Professional Documents
Culture Documents
MBTS3900
Local MBTS Commissioning
introduction
www.huawei.com
We Need:
Note:
First the Engineer will move to the site and get the ESN from the BBU during the pre-
installation & provide it back to Huawei Integration Team (OMCR).
The NI team will activate the DHCP Function and assign the IP to the BTS.
We Need:
• Do not remove the USB flash drive during the period from
plugging in the flash drive to the duration of normal operation
of the base station. Otherwise, the file load fails.
• Check with BSC integration team whether the BSC can Ping to
the BTS IP.
HUAWEI TECHNOLOGIES CO., LTD. Huawei Confidential
Use LMT for MBTS Commissioning
To use the LMT to log in to the base station, perform the following
steps:
• Connect the LMT to the base station.
• USB-Ethernet adaption cable to connect the Ethernet port on
the computer where the LMT is installed to the UMPT in the
BBU3900.
1. Download the FTP server software. (Optional. Perform this step only when there is
no FTP server at the LMT computer.)
2. In the upper right corner of the LMT main window, click FTP Tool. The File
Download-Security Warning dialog box is displayed.
3. Click Save to save the FTP server software SFTPServer.exe to the LMT computer.
4. Double-click SFTPServer.exe. SFTPServer.exe is decompressed into an SFTPServer
folder.
5. Open SFTPServer. Double-click SFTPServer.exe to start the FTP server. The icon is
displayed on the right side of the taskbar after the FTP server is started.
6. Configure the FTP server.
• Set User name, Password, Working directory, the default user name is admin
and the default password is hwbs@com. Set Working directory to the root
directory of the FTP server, which is D:\FTP, and retain default values for other
parameters.
• Click OK. The FTP server is successfully configured
• Click Execute
• After the base station restarts, run the LST VER command to check
whether all modes have been loaded with the software of the target
version. If not, run the DLD SOFTWARE command to redownload the
software and then run the ACT SOFTWARE command to activate the
software.
• If no operation is required on the LMT, log out of the LMT according to the
following steps: Click Logout in the toolbar in the LMT main window. The
Confirm dialog box is displayed.
• Click Yes. The LMT is disconnected from the base station. A dialog box for
logging in to the LMT is displayed.
• Close the browser to exit the LMT