to 3.6V I/O
PIO control
UART interface with
programmable baud rate
With integrated antenna
With edge connector

Block Diagram

ANDROID APP
Specification

BLUETERM
Android
application is required
to show the result of
the mobile detector
output.

Block Diagram

CONCLUSION
If the mobile is in active detector
detects the mobile successfully and
the result is shown in the developed
android application.

You might also like